Subaru - Outback :: 2005 XT - Hard Cranking / Fuel System Full Of Rust
Feb 3, 2013
115,000 miles, adult driven. Hard cranking, took into dealer. Replaced 4 injectors - cylinder 2 misfiring. Showed me return gas line clogged with brownish material. Dealer stymied.
Now, Subaru headquarters diagnoses replacing all steel fuel lines, fuel rails, fuel pump...full of rust from inside. Tank looks Ok, as does filler neck. Premium gas used always, added Drygas seasonally as needed.
Question: where the heck would rust come from? What can I do to prevent this problem again? Love the car...would like to get 200,000 from it.
View 16 Replies
Advertisement
I had posted earlier about replacing the harness or at the very least the plug that broke off of the cam shaft sensor on our 98 Subaru Outback. Well, I replaced the plug, and the cam and crank shaft sensors as well and it is still cranking but not firing.
View 7 Replies
My 2016 Outback, 10K miles, occasionally does a weird thing. The dealer is far from us, so I'm putting off taking it in, especially since they will be unable to reproduce this. Every now and then when I try to start it, it does not crank. The dash lights all come on, and dim when I turn it to the start position. But instead of cranking, it just does a soft stuttering click, exactly as if the battery were nearly dead. But if I try a few times, suddenly it cranks perfectly and starts right up.
View 15 Replies
My 2000 Subaru Outback automatic, with 95,000 miles is intermittently stalling. No check engine light, no sputtering, engine temperature & oil pressure fine; it will just be running and then it isn't. It has happened with a 1/4 tank gas and with a full tank of gas. Primarily it has happened after driving around on a hot day, with some highway driving, city driving, running errands- so stopping for a while, then when I head home and gain altitude (another 2000-2500 ft), it will stall when I take my foot off of the accelerator to make a left turn, or go around a blind right curve, but not every time. When it has stalled once, it tends to repeatedly stall when I take my foot off of the gas.
It always starts right back up again with no problem. It happened once in town right after I filled up with gas, but didn't repeatedly stall after that.It has been to my mechanic 3 times and no codes come up with scan. The AF sensor (idle control valve) was replaced twice, throttle body cleaned (although not bad), crank sensor checked, fuel trim checked, wires, battery checked, hoses checked, reprogramming of ECU checked- not needed, no recalls/reflashes, nothing found. I don't want to end up stranded on a lonely mountain road with fires approaching, or getting broadsided when it stalls in a left turn.
View 15 Replies
For the past 3 yrs only in the winter when its around 30 outside where my car is parked after i start the car and put it in reverse to back up i have no brakes, the pedal is hard, i have to put direct pressure and hold it down til it softens to the floor after about 5 to 10 seconds then i have brakes for the rest of the day. But this winter and its still cold out it has been happening intermittently during the daytime going front or back i have to try and pump the brakes til the peddle softens or i just press the peddle hard and hold til it softens and then it works takes about 3 to 4 seconds in the middle of the day. Only happens when i first start up the car. I have replaced the pads, rotors, master cylinder, flushed the whole system and the latest money drop was replacing the booster.
View 17 Replies
The car had no accelerating power and it was well overdue for new spark plugs and wires. I just replaced them and it's doing much better, however, the engine seems to be shaking a bit when I start it/idling, which is making the entire car shake some too ( the seats, car shifter, etc ) . It's been awhile since I've also replaced the air filter too, which I obviously should have checked but haven't yet. When I replaced the spark plugs, I noticed there was a minor amount of engine oil on the spark plug wires, where they connect to the spark plugs; more notably the front 2(of 4), left and right. I also just changed the oil and there was no oil loss really, other than any minor amounts that get burned off through the miles.
The exhaust manifolds ( y-split ) are okay, but one of the nuts seems to loosen over time, causing a minor air leak there and makes it a tad noisy. Near the back half of the exhaust system, there some water dripping at one of the connections, and at the tail pipe the exhaust smoke is chugging and isn't consistent sounding.
What is still causing this engine shaking and the chugging noises from the exhaust system. The 'Check Engine' light is on, due to other repairs I know I need to make, such as an 02 sensor and fuel level sensor; however, lately it has started blinking too.
View 7 Replies
One of the fuel lines on our 2007 Subaru Outback needed to be replaced (rodent damage). Now the car reeks of gasoline. The dealer said it will take time to dissipate. How we can speed up the process?
View 5 Replies
My OBXT is running way too hot when heading up hill. Recently have had the caps and cooling system pressure tested and all passed. I had the head gasket replaced, water pump, timing belt, pulleys, etc. The engine was also pressure tested and passed.The Subaru techs and I are at a loss.
View 8 Replies
Riding on the highway to the summit of Vail Pass, car loses power, check engine light goes on, by the time I maneuver it past huge trucks to right shoulder, BAM!!!! White steam radiator fluid explosion dead car....mechanic says "small block" (I think) broken, need new engine. Towing it back to my guys who sold me the car about 2 months ago with reconditioned engine & brand new head gaskets.
View 19 Replies
My wife has a 2005 Subaru Outback XT w/auto trans, about 135k miles. We live in SoCal.The car runs great...well, most of the time. During the summer, or when driving up steep mountains with the AC running, the needle will climb steadily north towards overheating. Call me timid, but I've never been curious enough to find out what happens if I let the needle get into the red.To let the needle drop, I have to turn the AC off. This isn't the best option now since we've been experiencing over a week of temperatures higher than 103.I also noticed that the temp needle will drop to normal within a couple of minutes if I turn on the heater.
I did open the bonnet when we returned from a trip and with the car running, checked to make sure both fans were running.
View 18 Replies
My 2004 Outback now has 120K, has always been maintained and repaired at the dealership (except tires and battery), and has always run great! I've had the plastick-y parts replaced over the last few years including head gaskets when one cracked and made smoke. In July I got a jump from a AAA tow truck, who said my battery tested as needing replacement.
In September my check engine light went on, and the dealer found the code PO420-catalyst system efficiency. They didn't seem to look any further into causes. The cat converter replacement was to cost $2521. They reportedly tested the battery as OK as part of their routine checkup. I declined the new cat converter till learning more. Meanwhile, my check engine light seemed to cycle on, then off, then on, then off . . . every several days.
In December I had the battery checked at Sears, who replaced it under warranty. So I guess it wasn't okay after all. After that my check engine light stayed off for somewhat longer than usual, then back on for most of January. I was just about to give in and get the repair done when it cycled off briefly a few days ago.
I've lost trust in the dealership because of their battery check which differed from others before and after theirs; and for their lack of specific diagnostics. The light is back on and I don't know what to do next.
View 7 Replies
I recently had my wheel hub and bearing replaced. The mechanic said I might hear a little noise with the brakes but they'd work. Turns out that noise is the Anti-lock braking system engaging every time I use the brakes. It happens when the car speed gets low, maybe 5-15 mph. Also, if I'm driving slow in a parking lot or something, and let off the gas, that change in speed sets the ABS system on too, without my foot being on the brake pedal.
I've also noticed sometimes when the weather is very cold, the ABS light will go on and the ABS brakes won't work; just regular brakes. Is this something that I'd be able to solve at home? Could I possibly bleed the brake lines to check for any air ( although braking seems fine ) , busted fuse for the system, anything else to check before asking the mechanic?
View 4 Replies
05 outback xt ... I bought this car last October and don't know the history of what has been replaced and what is oem. That being said I have had a horrible smell (imagine a skunk eating rotten eggs) when I back the car up. I also have a problem with my car hesitating when i accelerate but it goes away once the car is warm. The check engine light has never come on when driving but I know it works.
View 6 Replies
2005 Subaru 2.5 Limited Outback. If I drive my Outback for over an hour, when I make sharp turns at a low speed in a parking lot my front end doesn't seem to turn right. As a I turn it seems like maybe the front differential is not working right, both wheels want to spin a the same rate. what could cause this?
View 10 Replies
I have a 2005 Subaru Outback XT with turbo. I have had a strange problem the last two winters and have stumped two mechanics, so far.
At this time of year, it is necessary to warm my car up for a few minutes in the morning. Last winter, when I warmed my car up, I would smell gasoline outside of the car and in the cab. It only happened when it is about 25 degrees or less outside. After about 10-15 minutes, once the car was warm, the smell would go away. I figured smelling gasoline was bad news, so, I took it to my mechanic who said he found a loose clamp in the engine. He tightened it and it fixed the problem. I didn't have any other issues that winter or through the next year.
But, this winter, the problem is back. I have moved, so, I took the car to a new mechanic (recommended by friends) and told him the issue. He said that he found a loose clamp between the engine and the turbo and tightened it. He said other than that, he can't think of anything. Well, that worked for a few days. But, now, the problem is back and with a vengeance. The smell is a bit different. Still like gasoline, but kind of like exhaust, too. And it is strong. I have to open the windows for a few minutes to air the car out before I can drive it. I took it back to the mechanic, but he is stumped and not sure what to do next.
I think my next step is to take it to a Subaru dealer, but with a 10 year old car, I'm hesitant to go that route. Though, I love my car and want it to last AND be safe to drive. What is going on?
View 9 Replies
When I turn my 2005 Subaru Outback sharply, especially when in reverse, it seems to brake without my touching the brake pedal. About the same time it started, the automatic transmission would give a slight jump when shifting into or out of neutral. Took it to one shop, they said I needed a new transmission to install. Took it to another shop, they fixed my differential. But they didn't fix the seeming braking. The nearest dealer is 150 miles away and I haven't been able to get there at the right time on a weekday.
View 4 Replies
I'm 1st time owner of a Subaru. This is an automatic 2013 Outback 2.5i Premium with 9,600 miles.
Last Friday and last night (Sun) when the car was parked with no key in the ignition, there was a continuous sound coming from behind the rear left wheel. It sounded like a fuel pump was on.
To stop it, I put the key in the ignition and turned it until all the lights come on without actually cranking the engine. When the key was removed, the sound stopped. The sound seemed to start a couple hours after I parked the car. Both occurred in the evening and there was less than 1/4 tank of gas in the tank.
Since there are 2 commonalities here, I'll fill up the tank and monitor every 30 min (may not be able to do this when I sleep!). Since it is intermittent, there's not much the local shop could do except to check if there is any Subaru service bulletin.
I am concerned it was draining the battery last night but this morning it started right away.
I don't know if this has been happening without my noticing. So is this normal?
View 3 Replies
My 2001 L.L.Bean Edition H6-3.0 is losing power & MPG on the fwy. Sometimes it will feel like something is holding it back or dragging. I've checked the brake calipers and they're not sticking, changed the air filter, oil & filter, transmission fluid, and still cannot find the problem. I've overfilled the gas tank and read this can damage the charcoal canister. Will a saturated charcoal canister cause a drop in power and MPG? What should I check out next?
View 10 Replies
In the last couple of weeks I've been getting a whistle or whining noise I think from under my car periodically. It doesn't happen when I start the car, not when idling and starts at about 20/30 mph. I've had the car in the shop for regular maintenance, just replaced front bushings, put on new rear brake pads and new rotors. I've checked the car for anything that might cause wind since it comes and goes even while driving. Seems worse in hot, damp weather. Back to the dealer today because it was loud and they say drive shaft, but there is no vibration and the car is running very smoothly. It's driving me crazy when it happens because it almost sounds like a plane landing.
View 13 Replies
I just replaced both front strut mounts on my 2005 Outback 3.0L. I was 100% sure that it would resolve an ongoing noise/rattle in the front end when driving over bumps and generally rough roads. It worked with some of the noise because the strut mount bearings were shot. But much to my disappointment after putting everything back together I still have a rattle (more like the sound when you shake a shoe box with a tennis ball inside it) in the right front suspension somewhere. When lifted the right front wheel is solid with no wobble left to right or top to bottom so I"m thinking it is not a tie rod but I am not a professional mechanic. Should I take the right front strut back off and check the new mount or is there an easier answer.
View 3 Replies
About 2 months ago, I noticed a high pitched whine on my 2005 Subaru Outback. It honestly sounds like a siren and is very noticeable. It occurs more often when the car is cold (1st thing in the morning) and around 20 mph. It sounds like it is coming from the rear of my car. It occurs whether or not I am pressing on the gas pedal. Once I get above about 30-40 mph, I don't notice it anymore (don't know if this is because other engine noises are drowning it out or what). It does not change or get worse when I turn. It seems to subside once my car is warm. Other people have heard it and some describe it like an airplane taking off.
I took it to the Subaru dealership and they said it was my alternator. Lo and behold a few hundred dollars later, it was still making the noise. A few days later, my CAM sensor went bad and I was back in the shop. Of course, I tried to get my car to make the noise for the mechanic, but it wouldn't cooperate. They didn't see anything wrong, but it is still making the noise. I have taken it to the dealership and they couldn't get it to make the noise. My rear wheel bearings were going bad and so I replaced those - under warranty, but it still makes the noise. I keep up with all my oil changes, services, etc. I just had the fluids checked and the power steering fluid is normal. The power steering pump has also been checked and it is normal. What this might be?
View 14 Replies
