Jeep - Cherokee :: Steering Pump Leaking And Gear Box Shot?
Mar 29, 2015
I drive a 1998 Jeep Cherokee 4x4. I lifted it with a Rubicon Express 3.5" lift and had some drive line vibrations. So, I decided to purchase a slip yoke eliminator and use a rebuilt front drive shaft for the rear. I also starting having steering issues. The pump was leaking and the gear box was shot. Other than it leaking PS fluid all of the time, it wasn't a huge issue and was steering perfectly fine. I had a friend install the SYE, new steering pump and gear box in the same day.
When I drove away, there was a slight rumble from the rebuilt drive shaft and my steering was all screwed up. I could barely turn into a parking space. U-turns were completely out of the question. I assumed the issue was that the new gear box was off center and have been waiting for my friend to have the time to redo the job.
In the mean time, I decided to investigate the rumbling drive shaft on my own. So I removed the front driveshaft and swapped it with the rear. Problem solved! The rumble is gone! I am going to rebuild a different drive shaft for the rear and in the meantime, drive without a front driveshaft. Interestingly, my steering issue has completely disappeared. I can now do tight u-turns and park without a single issue. What the heck is causing the issue?
View 16 Replies
Advertisement
I have a 1999 Jeep Grand Cherokee which I bought used. Last oil change they told me that the power steering pump was leaking. The leak was not enough to be seen, but it did seem to make some noise every once in a while so I took it in to get a new power steering pump at the dealer. Two days after they put the new pump in, power steering fluid was pouring out on the driveway, it was a really big puddle of fluid. I had to put new fluid in to drive it five miles back to the dealer. They said that it needed a new line, they were not sure why it needed a new line, they guessed because of the high mileage, 164,000 miles.
I told them that my Mercury has 287,000 miles on it and has never had the power steering pump replaced or the line either. I have driven most every car I ever owned 300,000 miles and have never replaced a power steering pump or line. But anyway, when the Jeep was supposed to be ready, they told me that the new line blew up spraying fluid all over the shop as soon as they started the Jeep and they had to get new parts so it would take another day or two. My question is what caused the new line to blow? My thinking is there must have been something wrong with the new pump or with the installation, somehow it was outputting too much pressure, anything that could blow a new line, would blow the old line.
View 3 Replies
My 2001 jeep cherokee sport had a transfer case boot replaced a few months ago where the "oil spinner?" is near the rear portion. Before that went out i had periodic noise that i narrowed down to the transfer case using a mechanics stethoscope. Now i have a cluncking noise with gear grinding sounds periodically between 15-35 mph. I have annecdotal evidence from another forum that it may be the oil pump in the transfere case related to a TSB, yet i cannot find this TSB. Am i on the right track? It appears that i can get an oil pump for $60 but i have to consider dropping the case myself and pulling it apart.
View 3 Replies
A few days ago I had a big PS fluid leak. Turned out the return line had been sliced a bit. I had to drive it for a couple days before I could get around to fixing it. The steering is still stiff and the pump whines. Is this an indicator that I need to replace the pump?
View 4 Replies
I have a transmission cooler attached to my transmission. The lines that connect it are leaking around the crimp fittings. I figured if i just cut the fittings off and used 3/8 fuel line, would i be ok. I am afraid that i might get some air into the lines and mess my transmission up...
View 5 Replies
When cranking, i have to give it gas and rev it til it smooths out. Eventually it will run smoothly. When i throw it in gear, it wants to sputter and die out. If I put in D, i have to give it gas or it dies, but I can only barely touch the gas or it dies out. There is a vacuum leak in brake booster, but ive been told the headgasket could be blown.I want to know if the head gasket could be a problem and if its worth replacing the booster.
View 2 Replies
I thought my transmission was not going into 2 gear, but it is. But it ain't going into 1st gear. Just found out today.
View 2 Replies
I have a 2002 Jeep GC with the 4.7 v8 84k miles.
I noticed that the fitting on top of the pump with the clip bracket is leaking I removed the clip and tightened the nut/fitting. Moved just a bit. The hose is loose in there and I can pull it up and down like I said it's loose. It's weeping PS fluid. Is this suppose to be loose or is there an o ring inside the fitting? I'd like to get this fixed I before it gets too cold out.
View 7 Replies
I have a 96 Jeep Cherokee, 2wd, 4 cylinder, manual transmission, I have had some work done on it. Recently, I had the clutch redone, then I had a tune-up and the motor mounts replaced.
After the motor mounts were done, I was unable to get the vehicle into gear. My mechanic adjusted the clutch pedal and it was running as long as I did not put it into reverse. I had driven it about 3 miles from my house, parked it.
Came out to start it a couple of hours later and it would not turn over. It wanted to start but no engagement. I had to have it towed to my house where my mechanic could check it out.
Since that time, we have determined that it is not the fuel pump, we changed out the fuel injectors, replaced the coil, replaced the crankshaft sensor and it is still doing the same thing. Have gone through all the suggested remedies.
View 9 Replies
My manual transmission 1995 Jeep Cherokee today refused to go into any gear after I had stopped for a light. After pushing it to the side of the road I was about to call AAA when it went into gear and worked perfectly thereafter. This happened once before about a month ago. What could be the problem and how likely am I to get stuck for good?
View 5 Replies
Dashboard lights out, on 1999 jeep cherokee. seem string because transmission gear level lights is also out. on the floor.
View 10 Replies
My 94' Jeep cherokee 4.0l 2wd has had an issue that the steering over the course of several years has get some play in it now. It also makes sounds as documented in the video. I should also note it doesn't seem to do it when it's warm, but when it gets around 50ºF or lower the problem is there. [URL] ....
View 2 Replies
I have a 1999 jeep cherokee 4 liter in line 6.tilt steering wheel is lock in one position. The handle that you release to move the steering wheel up or down don't have any tension on it.
View 1 Replies
The passenger side of my jeep accumulates water when it rains. (leaking Sunroof) I remove the water as soon as possible, however Lately it has developed problems starting. There is a clicking sound that is coming from under the glove compartment or maybe the fuse box in the same area. Is it possible that the fuse box could be causing the shortage and my next question is can this problem detected/ corrected, by rewiring entire box or damaged wires? I love my Black Beauty, very little problems and only 112, 000 miles.
View 4 Replies
I have a 1995 jeep Cherokee country that has 130k miles. I have notice that when I shift from park to drive, park to reverse, drive to reverse or vice versa It makes this thud noise after placing it in gear. Is this a sign that the transmission is about to go out ? What action should I take? By the way its a automatic transmission
View 1 Replies
Just got a 1996 Jeep cherokee with right hand drive, 73,000 miles. Drove it less than 2500 miles when had problems with it shifting out of first gear. Would rev up the rpms to 3500 to 4500 and then a large jolt before going into next gear. Took to transmission specialist who was able to get it to act up., Now he tells me that the transmission is an import??? (was manufactured here in states and sent to Japan) Can't get the codes on the machine to tell him what is wrong with the tranny., says the codes say it is ok. Now what do I do. I need this car as I am a mail carrier and it was bought for that purpose.
View 8 Replies
2001 Jeep Grand Cherokee with a hard steering problem. I've changed the power steering pump, high pressure hose and gearbox.... the fan spins slow and it still steers hard ... could this be a hydrolic fan problem ???
View 10 Replies
My wife and I just bought a pre-owned 08 Jeep Grand Cherokee with about 60,000 miles that just started to make a whistle sound on initial acceleration and deceleration when the engine is warm and the transmission is in gear and moving. The sound does not happen with a cold engine, when the transmission is in park, or neutral. A local mechanic checked it for vacuum leaks and didn't find any. He thought it may be a dirty throttle body, so I cleaned that out really well, but the whistle didn't go away (it did make the jeep run a lot smoother!). It's difficult to pinpoint the noise since it only happens when the vehicle is actually moving.
View 8 Replies
My '95 Grand Cherokee (104K miles) just started groaning when I make full turns. After first 1 or two turns, right or left, can hear the steering column groan and feel some resistance. Have I lost power steering fluid? or worse?
View 2 Replies
I've got the feeling wire clothes hangers, duct tape, & screw clamps may be handy,;>). there appears to be a security cage around the fitting where the hose connects to the pump.
View 1 Replies
I am replacing my leaking power steering pump. I checked the hose connections and it doesn't appear that the leak is coming from there. I have removed the right front wheel and have the car on jack stands. It is really tight under there.
If I remove the cross member under the power steering pump will that allow me to get the old power steering pump out and the new one back in?
Will the removal and reinstall of the cross member affect alignment.
View 4 Replies
