Toyota - Corolla :: Sputtering / Rough Idle After EGR Vacuum Check Valve Replaced
Sep 20, 2012
I replaced my EGR valve vacuum check valve, but now started getting sputtering/rough idle. I'm pretty sure the direction of the vacuum check valve is correct, but I tried both ways to be sure and still got the sputtering at idle.
The old vacuum check valve didn't give me the sputter. I only replaced it because it was melted and I'm not sure it was working. I included a photo of it. It's orange and black.
View 12 Replies
Advertisement
My wife has a stock 03 Passat 1.8t.
1. The car seems to shift too soon from 2nd to 3rd and i can hear the turbo drop pressure. It sounds like a quiet blow off 3 or 4 times when it shifts from 2nd to 3rd.
2. There is a vacuum control valve that sits on top of the air cleaner box and it ticks a lot. it has a electric plug going to it.
3. The car has a rough idle while in drive and sometimes shifts hard. I changed plugs, trans flush and filter change.
I would take the car to a VW dealer but the closest one is about a hour away and my wife needs the car.
View 1 Replies
I have a check engine light on the car and in the past it has been bad gas or a vacuum leak. Dealer says on toyota that is not possible.
View 3 Replies
I am working on a 2003 toyota matrix 1zz-fe automatic.
Replaced engine ran good for 20 miles, rough idle as if vacuum leak but no vacuum leaks to be found. If I disconnect and plug the vacuum hose that pulls from the air intake is smooths out and runs good.
Some reading suggests that it is the idle air control any?
View 19 Replies
I just replaced fuel pump and tps on my 1989 Dodge Dakota 4 cyl truck. Now it idles rough and the check engine light came on. I have removed battery cable to reset computer but did no good. What could be the problem now? I have since replaced the plug wires and distrib cap and it is flashing 3 5 5 twice now?
View 10 Replies
I have a 2000 Corolla with about 147,000 miles. At idle it runs very rough, but can accelerate up to about 50 mph. Then it starts to cough and wheeze and run roughly again and won't accelerate any further. It feels like the engine will shake itself off its mounts, so I slow down and stay under 50 mph. I replaced spark plugs and a repair place hooked it up to a computer. They then told me it needed about 1800 dollars worth of repairs to replace the valve cam I think they said. I'm skeptical and wonder if it just needs a tune up, . It has not had one since I bought it at 128,000 miles, and II don't know how long it had been prior to that.
View 5 Replies
I need to put a check valve into the vacuum line that runs to the gas tank. I know that this line is somewhere in the rear passenger side of the engine compartment, but there's so many lines there that I find myself confused when I look at it.
View 1 Replies
Basically when the car is in D and when i am stopped with the brakes pressed on at a stop sign or a red light, the car starts vibrating and i can see the the rpm going down and then receiving back up and going down again something when the car is in R. its a 2009 toyota corolla le 90k miles. when the headlights are on, the rpm stays high so the car does not vibrate or anything. other than this the car runs perfectly fine.
View 1 Replies
My exhaust system was replaced on my 2005 Corolla in August. After driving it for just a few days, there was a shaking when the car idled. The mechanic replaced two engine mounts and the idle was much worse! He said it was ok to drive, so I started on my planned trip across the country. In Denver I took it to a mechanic at the Toyota dealer and they adjusted the throttle. It was better for a while, maybe a week and 1,000 miles. Now it is worse than ever! Having gotten two totally different causes from mechanics, I am not sure what to do next.
Also just before the exhaust sytem went, I had the 60,000 mile service done and had the car totally checked out by both Toyota, and an independent mechanic who specilizes in Japanese cars. After a car wash in California, the maintence required light came on.
What is going on?
View 8 Replies
I have a 1993 Geo Prizm (Toyota Corolla) that idles roughly and lopes only when the engine is fully warmed up to operating temp. I changed the plugs, and wires are only 1 year old and seem to be in good shape. I suspected a vacuum leak, but have not been able to find one.
View 4 Replies
I fill my gas tank to 100% but I don't pump it again and overfill it like most people do after the pump stops. I then proceed to start the car. Initially it revs up and starts fine but when it revs back down to idle it does a rough idling (and sometimes it stalls). To get around the stall, I would restart and rev the engine to 3000 rpm for about 2 mins and it would be fine enough that I can drive away without it stalling but after a mile the rough idling stops and everything is back to normal. I replaced the PCV valve and it worked for about a year but it all came back again. I am stumped and every mechanic gives me a different reason and none of the reasons are even definite. It's one of those "lets try this and see what happens". One more thing, the car runs fine. It only happens when I pump more than 75% of the tank.
View 5 Replies
I have a 1997 Corolla with 150k miles.
I had my catalytic converter and flex pipe replaced this summer. Lately, my car has been idling rough. While stuck in some horrific stop and go traffic three weeks ago, it started to make noises as if it would stall out. It didn't, but it still sometimes makes those noises.
The car seems fine on the highway. No loss of power. I did think that the hood felt too warm on a recent trip, but the temperature gauge in the car showed no issue.
The car hesitated when I tried to start it last week, but normally starts fine. It was the first cold day of the year.
I saw some white smoke come out of the tailpipe last week. It only happened once. Coolant and oil levels are fine. The spark plugs look good.
The fill pipe has been leaking gas for several months. It leaks if the tank is more than half full and it drips a bit of gas when I fill up. Two mechanics have not been able to find the leak and have told me not to replace it until it is a problem, given the age of my car.
I took it to a mechanic today (not the one who replaced the cat). He told me that the rough idling is due to the new flex pipe being shorter than what was originally there. He assured me that the car is fine to drive long distances and that there was nothing wrong with it. There's no check engine light or anything on the dash to indicate a problem.
I should be relieved, but I'm not. I've lost confidence in my car. Can the stalling noises and rough idling be explained away by a changed exhaust system? Or are these signs of a problem about to happen?
View 6 Replies
I have a '98 Ford F-150 XLT, 2WD, Short bed, Ext. cab, 4.6L, automatic trans. with 65,000 orig. miles. I bought this truck new. When I have the A/C or heater or just outside air coming in through the dash or floor vents, the air will switch to coming out of the defrosters when I accelerate and then the air will return to it's normal position when I let up on the gas. Is this caused by a bad vacuum check valve and if so where is it located and what does it look like??
View 11 Replies
Question, I have a 2003 VW Golf GLS 2.0L AHV (5 speed). The brake vacuum line is cracked after the check valve on the intake side. I looked up the part number on the hose (at work and don't have it on me at the moment), did some research and noticed some revisions to that part number. Eventually settled on [URL] ..... (I ordered a new one since I needed to order a few things). Needless to say, I am beginning to think I ordered wrong.
I noticed that the check valve on the new hose has a 3rd piece that a smaller hose looks to clamp on? The check valve that is in my car doesn't have that. Did I order the wrong part? or did I need to be a cap?
View 3 Replies
I have an 2002 Volkswagen GTi 337 edition with the 1.8t engine in it. My check engine light came on so I went to my local autozone to check the code and that's what code it threw on the ODBII sensor. It says my problem could be a "failed clutch vacuum vent valve switch". It also revs about 100-200 rpms extra in between shifts and I'm not a mechanic but know a little about cars. I just don't know if I should replace the OEM clutch safety switch or what I should do about this.
View 19 Replies
After replacing the fuel filter, O2 sensor, and checking plugs and wires and the rotor, my 91 toyota corolla is still sputtering and its driving me nuts.
View 1 Replies
I have a 2001 f150 5.4 liter 2 wheel drive super crew that idles rough with surges in the idle. Weird thing is it only does it when it's 55 degrees or below. So it's fine now in the heat but winter is coming and the colder it is the worse the idle. Replaced maf sensor.
View 2 Replies
09 tiguan that was bought in august of this year as a certified pre owned and has a warranty on it until 60k miles or 2014. Recently there has been some issues with the car stalling out and sometimes having a very low rough idle and then the idle will pick up and the car will surge slightly then it will be fine for a while. I have my suspicions that it is because this is my fiance's car and she has been putting mid grade gas in the car lately. Also we cannot get the fuel door to open now is there any tricks on getting it open?
View 3 Replies
ok,up to yesterday, my wife's car started and ran fine. but we had not driven it in about 3weeks, and it was on empty. well, my kids would listen to the radio and, i think, starting it while we were at work. anyway, they ran it out of gas. so put gas in it, 3gallons, turned the key on and off a couple of times to get a good prime. started it up, died, i figured not enough fuel, yet tried again. started, but started spitting and sputtering and idling really ruff, had to hold to the floor to keep it running. removed the maf. it started and did the same. finally, i held down the gas and brake at the same time, took off to the store, got gas, but it died half way there. got it to the pump, put more gas thinking that's the problem. nope, the same. got it home, but when i let off the gas, it idles like it's not getting fuel and dies. so, any clue what it is? remember, 3 weeks ago it ran fine.
View 1 Replies
2003 Elantra gt 90,0000 miles manual transmission. Rough idle under 1000 rpm it smooths out completely above 1000 rpm.
Also the engine makes a ticking noise from a cold start up. It stops making the ticking noise after 1500rpm or when the engine warms up.
Occasionally the car has a sputtering backfire. This happens when I park the car after being on the highway.
Replaced the plugs, wires, and the pcv valve. Dropped the oil pan and it and the oil pump pick up screen were clean.
The only check engine light to come on was for the speed sensor. It has since gone out on it's own.
View 17 Replies
When the idle control valve is replaced does the ECU have to relearn the settings?
View 2 Replies
