Volkswagen - Routan :: Gas Pedal Stuck To The Floor When Going Very Slowly
Apr 5, 2016
201w Routan SE 50000 miles. Past several months the gas pedal has gotten stuck to the floor four times. Always happens when going very slowly and romping on the pedal. Last time was today, 4/5/2016, when I was stopped at a round about and had to quickly accelerate as noone in our area knows how to navigate one. The pedal immediately stuck to the floor halfway around the round about and disengaged after I tapped on it. Hope this isn't a known issue cause I haven't gotten a recall notice for this piece of crap.
View 1 Replies
Advertisement
In the first instance of this problem, my brake pedal was stuck to the floor. By pumping it a few times, it gradually released and rose to the proper level. Brakes then seemed to work fine for a couple of weeks, until I reversed out of a parking space, but could not brake the car when I shifted into drive. I pushed the brake pedal to the floor, but could not stop until I ran over two large boulders that, stopped the car short of a big tree.
My mechanic doesn't know exactly what went wrong, but is replacing the brake cylinder. I fervently hope that fixes the problem! What could it be?
View 4 Replies
I have a 11' VW Routan and just started having the following issue:
Minimal amount of heat, even after the temp gauge indicates that the engine is up to operating temperature. On cold days the car warms up fine and sometimes I get very hot air heat (normal) coming from the vents then all of sudden the air goes cold or lukewarm. I need to stop the van, turn off the ignition and restart the van for the heat to come back. But every once in a while; while the cold air is coming out, it does hot again. What the problem(s?) might be?
View 5 Replies
I purchased a new 2009 VW Routan back in 2009. Things went well for roughly the first 3 years. About 7 months ago the car just shutdown while driving. I pulled over and it started up again. I mentioned it to the dealer when taking it in for maintenance and they couldn't find a problem. It again happened to my wife with our 2 little kids in the back. The car just shut off while driving and she couldnt start it again for a few minutes and the obviously concerned to drive it anywhere. We took it the the VW dealer service about 2 weeks ago right after the incident.
They had it for about a week and replaced the battery and some electrical systems. It worked for a week and the same thing happened again today! It's back at the VW dealer service department. Now I have zero confidence in this car and that the service department is capable of fixing the issue to begin with. I've read about a recall for the 2010 model for this issue and I'm gravely concerned I have a lemon on my hands and against a wall with no recourse. What are my options? I want to have VW replace it. It's only 3.5 years old and I'm not going to keep driving a car that can randomly shut down.
View 19 Replies
I have a 2000 SCrew KR F150. A couple of weeks ago I noticed the brake pedal was slowly going to the floor while at a red light. I pulled over and popped the hood checked the fluid reservoir. It was full, so obviously no wheel cylinder issues or fluid loss. I haven't had a chance to tear into it yet.
View 14 Replies
We recently purchased a (used) 2010 Volkswagen Routan with approximately 40k miles. Almost immediately we noticed a loud noise whenever we began to slow down in city traffic. The noise is loudest after the car has been driven for a while. It sounds like metal knocking around. The dealership claims the brake pads are causing this noise. They said the pads are perfectly good but are two different brands and this is what is causing the sound. I do not believe brake pads would continue to make this noise after 3 months if they were good. I am also not convinced it is the brake pads at all.
View 1 Replies
My clutch pedal went all the way to the floor. The engine was missing first and then that problem happened with the clutch. I had the car towed to my business, I checked it the other day and the pedal was up. The clutch still doesn't engage.
View 6 Replies
1987 F-350 460 Auto Trans. Brake Pedal slowly going to the floor. Stopped at a red light yesterday on a slight down hill and I noticed the brake pedal slowly going to the floor. I had to put the truck in Park to avoid bumping into the car in front of me. I checked brake fluid level and still at the full level, check rims for brake fluid leak from brake cylinder, none. Could my master cyclinder need rebuilding or is my vacume diaphragm going. Not sure thats what its called.
View 14 Replies
Brand new 2012 jetta TDI (less than 1,000 miles). Standard, 6 speed. A few weeks ago, I went to brake, and my pedal went all the way to the floor (no resistance) w/o slowing me down. I let the pedal out (after freaking out a little), and when i went to try again, the brakes kicked in. I was a block from home, so I continued to drive, pulled in to park, and it happened again. Left foot on the clutch, right foot went to brake and went all the way to the floor. Took it straight to the dealer. They checked it, drove it, checked it again. Couldn't find anything.
I've driven about 500 miles since, with no incident. Then, it happened again. My brake pedal literally touched the floor, and didn't even slow me down. I tried pumping. Nothing. Took the pedal all the way out, and then recompressed- worked fine. Drove it to the dealer, happened one more time on the way (had to pull the ebrake to stop).
They have had it 2 days and still can't find anything wrong. I've been driving VWs since I got my license. I've never even owned an automatic, so the whole "maybe you were pressing the clutch instead of the brake" comment is out of the question. What is going on?!
View 12 Replies
I have a problem about which the mechanics I have asked are baffled: In cool, cloudy or sunny weather, my brakes and break-pedal pressure are fine (the mechanics have said I have good fluid, brakes, etc.--they can find nothing wrong--and, of course, it never has a problem when they test-drive my car). However, when the weather warms up and it's a bright, sunny day, my brake pedal loses pressure and slowly sinks to the floor--a dangerous thing at intersections. There's slight pressure if I pump the pedal constantly while at a light; but, without pumping, the pedal immediately sinks to the floor.
This is a real problem, because this problem always occurs right when mechanics are not near or not open for business--and none I've talked to have ever heard of such a problem. The bright, hot sun's affect seems to be key, because if it's 80 degrees outside and cloudy, I don't have the issue--but, then again, I don't usually run the air conditioner if it's cloudy. As such, I'm not positive; but, this may be tied to when I turn on the air conditioner--as though the two share the same vacuum system.
View 3 Replies
I don't know what's going on maybe some body can shed a little light on this. If you hold the brake pedal down for a long period of time you can feel the pedal slowly go to the floor. So no problem I'll change the master cylinder bleed everything brand new fluid. Don't drive it much we let the sister in law drive it we'll I jump back into it the other day to go to Home Depot and once again I notice it still does it. Could the hydra brake booster be bleeding by or what's else could be causing this it's driving me insane. I really can't imagine the hydra booster causing a problem but it's new to me. I was thinking about bleeding the brakes again thinking there maybe there's air but I have run 2 bottles of brake fluid through how much more??
View 8 Replies
So over the weekend my clutch pedal stuck to the floor 2 times and would not come all the way up on several occasions. It has since then stopped doing it. I am wondering if I should bleed my clutch or not. Flush and change fluid?
Just concerned it may turn worse.
View 16 Replies
Facts: 1999 Vw passat 1.8t
1 year ago, clutch pedal would not come up off the floor, no life in the pedal.
Problem: Clutch master cylinder, replaced.
6 months ago, clutch finally went bad. Took car to clutch shop, replaced clutch kit(found out after i payed that they only turned the dual-mass flywheel... ). Get car from clutch shop, the clutch pedal came up only 2-3 inches off the floor by itself but you could lift the pedal with your hand or foot, and it would come back up all the way, but it was life-less. It was not pulling fluid in. It was catching extremely low. I called the shop, they said that it was just because it was a new clutch and it would get better. I didn't believe them.
Two days ago, I got into my car and couldn't get it into gear. Clutch pedal would go down with the same amount of force as before. Took it back to the clutch shop and explained the history with the clutch master and then them doing the clutch kit. They said it wasn't bleeding properly and they're not sure if its going to have problems again. Car is working now, but I am concerned that it will have similar problems again.
The tech who fixed it said he pumped fluid into it extremely hard, and that's what made the pedal come up all the way (no longer stops 2 inches off the floor) and its going into gear just fine now. What the problem might have been? Block in the hydraulic lines? If this is the case, does forcing fluid through it fix it?
View 2 Replies
1998 Passat 1.8T FWD. My clutch pedal is stuck to the floor and wont spring back up. I can't seem to find the little tank to check the clutch fluid. I have heard the it uses the same tank as the brake lines do, but the tank that holds the brake fluid is full. Can it be the slave cylinder is gone? or just got a air pocket in the line?
View 1 Replies
I have a 2003 Jetta GLI. Thus morning driving into work my clutch pedal stuck to the floor. I was able to pull it back it and make it to work, but when i got to work i noticed fluid dripping from underneath my car.
View 4 Replies
I've been driving manual 12 years, all my driving life, and been in 10+ manual vehicles during that time, including a 10+ year stint in a 1.8T Passat with a 5-speed.
In all that time, and all those experiences, I've never replaced a clutch, damaged a clutch, or had one problem. In fact, I consider myself a very good operator of the manual transmission.
This is preface to my current situation. 2009 Tiguan (early build) 2.0T 6M, driving at 57mph in 6th gear - downshift to 4th to pass a truck and WHAM. Grinding, confusion, and then the clutch pedal stuck straight to the floor. Glide to a stop on the side of the bayou road.
Totally immobile vehicle. Impossible to shift into gear, or get the pedal off the floor except by pulling. Smell of acrid smoke.
VW dealership says "we're doing a courtesy warranty repair" on the clutch, flywheel and bearings, as if it's my fault. Impossible. This is a mechanical defect if I ever saw one.
View 9 Replies
Ok, did an intake manifold cleaning on my 99 Accord the other day, and now I have problems...
Long story short, some time ago my car started to have a very rough idle. Took me awhile to find the problem. Turned out the air hose, between the filter and throttle body, had developed a big hole on the underside. So I replaced it and while I was at it used some throttle body cleaner, spraying into the intake manifold chamber. Lot of junk blew out the tailpipe. The car ran much better, but the idle could still be a little rough. I ran it that way for awhile, and finally the other day decided there was probably still some junk in there and it was time to really clean it out. So I took ff the throttle body and intake manifold housing. There was a lot of junk in there! The small intake on the passenger side was completely clogged shut. (I understand this isn't surprising on these cars.) I used a bunch of rags and 2 cans of Valvoline throttle body cleaner and a lot of elbow grease and cleaned it out. I was thinking to myself that whatever I didn't get with the rags flushed through OK, but I didn't want to take the whole intake manifold out.
So I put it all back together. (I took a video before I started, so I'm pretty sure it's all back together right.) But now I have problems. The car starts. It idles fine mostly, but can be a bit rough. But the trouble starts when I put the pedal down. If I do it in Park, well, if I push it quick the engine just dies. If I push it slow, the engine revs then quits, revs and quits, over and over. Similar if it's in gear. If I push it hard, the engine stalls. If I push it gentle, it revs up, but chugs along a bit.
I've run some seafoam through it, thinking it was clogged up with all that junk, and sure enough, lots of smoke comes out, but nothing is improving so far. What have I done wrong?
View 19 Replies
I have a 2012 Volvo S60 with an intermittent problem. Sometimes when I am moving slowly (probably 5 to 10 mph) and turning the wheel, I'll feel a thumping under my feet (more to the left side of the floor). It has happened when I start moving, but I seem to notice it more often as I'm stopping -- perhaps only because I'm more likely to be turning at slow speeds when stopping (e.g. pulling into a parking space).
The dealer looked for the problem, but found absolutely nothing. This has been going on for over a year now and I'd like to figure it out in case I'm heading to a bigger problem. Btw, when I say intermittent, it may happen a few times over a day or two, then nothing for the rest of the month.
View 10 Replies
I was leaving a training class today and the cover on my gas pedal got stuck, I came close to a truck. (new car + big truck = not good) i stomped on the gas a couple of time and got it to release. I was not in a high traffic area.
View 24 Replies
2006 Passat, 6 speed manual,113,000 kms. Driving to work this morning and I noticed every few shifts that the clutch pedal rebounded slowly when released. Then in traffic stuck to the floor and I had to physically pry it back with the side of my foot. Worked fine for a few more shifts then same thing again.
View 4 Replies
I just replaced pads and rotors on my 2000 Passat GLX. Everything went fine, i got done, pumped the pedal 10-15 times, took it for a test drive. When I depress the pedal, it goes all the way to the floor, the car pulls right, then left, and slowly stops. At this point, if I hit the brakes again, it feels normal.
I figured it just needed a few minutes, I drove it for about 45 minutes, and it never got any better. I have changed the brakes several times before and never seen anything like this before.
View 6 Replies
