Subaru - Legacy :: 1999 - Metallic Rattling Noise
Aug 13, 2012
My '99 Legacy is far from quiet, but yesterday I heard a new -- and somewhat alarming -- noise.
Roughly two-thirds of the way through a four-hour drive, I started to hear a rattling or grinding sound coming from the front of the car, perhaps closer to the driver's side than the passenger's. It sounded as if a tin soup can or paint can were hitting the road, but when I popped my head under the car, nothing was hanging loose.
I hear the rattling sound as I begin to accelerate, and only when I have my foot on the gas -- when I let off, it's perfectly quiet. What I haven't been able to determine is whether the noise goes away after I reach a higher speed, or whether the sound of the usually loud engine drowns it out. The noise is most acute around 1500-2000 rpm whether it's in gear, or whether it's in neutral and I'm revving the engine.
View 10 Replies
Advertisement
We hear a horrible metallic clunking or cracking noise - only occasionally - when coming to a gentle stop, like at a stop sign. The noise is coming from the driver side front and happens more often when the car is stopping gently on a flat or slight downhill. It does not seem to happen when we stop on an uphill. It does not happen during sudden stops. A mechanic recently replaced the driver side tie-rod, thinking that would solve the problem, but it didn't. The same mechanic looked at the brakes and found no apparent problem. The sound is very loud and sounds almost like something is settling.
View 2 Replies
I have a 99 Subaru Legacy Wagon with just over 196,000 miles in it. Over the past few days I have had a noise coming out of what seems to be my right front wheel. It is a clicking sound that increases with speed, and is only when I turn and have my foot on the gas. Other than the noise there seems to be no other symptoms.
View 5 Replies
The car has about 142,000 miles. Is the clutch on this car adjustable? My repair files indicate it was "adjusted" a couple times, $40 each time. Now I think I might need a new one: it seems to be slipping, making some noise in 3rd, and in 5th.
View 2 Replies
I am a brand new VW owner and new member of this site. Just recently I purchased a '02 Passat GLX 4motion (w/97k miles) for fairly good price knowing that it was involved in a rear end accident.
Now I am finding multiple issues with this car. It looks excellent from exterior or interior. I have three different issues (front and rear axle pinion seal leak, broken spring, gas leak only when tank is full) with this car but I would like to discuss the Broken Spring issue here.
When I go through rough road or bumps I hear a metallic noise (noise like key chiming) from the rear driver side along with a rattling noise (like wood or plastic board rattling) at the same time from the rear middle part of the car. I researched online and found few forums talking about the brake pad caliper spring making similar noises. I called a mechanic and I was told that it could be the muffler.
I took the wheel off and kicked and hit the axle area with rubber mallet, kicked the muffler - but no similar noise was produced. However I noticed that the spring coil (rear driver side) was broken right at the bottom. When I did online research I saw one forum talking about broken spring making similar noise. I did more research and found the part (OEM# 4B0 511 115 B).
My question is:
> Does this sound like what causing the noise? Could a broken spring cause metallic chime and a hard board rattling noise?
> Is it necessary to replace the spring along with the shock absorber? Can spring be replaced by itself?
> How hard is it to replace a spring?
> Do you have to have spring compressor to mount and unmount? Can you simply take the whole assembly without compressing it?
View 3 Replies
While driving through a tunnel today I noticed a metallic rattling noise upon acceleration. It goes away immediately when I let me foot off the gas and when I park the car and rev the engine the sound does not occur.
A few days ago, I had to rapidly accelerate and it felt as though I lost power for a split second. I am not sure if these are related, but I am hoping its not some sort of transmission issue (unless that is covered under the hybrid warranty. What was the diagnosis?
View 1 Replies
My R32 has got about 9,400mi on it, and for the past 3k miles or so, i've been dealing with this metallic scraping/rattling noise coming from underneath the car. When I took it to the dealer, they said it was the exhaust flex pipe, so they replaced it under warranty. Next day after picking the car up, same noise. So i took it in again this morning and they are saying its the flex pipe again, and they don't know if it is fixable.
They are talking to VW tech assistance, and trying to figure something out. I really love this car, but if VW says there is no fix for it, I'm weary about possible future issues without fixes too. Apparently it has something to do with the length of the flex pipes and the material its made out of. He was saying one possible solution is stiffer engine mounts. We'll see where this goes.
View 8 Replies
One of my headlights has stopped working on my 1999 Subaru. Do I need to replace the entire headlight assembly or is it just a bulb? Approximately how much should it cost to fix? 1999 Subaru Legacy sedan
View 10 Replies
My truck is making a metal on metal rattling noise when going over undulations or the type of vibration when you drive over a rumble strip.
It seems to be coming from underneath the engine area, but not quite sure. The sound is like a kettle lid clanking on the actual kettle when the water's boiling if you can hear what I mean. No noise when just driving.
View 14 Replies
Noticed a weird metallic rattling noise coming from the transmission when switched to N with the engine running and the car is stationary? Almost like the gears are rattling inside while in N position. I took it to the dealer and their Prius guru said this is normal characteristic of eCVT....
View 4 Replies
I recently replaced the brake pads on my 1996 Subaru Legacy. I can hear a grinding noise when I stop. I checked the brake pads again but could not see anything.
View 1 Replies
I've got a 2002 subaru legacy wagon, 150k miles. Over the past year or so (a real guess, can't really remember when it started) it's developed a wowowow noise that happens when turning. The car has to be moving - just turning the steering wheel while stationary does not make any noise. I can't tell if it's only coming from left or right side of the car or the front or back. It also doesn't happen when driving in a straight line. The wow's are faster when the car is going faster but the frequency is very roughly 4 per second at 40 mph. The noise itself is pretty low and grumble, and kind of sounds like James Earl Jones saying "wow wow wow wow".
View 19 Replies
My boyfriend has 95 subaru legacy L 2.2 that has issues. NEW: coil pack, fuel pump, spark plugs n wires, battery. (I forget the rest)
Background: While running the car almost out of gas (as usual) it starts to run rough, just thinking it was the gas, he gets gas and heads home but it does not fix the roughness. It stalls in driveway (lucky). A friend brings over obd scanner. Reads codes for cylinder 1&4 misfire. It starts and runs but sounds like crap. I tested the coil pack and the reading was bad, so got that and sparks n wires. Cleaned a bunch of fuel related parts (its been a while) and took out injector but apparently it was not back in all the way because fuel came spray/flooding out while another friend had a sparkplug out and was testing it for spark!! (luckily he was not harmed).
After this it has not started. We did get the injector back in all the way, and waited to work on it figuring it was flooded and that time would work. Next was the fuel pump, yay i can hear it now, boo still didn't work. Now car clicks. Ok, starter out, tested THREE times at advance auto, and once at napa. They both say it is good. (I have my doubts though, it sounded slow to start up to me). Battery is also tested, bad cell. Checked flywheel, Put starter back in and new battery with 625 cold cranking amps. Car cranks now, but no start. Clicking noise when crankshaft turns.
Q: Do the engine is still flooded?
Q: Did the flooding foul the new spark plugs?
Q: WHY is the crankshaft clicking?
Q: WHERE is the nearest cliff?
View 6 Replies
1988 Ranger, 2.9, 5 speed, 2wd, 7.5, 3.42:1, 190K or 290K on the odo.
I've been hearing this rattling, sometimes kind of a metallic ping, from the rear the last week. I thought it was probably the universal joints, didn't do it often, only under load between 1500-1900RPM roughly in second, third and fourth. I planned on working on it this weekend.
Today it started really making noise, sounds like valves rattling as though the timing was too high but it was coming from the rear end. It was making it all the way through the gears into fifth, even when cruising. Once it cooled down a bit it nearly went away.
I'm going to get started on it as soon as I can, but I can't get it in the shop to pull the differential cover and take a look right now. Dad's shop is full of crap, I live on top of a hill, not many safe places to get one up in the air properly. What is causing that sound?
View 5 Replies
My 02 Legacy with 185k suddenly developed a whining noise I believe from the transmission. The noise coincides with engine rpm. The noise lessens when the load is taken off the transmission when at cruising speed. The trans shifts perfect and the fluid doesn't look too bad.
View 2 Replies
"93 Subaru legacy 175,000 miles: Just picked it up yesterday after timing belt/water pump replacement. Now it makes a high pitched whining noise sounds like from engine, the mechanic called it a whistle, but it ain't no whistle and wasn't there before.
View 3 Replies
Recently I have been hearing a humming noise that increases with speed. I don't get it when the car stops. I think it's coming from the rear but only when the car is moving and steadily increases in volume as speed increases and comes down as speed comes down. It's not coming from engine or transmission but coming from the rear wheels. Could it be a bearing? or both bearings? Is hard to make out if it's left or right of the windows when the windows are closed. Car drives great and has mileage in the 80's
View 5 Replies
I get check engine codes p0301 p0302 p0303 and p0304. Sometimes just one or two sometimes all four. It only happens in fifth gear at or above 2800 rpm. There is no noticeable misfire; my gas mileage is 25mpg and like the advice below, I've changed the wires, and spark plugs but not the coils nor the injectors. I've reset the codes numerous times; it comes back regularly but only in fifth gear at the higher speeds.
The car: Subaru legacy AWD wagon 1999, 2.5 liter 5 speed manual transmission.
To state the obvious, checking for electrical problems is a process of elimination. I've included some points I got elsewhere online to narrow down the cause. What is not discussed, but has been brought up by parts salesman are the sensors. There's five, a cam and a crank sensor as well as three speed sensors. Which sensor that's failing would cause such specific engine codes.
Talking points:
"for piston misfires If there are no symptoms, the simplest thing to do is to reset the code and see if it comes back."Check engine light comes back on
"If there are symptoms such as the engine is stumbling or hesitating, check all wiring and connectors that lead to the cylinders (i.e. spark plugs)."There are no noticeable symptoms.
"Depending on how long the ignition components have been in the car, it may be a good idea to replace them as part of your regular maintenance schedule. I would suggest spark plugs, spark plug wires, distributor cap, and rotor (if applicable)."Done.
"Otherwise, check the coils (a.k.a. coil packs). In some cases, the catalytic converter has gone bad. If you smell rotten eggs in the exhaust, your cat converter needs to be replaced."It passed smog with flying colors. I'm not sure how to check the coil packs but since it doesn't actually seem to miss, I'd think to look elsewhere. -- maybe I'm wrong here.
"I've also heard in other cases the problems were faulty fuel injectors." Same conclusion as above.
View 1 Replies
I have a '95 Subaru Legacy L Wagon AWD 5-speed manual shift. There a new noise that seems to be coming from the front half of the car. I can't really describe the noise, but it only happens when all three conditions are met. If they are, the noise is continuous.
1.) The car has to be in gear--not neutral. But it doesn't matter which gear. I tried revving the engine in neutral, but nothing happens.
2.) I have to be accelerating on the gas petal. If I let off the gas--even if the engine and vehicle speed haven't yet dropped--there's no noise.
3.) Engine speed needs to be at or above 2,000 RPM. It gets louder at higher engine speeds, but it's pretty much proportional to the "normal" noises at higher speeds.
What might be causing this?
View 7 Replies
My 1999 Subaru Legacy has a couple of rust holes in the hood. Unfortunately it's from the back and not easily fixed without welding.
View 8 Replies
As I was driving home the other day, I noticed the steering wheel on my 99 Subaru Legacy (130,000+ miles) became considerably stiffer than ever before. I pulled into my driveway (where, incidentally, the wheel loosened up) and checked the power steering fluid. Unsurprisingly, it was low.
I haven't been on the road since, but I did turn the car around in the driveway. Aside from the wheel gently stuttering or pausing initially (it's done this when cold for a while now -- I always assumed it was a loose belt or something) the wheel seemed normal.
I made an appointment with a mechanic and described my symptoms. He said he'd have to take a look but suspected it was a bad power steering pump. Is this the only possibility? Could it be a bad belt or a leak somewhere in the system? If it is the pump, how much should I expect to pay to have it fixed?
View 6 Replies
