Mitsubishi - Galant :: 2002 - Overheating After Timing Belt Change
Nov 19, 2013
2002 galant 4cly overheating! So my Galant has 120k miles and I just had the timing belt replaced and I thought I'd be good and have the water pump replaced as well. When I got it back I made a few short trips with it and it was running fine then I took a longer trip about 30 miles and I noticed it was overheating, so I took it back to the shop they thought it was air in the cooling system so they preformed a few flushes, replaced the thermostat even though it was new and then replaced the pump again and the radiator cap, the radiator it's self was replaced maybe 1-2k miles ago. I don't believe the head is leaking since I'm not losing coolant and the oil isn't milky.....I'm at a loss, could the thermostat be the problem? Do I need one from the dealer? Is there a history with replacement pumps bad?
View 12 Replies
Advertisement
2002 Montero sport 3.5V6 , Miles: 130,000. Bought recently drove home over 2 hour drive no issues, Recent work: Timing belt (preemptive). All Serpentine belts, PCV valve (after timing belt job I noticed oil in exhaust)It gave a P0506 code and idling at 500 rpm after the timing belt job, found some oil in exhaust. Got the PCV valve replaced. That solved the oil in exhaust issue, but the code has come back. Drives ok, no issues, no smoke.I am going to clean the throttle body and install new air filter, today and take it on a highway drive (clean oil residue from cat). I had the timing belt work done at a very trusted place, but this time their game was not so good. Boss on vacation, new location and their work was somewhat careless not their usual style.
View 11 Replies
Yesterday, I was waiting inline at a fast food drive-thru and noticed that my A/C was not cooling (it was 100 deg outside). I then put the car in park and revved up the engine and then cool air started to come out of my A/C vents. I did that for 2-3 mins, then noticed that my temperature gauge rose almost all the way to the top (it went right under the red). At that point I took off (out of the drive thru), to get some air flowing into the radiator. Sure enough it temperature doped fast. After looking under the hood. I noticed that one of the two fans to the radiator will not turn on. I'm guessing that's what caused the over heating. I am not sure if I did any damage to the engine though, it did run really hot but not to the red mark but a hair line right under it.
View 5 Replies
I have a 2002 Intrepid ES with a 3.5L V-6 with 264,000 miles on it. I have recently had the timing belt and water pump changed. Three weeks later I am driving home and the temperature gauge starts climbing. This is the first time this car has ever overheated. Well, I call my buddy who is a certified mechanic and he tows the car to his shop. I have him check the water pump to make sure it hasn't prematurely failed. He tears the front of the engine down and inspects the pump. He finds nothing wrong with the pump but he discovers the timing belt tensioner has failed and it has caused the engine to jump time, I tell him to go ahead and replace the tensioner.
After he put the engine back together he started it and it ran cool while it was sitting at idle for about 45 minutes. Then he took it for a test drive and it overheated again. He checks the thermostat and finds that it has also failed; he replaces that also, still overheating. New radiator hoses, upper and lower, new radiator, new thermostat, new water pump and it still overheats. He put dye into the coolant to check for a blown head gasket and it tested negative for a blown gasket. The exhaust doesn’t smell of burning coolant or producing white smoke. My mechanic friend and I both have run out of solutions…
View 12 Replies
I am getting concerned with the steering of my car due to a rather unsettling behavior that has developed within the last month or so. at first it was barely noticeable but over the last several weeks its become more pronounced and more than a bit unsettling.
This issue occurs under two conditions accelerating on a steep upward incline or accelerating to highway speeds / passing. The severity of the problem seems to be a factor of how much torque is being applied to the wheels.
When I accelerate hard the car feels like its pulling slightly to the left but as soon as I let off the gas the car seems to jerk suddenly to the right.
View 11 Replies
So the last week and a half my car has been making a loud noise that sounds like a loud POK when my car accelerates or slows down. I am worried that there is a loose bolt somewhere and that the noise is caused by something shifting under the forces being applied to the wheels.
View 9 Replies
My driver side floorboard is leaking something. I am not sure what this could be. There is a huge stain that looks like a burn almost, and around the hole is a brown stain that keeps getting bigger. I lift up my floor mat and it is soaked. Could this be my air conditioner leaking or could it be something more serious? 2002 Mitsubishi Galant ES....
View 2 Replies
I am having issues that i think are related to the transmission.
When I am stopped and the car is in drive it starts to vibrate significantly however once i start moving again the vibrations stop.
Switching to neutral or reverse also causes the vibrations to stop.
I am thinking that somehow the transmission is not fully disengaging when the break is pressed like it is supposed to but i may be way off on this.
View 18 Replies
I've had my Galant since mid-May. I bought it in a rush as a replacement vehicle after a car accident. Soon after I noticed a damp/musty smell coming from the A/C. I read that changing the cabin air filter would fix the problem, but since the Galant doesn't have a cabin air filter, I had a dealer use a foaming cleaning agent that was supposed kill off any mold that may have been present in the A/C system, the cleaner seems to have fixed the damp smell.
Right before I had this done I noticed that the floorboards on the front passenger side were consistently damp. It's been that way for about a month, and the A/C continues to leak. Now I've noticed that for the past few days when I'm trying to defog the windshield on my morning commute, the heater is blowing cold air even thought the A/C is switched off. Are these these two problems related? Also, would I be able to repair them at home?
View 6 Replies
A mechanic has my car and replaced my timing belt and water pump....he said he had it running and then it sputtered out and wont start..i have never had a problem with this car. Just replacing before it went out.. he is missing something.
View 19 Replies
I replace my timing belt and water pump and my engine is now over heating. I notice it's only over heats when the ac is running and the engine is idling. When I start to drive the engine temp goes down.
View 1 Replies
I just had the timing belt (water pump and thermostat) replaced in my 2004 V8. I drove it home from the dealer (75 miles or so) without incident. Drove it to and from work (4 miles) without incident for a few days.
Last night I drove ~5 miles, idled in a parking lot for ~10 min and then drove another 5 miles and it overheated. Once I shut off the car it would not come back on. I waited for it to drop below 200C and it still didn't start. Electric consumers would come on all was well....but no start.
Car was towed to the local VW dealer who do not have a phaeton tech. After the hour and half it took for the tow truck to arrive and half an hour to tow it....it started up.
I am now thinking about my next move. As I read through everyone's overheating experiences they are mostly
1. Failed thermostat (which one? does the bottom thermostat control water pump operation?)
2. Fan issues
3. Air in the coolant line following a flush (could be, but I drove it home in the cold on the first day with the heater on)
4. False readings due to a bum (upper?) thermostat.
I have a VCDS but have not been able to get out to the car to give it a shot.
View 11 Replies
I was wondering if the timing belt on my 05 RX 330 needed to be changed due to age and not miles. The car only has 72k miles on it but it is 10 years old.
View 5 Replies
So after saying "We don't work on that model" when I asked for a timing belt / water pump change (yup, they actually said that), I went in today to try and get a second key made since the guy I bought the Phaeton from only had 1. I do not have the little code. I was told that there was nothing they could do without the code. My only hope would be to contact EVE directly.
View 2 Replies
I just changed the timing belt and everything runs great. I pushed the AC button and no light came on. I checked all the fuses and they are good I took the H and L caps of and tapped the pin and there was air blasting out. Don't know what it could be? All I did was loosen the compressor and remove the belt and put it back on.
View 2 Replies
After timing belt change code P0016 with Check engine light trac off and VSC light on.
Put on the entire kit...timing belt,tensioner, idler, and water pump. When I took it apart to put the new cam crank sensor I inspected everything and all looked good.
Changed the sensor and reset code, a few hours later back on. Car seems to run fine. I didn't think the sensor was bad. Car was running great...just due for timing belt.
View 6 Replies
My dad changed the timing belt on my 99 CR-V in August and he had some trouble getting it in time (he had to tear down and put it back together 3 times!). Sometime after the timing belt/water pump/spark plug change, I noticed a vibration in the steering wheel while at a stop and a loss of MPG (went from getting 24 mpg to 22.7).
It did not happen immediately after the timing belt change (or at least i dont think it did) so i thought the mpg loss might be due to the changing weather and the vibration coming from a motor mount that i knew was broken, but I got the motor mount fixed and it did not do anything. I think that the vibration has gotten worse, but it seems to be at its worst when the car is really cold. (this morning the temp. was 9 degrees and it vibrated harder than it ever has).
The vibration only happens when the car is in park or at a stop, and it goes away when i accelerate, even if I only accelerate a little bit. I have not noticed a loss in power, or any sluggishness in acceleration. I have tried to research this, and I read something about the drive belt being out of time, but I'm not savvy with cars so I just don't know.
What could be the cause, do I HAVE to get it fixed, and what do you think a reasonable cost to repair is?
View 10 Replies
My mechanic just did the timing bet, water pump and other belts. Also changed the tensioner.
Car runs fine and everything seems great until I get to a red light. The engine sounds louder then before. Not very loud but its louder and maybe a very slight vibration, not sure yet. No noises while driving, seems like its running the same or better then before. Runs fine though
View 4 Replies
I have a 2005 Toyota Camry with 120K miles that was bought used with 110K. The previous owner did not have the vehicle long and did not know if or when the timing belt had been replaced. I have read several blogs that recommend replacing the timing belt at 60 or 90K. To err on the conservative side I decided just to do it at 120K. Now my problem. Before the timing belt change there was a slight knocking from one of the cylinders. After the belt change the knocking is more pronounced. Q. How concerned should I be that the knocking is more noticeable? Could this be a by-product of the new belt and as it loosens the knocking will subside somewhat? OR, am I looking at valve job or worse?
View 8 Replies
We just had our timing belt changed today as well as the waterpump and fanbelts. It has a loud whining noise now and I don't know if it is even safe to drive back to the mechanic...
View 3 Replies
1987 Acura Integra AT with 158k... Water pump broke after 75k miles (in 18yr period)....
I am wondering what else should I have it done:
- thermostat
- oxygen sensor (is there one?)
- vacuum tubes (I hear that these fail due to age)
- anything else?
Are these near where they will be working on? Any other tips?
View 6 Replies
