Toyota - Sienna :: 2003 - Replacing CA Catalytic Converter
Feb 14, 2011
Chk engine light is on. Checked it at Advance Auto and indicated either cat or the O2 sensor (rear). So, I went to replace the O2 sensor and learned the hard way that you can't just unscrew the nut. I torqued off the stud to which the O2 sensor attaches. Muffler shop told me you need to heat up the stud/nut first to remove it. Oh well, lesson learned. So, I'm looking at replacing the pipe with the catalytic converter attached since I can't seem to fix the broken stud (or actually get the one I didn't break off). The problem is, my car is apparently a CA model and has the special cat on it. I live in VA. What sort of problems might I run into if I replaced the cat with a non-CA version? They are significantly less expensive. This is for a 2003 Toyota Siienna
View 1 Replies
Advertisement
My wife and I have a 1997 Honda Accord, roughly 260k miles. A few months back the Check Engine light came on, diagnostic came back with P0420, typically indicating the catalytic converter is shot. Who am I to argue, it was an factory part. So we replaced that with an inexpensive Magnaflow converter. (don't have the part number on me); this was 5 days ago. Today my wife takes the car in for inspection. Check Engine is still on with the same code. The guy at the testing station begins laughing at my wife when she says we only spent about 200 in parts and labour on the new converter. I'm inclined to think that since we already replaced the converter that I should be looking somewhere else (O2 sensor maybe). But I also don't want to just start throwing parts at it. Do I have a case here? I would really prefer not to spend $1000 on a car that old with that many miles on it just to pass inspection.
View 4 Replies
06 Camry SE I4
I had to replace my catalytic converter because of the code I was getting. It wasn't difficult to do, but took me a while because I had to transfer the thread rods to the new CAT. Once the new CAT was installed, I went to test her out, but noticed that the car all of a sudden, has no electrical power. Nothing at all. I checked all fuses and nothing is blown. The only electrical I messed with on the car was the O2 sensor.
Car has a brand new battery from yesterday. The only thing I didn't do is install a support bracket on one side, because it was missing a bolt and one thread rod was stuck in the old CAT, i couldn't remove it.
A friend suggested that the missing bracket may be causing a ground issue. Is this true?
View 7 Replies
Heard a funny intermittent rattle and my mechanic told me that my check engine light should be going on any time now as my cat converter is bad. The part is about a thousand bucks! Looked on line and see some aftermarket ones from walker and some other retailers. My car has 103K miles on it,.
View 17 Replies
I have some serious work that needs to be done on my car. The catalytic converter needs replacing, and the valve cover gasket and cam adjuster seals need to be replaced. This work falls under their respective warranties. However, I'm wondering if I should have the water pump and timing belt done at the same time as I have 77000+ miles on my car. Is there anything else that would be good to do at the same time as this work. I would be going back to the VW service center for these repairs. Would it save me any money to do this all together?
View 4 Replies
I recently had the catalytic converter replaced on my 1999 Toyota Corolla and the gas mileage dropped from about 28 mpg to 21 mpg.
View 18 Replies
Okay, my wife has a '99 Toyota Sienna with over 200 k miles. Recently, it has began making a loud exhaust noise. I looked at the exhaust system and cannot see any obvious holes. Also, her check engine light has been on for a while. I checked it and it said misfire in cylinder 5 (can't remember the code). Changed plugs and all, still the light. It also idles very high. There's no rotten egg smell that I can tell, but she does say that it seems like it doesn't have a lot of power when accelerating.
View 4 Replies
My Toyota Tundra 2011, driven enough to haul a horse locally (6000 plus miles) is now unable to go above 30 mph, it was fine last week. Toyota dealer says it is both of the air injection units and switch. Of course it is out of warranty 3 months.
View 10 Replies
1996 4runner here (187,500miles), with weld in after market cat (on when purchased, with less than 1000 mile on it). started throwing the 420 code beginning of last summer. Replaced both O2 sensors and same results. Was coming on after every 30-40 miles after resetting, replaced wires, plugs, cleaned throttle body started coming on ever 120 miles or so. Now in the middle of winter it has gone 450 miles and still has not come back on?? Does the winter fuel blends in Georgia, or cold more dense air make a difference on cat performance? Still plan to replace it with a direct fit with a warranty but curious if I am overlooking something.
View 6 Replies
Toyota says the code is P0420 and the Catalytic Converter is rattling under heavy acceleration showing the Catalytic converter is bad and should be replaced. Toyota wants 2,334.00 which seems very high to me. Is it the Catalytic converter? The car is a 2004 Toyota Prius.
View 12 Replies
I had my local garage do their electronic check when my check engine light came on. They said the code they got indicated a failed catalytic converter and quoted me $720.00 for a California compliant replacement, including labor. I live in Connecticut. I'd like to take a few days to get a second opinion and second quote, but the garage manager said that driving it in this condition would risk fouling the oxygen sensor, which I recently replaced for a couple hundred bucks.
Should I be concerned about fouling the oxygen sensor by continuing to drive the car? 2000 Toyota Camry...
I looked under the car and the rear attachment bolts to the converter are rusted beyond recognition. I'm tempted to try replacing it myself but it may be a bit beyond my skills.
View 7 Replies
My wife's car is a 2002 Prius, 149 k miles. Lately the check engine light has been coming on. I took it to the dealership, and their assessment is that the catalytic converter needs to be replaced. They are recommending about $2,000 + of repairs. While I am contemplating the practicality of investing that much in keeping this car going I'm wondering if it harmful or dangerous to continue operating this vehicle.
View 12 Replies
Yesterday my 1995 Toyota Corolla (which runs well otherwise) started making the loudest rumbling exhaust sound I've ever heard whenever I stepped on the gas pedal. It also felt like it had trouble accelerating when I would try to get going after a stop. I took it to a mechanic right away, who says it needs a new catalytic converter and resonator pipe.
My boyfriend says this is a repair he could do. He has done some car repair and worked with a mechanic before, so I am considering trusting him on that, but I don't know what types of repairs he's done before and I know he has never worked on this model. What would you take into consideration whether or not it would be safe to attempt this repair at home?
View 19 Replies
Thumping noise in rear passenger side. I removed pads and rotors, inspected and found nothing wrong. I decided to replace the new rotor with same and the thumping is still there, but only with the brakes being used. Nothing felt in the brake pedel and the the van stops fine. So why the thumping noise?
View 4 Replies
I have a Toyota Sienna 2008 mini-van. I need to replace my broken passenger side rear view mirror.
View 5 Replies
I recently had my catalytic converter replaced with a non-OEM cat. The check engine light came on and a different shop (different from the shop that replaced the cat) said that it will keep coming on because I had the cat replaced with a non-OEM cat.
View 3 Replies
I have a 2001 VT GTI with 155K miles on it. It is in very good condition. I have loved the car except for the high maintenance costs that typically seem to be associated with VWs.
I found out this week after my check engine light came on that the car needs a new catalytic converter and a new new secondary air pump.
Let's assume that this diagnosis is correct and the repair is accurate for the sake of this posting (and I have no doubt it is). In other words, I don't want to get my question derailed on that issue.
The car has new Michelin tires on it and runs well. The problem is that it will fail the state emissions test I am required to take next December, and I will either be forced to have the car repaired or will not be able to get updated license tabs (isn't that sweet?!).
It seems that I have a few options:
1. Get the repair done (ouch) and keep driving the car for a few more years. Repair cost is about what the market value of the car is (from what I have seen).
2. Sell the car "as-is" between now and December and see what cash I can get out of it. Any buyer will discount the value of the vehicle based on the repairs needed. Of course, then I'll need a replacement vehicle of some sort.
View 16 Replies
See related guides and technical advice from our community experts:
How to Replace a Catalytic Converter
Step by step instructions for do-it-yourself repairs
Browse all: Air Intake and Exhaust Guides
View 9 Replies
I have a 2000 Lincoln Town Car with a single exhaust system, part of/attached to the frontal area of the exhaust "Y" pipe are two lumps with heat shields, the muffler is obvious in the mid-section of the car, but are those "lumps" the catalytic converters, and if so, why two when the older cars had only one?
View 2 Replies
Someone put sugar in my gas tank so I had it worked on at the Dodge place they replaced my fuel pump..fuel filter cleaned the tank..flushed the lines cleaned my injectors and replaced the plugs..I went to pick it up I barely made it a mile down the road I had no power and a lady flagged me down to tell me to pull over because I had sparks coming from the bottom of my van I looked under the van and the catalytic converter was red like hit coals the Dodge place is telling me its my flex plate? I think they are misdiagnosing the issue because before the sugar issue I had no problems with my van?
View 14 Replies
I have a 2002 Toyota Prius that is currently in limp mode...
Took it to the dealer for diagnostics and they said the Catalytic Converter has failed...So I went online, bought a new one and replaced it. The symptoms prior the Cat replacement were still there...mpg loss, power loss, and exhaust air was not exiting the end of the pipe but actually leaking out the connection point where the Cat and the manifold met.
View 7 Replies
