We just purchased an Aerio for my teenage son. We all just love the car. It is the base sedan with 5-spd. There is one problem we did not notice on the test drive. It seems that when the front windshield was made, there is a slight "wavy pattern" that you can see. While it does not inhibit your vision, it is a little irritating.
View 30 RepliesI have an '04 Suzuki Aerio, and there is a loud popping or knocking sound coming from the front of the car when I drive it. I don't seem to hear it when the car is inert (i.e. idling or traveling in a straight at a constant speed). I hear it intermittently when I accelerate/decelerate or turn. I hear it in drive and reverse. The strange thing is that it seems to go away completely when it is raining, and then come back when it stops raining and things dry out. It has been happening for a month or two. I think it has been gradually getting a bit louder. What could cause this?
View 6 RepliesI'm wondering, is there a way to disconnect AWD and have my GF's 2003 Aerio SX be driven only by RW or FW drive train?
View 1 RepliesSome time late last year a branch or something managed to rip my filter off my cold air intake.. the check engine light came on and I ignored it, simply thinking I had not tightened the gas cap.
So last week, I went to get my 2003 Suzuki Aerio SX, with 160K miles inspected, and they told me it was through a code that the mass air flow sensor was bad.. Later they find out my filter is just missing.. the clamp and a section of the rubber was still on the tip.. but the rest of long gone.
So I have been driving, 4 or 5K miles with no filter. I buy some mass air flow sensor cleaner, spray it and now my car idles at just under 2K RPM but slowly creeps up to around 3K RPM. It drives fine, but when I pop it out of gear or hold the clutch down. it starts to go nuts.
I put a brand new K&N filter on, I didn't add any oil to it as it didn't say it needed any and it wasn't dry, but not soaked either.
Now when I went to remove my Mass Airflow Sensor, I did remove a couple other parts first by mistake. I fiddled with the temperature sensor inside my cold air intake, but I couldn't get it out due to the rubber ring around it holding it in and sealing it. I also removed the Fuel Injection Manifold Pressure Sensor but I am pretty sure I put it back on fine. and I did remove the Throttle Position Sensor.. so maybe thats my issue?
what should I do to troubleshoot it?
I sprayed wd40 on the throttle above the engine, not sure if it was it or not but my engine was idling at a lower 1800 rmp for a while, still high but not as bad, I took it for a ride around the block and when I got back it was at 3K again, it did run at a steady 20 mph in second gear with my foot off the gass completely.
I do not know much about cars. I tried to consult my owners manual, but no luck. The problem is this. I have a 2004 Suzuki Aerio with about 73,000 miles on it. When I have my blower on (regardless if hot or cold, ambient, defrost, or AC) and I turn left, my car starts making a "shoof" noise kind of like a large stack of paper falling over. Just today I noticed that the floor of my front passenger area was wet and discovered that there is also a leak or leaks coming down from behind my glovebox when I make these left turns. If I don't have the blower on, there is no noise and (presumably) no leak. The contents of my glovebox are completely dry. I am at a loss as to what is causing this.
What this is, whether it is serious, and can I fix this myself or do I have to take it in? And if I have to take it in to get fixed, how should this problem be described in order to get it fixed properly? I had brought it in to a Midas a few weeks ago about the noise (before I discovered the leak and the air-dependence of the problem) and the guys there said that they heard the noise but thought it was just my wheel rubbing against the wheel well when making sharp turns and that it wasn't that big of a problem.
Weird problem I've had for some time... The car makes a noise that sounds like a slipping belt and only does so at a speed of 15 mph or more. Its a manual and I know it can't be a belt because I've done a little testing while driving. I'm going down a hill, put it in neutral, turn the engine off completely and coast down the hill and the noise is still there. So nothing in the engine is turning at this point, I'm just rolling. So what is moving at this point that could make such a noise?
It also makes the noise when the engine is running and what's weird is I can almost make it go away (the cycles of the noise become less and less frequent if that makes sense) while in gear if I apply the gas just a touch to a point where I am neither accelerating or decelerating. What this noise might be?
i just recently went to a mechanic check out my wife's car cause it was vibrating really bad, and a pulley was making a lot of noise... they told me that the alternator bearings were shot, and i needed 4 motor mounts, long story short i changed the alternator.... it wasn't the problem... had them check it again, they said power steering.... i didn't want to waist a couple hours of work again, i checked it myself like i should have done in the first place... and found out it was the tensioner pulley.... so can i get any pointers on how to change the tensioner pulley, cause i tried and i lacked about 1/4" of space to get the bolt out... do i need to drop the engine or raise it? if so how.. 2005 suzuki aerio 2.3L .....
View 6 RepliesI have a 2005 Suzuki Aerio with an automatic transmission. Occasionally, maybe once every month or two, the check engine light will come on while I am driving and the car will immediately stop down-shifting from 3rd gear. The car otherwise seems to run fine but I end up having to manually shift to get to wherever I am going. Then on my next trip, the transmission will shift fine but the check engine light will stay on for an additional trip or two and then go off. What is going on. By the time I get to it the light is off again and the car seems to function fine.
View 4 RepliesThe car is a 2004 Suzuki Aerio with 68k miles on it. I've owned the car since 25k miles, and performed all maintenance on time. The car was also maintained well before we owned it (receipts). I've taken it to our garage 5 times now, for the same noise. Here is the timeline of events:
1) Two months ago started making two noises (rattle over bumps and a faint clunk on driver's side when turning). Garage replaced control arm assembly on both sides.
2) Took it back a week later because it was still making clunk (It got worse over this week, and then stayed at this level. I can feel it under the driver's side floor board. Sounds like a clunk/cracking noise) and was making a new rattle. Garage said their air wrench was messing up the first day and a heat shield came loose.
3) Another week later, still making clunk and making yet another weird rattle/grinding noise over bumps. Garage said this time that it's another loose bolt on the control arm assembly. Tightened and double checked everything. They seemed apologetic and embarrassed about the loose bolts.
4) Another two weeks later, still making the clunking noise. I take it back and take our mechanic for a ride. He hears it. I call back later that day and they say they can't find anything wrong with it (checked struts, front suspension, and cv joint). I speak with a different mechanic and he tells me "we don't do any fancy hard turning when we take the cars for test drives. We drive them like most people with old cars drive them." This seems to infer, to me, that it's only making this noise because I drive my car hard. Fyi, I drive reasonably. They say they had my mechanic, the other mechanic, the shop owner (who was on vacation that week), and ANOTHER mechanic from a different garage looking at it, and they can't find what's wrong. Bring it back next week.
5) Yesterday, they say they looked everything over and couldn't find anything wrong. Said they would have to diagnose it by feel. I have to work, but my husband picks it up and says they said it's play in the drive shaft causing this noise, and that they didn't seem worried about it. I only paid for the first visit.
Does this sound reasonable? Should I take it somewhere else for a second opinion? It does it on turns weather I'm on the gas or not. I like this car and I'm hoping to keep it for at least a few more years.
I have a 2004 Suzuki Aerio with a 2.3 4 cylinder 5 spd. The problem I'm having is when I accelerate the car pulls to the right hard the steering wheel turns about 5 degrees. When I left off the throttle the steering wheel comes back to center and I hear a pop and feel coming from the passenger front. It also does this while I'm at speed I can hit a bump in the road and get the same problem. I just gave the car an alignment and the issue got worse now my whole car feels like it shifts to the right and left.....
View 3 RepliesI just noticed today my passenger side windshield is wavy. Is there a TSB for it? I would like to get mine replace, but my dealer said it's within spec...
View 9 RepliesI have a 1999 Saab 95, auto, 4 cylinder. I believe the fuel pump is going out. The car will sometimes stall at a stop light and when I stepped on the gas hard it sound/feels like it's stalling but gets going again!! I already checked the fuse, what else can it be? The car has of 100k on it and it's the original fuel pump.
View 12 RepliesDo I need to do anything other than disconnect the battery to disable the airbags on this car so I can replace the ignition lock?
View 30 RepliesIs there some common issue with this? Purchased the vehicle new in 2008, and in 2011 we have had to have the car in for this issue at least once a year. They replace one, then the other, then back to the first one, and now it appears the second is not working again. Each winter we run into this. The dealer will only warranty for a year, so I am paying each time.
View 1 RepliesI recently went to a local chain to have my oil changed and tires rotated. Later that evening when I went to turn on my headlights for the first time since the oil change neither one was working. When I brought back the car the next day to see if they could look at this to see if anything reset accidentally I was told that both lights were burned out and it was a coincidence. It seems unlikely that both headlights would go out at once (high beams were OK) and that it would have happened right after the oil change. I couldn't say what would have caused this but wanted other opinions on if it was likely related to the oil change.
View 19 RepliesI have a 2002 accord 4-cyl with a 5-speed with 89,xxx miles. Just a few months ago, I noticed a clunking sound coming from the front suspension when I go over certain bumps. "Certain" bumps are usually wavy pavement or dips (not wide dips, but short/concise ones), and sometimes certain speed bumps. Sometimes the sound happens regardless of the types of bumps though, but the aforementioned ones usually bring the noise quite consistently. The sound hasn't really gotten worse, but it hasn't been getting better either.
A while back when I had my timing belt done, the mechanic stated that one (or more) of my engine mounts were worn. Is it possible one or more of my engine mounts is the source of this issue (from the engine "rattling" around in the compartment. I'm not sure if that's even possible, just a hypothesis) or is it purely suspension. PS. The sound isn't quite a sharp metal on metal sound. Its more of a "thump" or "clunk" coming from the front end (left or right) as if its bottoming out or a bushing or spacer has worn off. Its just loud enough to drive me crazy, and sometimes I can feel it through the floor.
I have a 2008 Suzuki forenza, 125,000 miles. I commute 5 days a week one hour each way. The check engine light came on, then after a day it went off. I filled it up with gas and as soon as I started it up, the light came on again. Then an hour later, It went off. My brother came to pick me up from work, it was on (he notices nothing). Took it to Auto Zone and the code came up Throttle Body. Went to get a new gas cap & air filter, the code went off.
Changed both. (The gas cap was clicking but not staying on.) Drove to the mechanic. They said they cleared the code but do not see anything wrong and to bring it back if it comes on again. For 348 miles, it drove fine, parked it in the drive way. I went to start it this morning to move out of the driveway, the light is on again. There is a sight hesitation while driving; the mechanic thought it might be a spark plug. I have had the car a year. The hesitation comes and goes. I plan on getting the plugs changed next week. I started using Lucas with every fill up. So far have used it 3 times.
The transmission feels like its slipping while in drive. Oddly though, it shifts great using 1st to 2nd to Drive, then using an on / off switch to control 3rd to Overdrive/4th. Its automatic and I am just using the shifter to control shifting, because the car doesn't seem to downshift on its own either. It will stay in Overdrive/4th even at 35mph with the pedal to the floor, only sometimes downshifting after awhile. The car also hesitates slightly while driving at above 65mph on highway. It stops doing so on hills, and it has no issues at lower speeds, even at 5k rpms. Not sure what that is related to. I just bought it, and the transmission fluid is black, not sure if its from lack of maintenance. I assume the transmission needs a rebuild, but the more I know the better I won't be ripped off at a shop.
View 2 RepliesThe air conditioner works fine. Auxillary heat works fine. Heat won't switch from cold to hot in the front of the car. What would cause this?
View 1 RepliesWe bought a 2007 XL7 two weeks ago. The second day we had the car the battery was dead. Had it replaced and then the charging system was not reading over 12.3 volts while running. Replaced the alternator but the car still ranges from 12.3 to 14.2 volts while running or idling. Last Saturday the front control stopped working. Could not change the radio, a/c or any other centrally located controls. We had a 2004 XL7 and it was great. Our vehicle was manufactured Nov of 2006 so it was one of the first out, I almost forgot that the speakers pop like something is grounding out every time we open the doors. I ran a Suzuki Motorcycle dealership for almost 10 years and have never seen anything this random in the powersports world. The dealer said he has replaced batteries in 3 other new XL7's. Did I get the only XL7 with Gremlins?
View 30 RepliesI just got my SX4 on tuesday and it has a shimmy in the front while going down the road. They balanced the tires but I still have the problem.
View 30 Replies