Toyota - Camry :: 2002 Won't Start After Fill The Tank
Oct 8, 2012
Background: My 02 camry (155k) ran great but I noticed grease/oil on the front of the engine so I had a local mechanic take a look. He replaced the front valve cover gasket, timing belt, and while he was in there, the water pump. He made me take it to the dealer to reset/recalibrate the stability control sensor because after disconnecting the battery to perform the work my "VSC", "trac off" and check engine lights were on. I got it back along with a list of work they thought I needed (replace the rear valve cover gasket, dog bone engine mount, and a bunch of bs I don't need).
Problem: Quickly my check engine light is back on. I fill up gas and I can't get it to turn over. The owner of the shop gets it to turn over by gassing it a bunch while turning the key. My mechanic later tells me the check engine light is due to a bum gas cap. He replaces that and the dog bone mount. Next day check engine is back on AND the next time I get gas the same thing happens - it won't turn over until I gas it, then it turns over and stalls a few times until I really gas it and it turns over and takes. Every other time I try to start the car it turns over first try. Both times I filled up I wasn't close to running out of gas or anything. I don't think the gas cap or the fuel injectors went bad coincidentally the same day the dude had his hands in the engine.
View 8 Replies
Advertisement
I just had the engine in my 2001 Toyota Celica replaced with a rebuild at 145,000 miles (the original engine was burning oil). It runs fine but now every time I fill the tank with gas and start the car it runs for about 15 seconds then dies. This goes on about four times then it runs fine. After the initial dying eposoide the car runs fine until i fill-up again (i usually fill-up when i have avout 1/4 tank left). Before the engine replacement I had no problem like this. The mechanic thought the problem was the fuel pump and replace it and the filter and inspected the tank for debris. I am still having the problem
View 10 Replies
I have a 2002 Toyota Camry XLE 4 cylinder. I made a mess today, filled 13 galleons of Diesel in my gasoline Camry. It ran fine for 5 mins and then stopped.
I am planning to drain the fuel tank. I see one i hope fuel line in the hood which I plan to open using a wrench and drain the Fuel tank. Is that right?
Also do I need to do any other things immediately? I was thinking may be I will change fuel filter also.
View 14 Replies
As title says, I cannot fill up tank without pump cutting off every few seconds.
View 2 Replies
I have a problem with the starting system on my 2002 Camry LE 4-cylinder. My problem started a few weeks ago. I drove it to the store, about five miles away, did my shopping, got back in the car, started it up and drove back toward home but stopped again to get gasoline. After filling the tank, the car wouldn't start. I turned the key but nothing happened. No noise, nothing. The starter motor wasn't turning over the engine. Thinking back, when I started my trip, the starting seemed a little weak but the car was sitting for a few days and it was cold out so I didn't make too much of that symptom.
So over the next half an hour, I tried starting it a few more times but got nothing but silence. So I called for a tow and $150 later I had my car back home. I put a load tester on the battery and it checked out fine. So I eliminated that part of the starting system being a problem. The next day, just out of curiosity, I tried starting it again and it fired up right away. The motor ran fine and I let it warm up for a while but I didn't go anywhere. I repeated this same procedure a few times over the past couple of weeks and each time the motor started up but again, I didn't chance going anywhere. However since I had some other maintenance projects I needed to get done on it and my wife has a 2014 Camry, having the 2002 out of service was inconvenient, but not an emergency.
So yesterday, with my maintenance projects done, I took the 2002 for a little test ride. Once again, it started up without a problem and I took my ride around the block. When I got home, I shut the motor off and went inside to grab a few tools. I came back outside, tried starting up the motor and got nothing. No start and no sound but the slight hum of the electric fuel pump. I tried a few more times with no success and then gave up for the evening. This morning, right before taking the other car to work, I tried starting it again just out of curiosity and once again, the motor fired right away. So this sequence of events tells me that something in the starting system is being impacted by heat when the motor is warm and when things cool down, they're fine.....at least for now.
I'm thinking the solenoid-starter may be going because I've had starters on other vehicles affected by heat before.
View 1 Replies
This is for my previous car that I used to own in 2005. It was a 1992 Honda Accord and the issue it had was anytime I went to the gas station to fill up the gas, the car refused to start and I would need to jump start the vehicle every time. I used to take the DC metro to work everyday, so I did not have to use the car as much, but it was a hassle. This happened all through the year and I was just used to carrying a Jump Starter Box with me in the car. There were no other issues with the car. I do not recall needing a jump start any other time. This one time, I forgot to keep my car in the garage and it was out in the snow all weekend. Come Monday morning, I started the car without any issues. I went to a friends place about 10 miles away and then tried to fill gas at a gas station near his place and it died at the gas station. I do not have the car with me now, having totaled it in an accident couple of years ago. But I was always amazed at this and would like to know what would cause something like this.
View 1 Replies
So I have a 2011 Toyota Camry and the other night I filled up on gas and when I tried to start the car it would start. It just made a grumbling noise and sounded like it was trying to start but couldn't. I got it to start after flooding it and now I have to flood it every time I try to start my car. I don't know what's wrong. Should I take it to a mechanics?
View 4 Replies
I have a 2002 Toyota Solara SLE 6-cylinder 2-door coupe. 98,000 miles.
I have lots of white smoke at start up. Big time oil consumption. My wife drives car 14 mile round trip each day. Each night, I go out late and start car to burn off oil. There is no smoke in the morning when I do this.
People here have suggested the problem is valve stem seals. Not something I should try to fix myself. I did change the pcv valve.
I took car to mechanic. Told him it might be valve stems. He said he'd have to do the heads. Sounded like it would be expensive.
View 14 Replies
Camry 2002 LE (4 cyl Auto), 140K mi
This morning, for the first time I can recall, the car would not start right away. Had been sitting in the garage for 2+ days. Starter would crank just fine, but engine would not fire. No lites were left on overnite. Finally (after about 6+ attempts), engine started -- runs fine now.
Took it to TOY dealer. Their diagnosis: weak battery, alternator low output.Happy, had recently (6 mos) replaced battery after 4 years of use, so got a new battery N/C.TOY ran a charging system check and it shows "Alternator Condition: OK" (midway between shitty and great I recall).
Funny, but my first thought when it would not start was the fuel system (fuel pump) or dirty ignitors. I did ask my regular mechanic for an opinion, and he thinks it might indeed be the fuel pump -- perhaps a clogged filter.
View 2 Replies
I am trying to fix the pesky hard start that I have. My car doesn't start right up anymore unless it is frozen cold. Other than that it takes 2-3 cranks sometimes 4 to turn over. That's annoying and embarrassing and I am trying to remedy it ASAP.
I have a check valve and Purge valve on hand right now. In my research it seems this is where I need to focus. I do have an engine code it was P0456 this time. I also have a gas cap.
I have a check valve because of the all too familiar cutting off early at fuel pump problem. I wanted to start there first since I am sure something needs repairing down by the fuel tank and since the problem is common. And hopefully the valve will work with the fill up and MAYBE with the start, if not that is where the purge valve comes in.
I got as far as get the 2 12mm bolts off and then couldn't make it any further.
View 2 Replies
It is on random times that after I fill up at a gas station, my truck decides it does not want to start. In fact 99% of the failure to start issues only happen after a fill-up. I am typing this now on just such a non-starter issue. Waiting 20 min and it fires right up. During regular driving, runs like a champ, great power good milage (for a 7.3) ...
I have tried random "tests" such as driving to the store, waiting for the duration of time it would take to full up my tank and it starts no problem. Anytime I try to make it happen I cant. The fuel filter is clean, CPS is new, the fuel pump is working. Don't know if it is a temp sensor thing sending wrong info glow plug issue, or? Ghost in the machine?
its 2002 7.3 with 125000 miles. I have had the truck for four years and this issue just started last fall (oct 2016). It happens infrequentaly enough to forget about it until it happens again.
View 6 Replies
I have a '96 Camry and the gas tank has been leaking. I tried fixing it with putty, which seemed to have worked until the weather became milder again and gasoline started dripping again. Does this mean I should be okay through the winter and reconsider my options only when spring comes around again?
View 7 Replies
My wife has a 2002 Accent with 117K miles on it. Fuel pump has never been replaced, but fuel filter and PCV valve changed about 5K miles ago.
The problem started when I added some BG44K fuel injector cleaner to the gas tank by way of a funnel. There was no discernable change in the car until my wife tried to fill up with gas...it kept clicking off. This has been going on for some time and it's pretty annoying.
So I do some research and learned that there could be charcoal pellets in the venting lines coming from the charcoal canister. I removed the charcoal canister from the car, and sure enough, there were a lot of little pellets in the hoses. I disconnected all the hoses and shook out all the pellets (not from the box, from the hoses) and connected everything back up. I went to the gas station and...nope, still clicking off every 2 seconds.
Then I removed the fuel filler neck from the car and inspected it. There were no restrictions in the main tube and no restrictions in the tube that runs up the main tube and loops back down the other side. [b]The blue/black check valve was a little clogged, so I blew it out with compressed air. I reinstalled it with the arrow pointing towards the charcoal box - meaning air and/or fuel can travel towards the canister only. Should the check valve be facing the other way? I assume it should, so gases can vent from the canister to the atmosphere - I don't want air/fuel going into the box, right?
I did find a restriction in one of the smaller hardlines that is connected to the fuel filler neck - it was more charcoal pellets. It was really clogged and I had a hard time removing them. At this point, there are no clogs, restrictions or charcoal pellets in any of the lines (including the charcoal canister), yet I still cannot properly fill the tank. Is the check valve now my only problem?
My wife told me today that the car "felt funny" and didn't "go when she stepped on the gas". Another symptom of the check valve?
I'm not entirely sure why adding fuel injector cleaner would have caused this problem.
View 24 Replies
Is there an easy way to drain all the gas out of the gas tank of a 2009 Toyota Camry Sedan, LE automatic transmission. Is there a drain plug or anything like that? I've never done anything like this so I'm hoping there is a relatively easy way to do it.
View 19 Replies
Like a lot of others, my 2000 Elantra will just barely take gas at the pump. So I've done the research, I think I understand the problem, but when I tried to find the replacement filter, there seem to be 4 different parts ranging from $8 to $180. Which part should I order and order first, or should I just replace them all?
View 4 Replies
I'm sure it's been asked before but why even show the gas level and claim those miles in the range. Also is there any way to tow this thing and while I'm here is there any way to use a floor jack on these.
View 19 Replies
This has happened to me a couple of times...last night most recently. My gas gauge was flashing so I stopped for gas.
I was only able to pump 3-4 gallons, before the hose shut off and every attempt to continue filling after that would only go a second or two before the hose shut off again.
I was careful I though to allow fumes not to build up since I imagined that might be why the hose was shutting off.
I drove for a few miles and later that night stopped again at the same station and was able to fill up as expected.
View 3 Replies
When filling the gas tank, the pump shuts-off (as it should) unless the tank filled very-very slowly. It has overflowed/spilled before the pump even shut-off in some cases.
CEL is not on. DTC 16826 stored: "EVAP Emission Contrl.Sys (small leak) Leak Detected". I just got a VAG-COM cable but haven't got the software going
yet.
Bentley has some diagrams for the fuel vapor recovery system but that's about it. Seems like there's something with the fuel vapor recovery / venting system going on. How to further diagnose?
'01 Passat 1.8T ....
View 3 Replies
Is it just me or does the AC blow colder air when I fill up the gas tank... without fail, after every fill up I notice colder air coming out the vents than previously before I fueled up. what's going on???
View 1 Replies
At seemingly random times when I take my Elantra to the gas station it will only fill the tank about half way before clicking off. After doing some quick google searches I'm leaning towards something being wrong with CCV system. I read that over filling the tank can cause debris to clog the system and a few months back my father-in-law borrowed it he has a tendency to overfill the gas tank. But I've also read that there's an error code that tends to pop up with it and so far there's been none. Either way I'm not familiar with how the CCV and related systems work.
View 3 Replies
After pumping for a few seconds the pump stops because it thinks the tank is full. I have been searching for other 2011 Sonata owners with this problem but can't find any. I see it on older cars, something about charcoal pellets, but not on new cars. Could this be charcoal pellets on this car? The car is still new, why would this happen?
View 26 Replies
