Golf - Volkswagen :: Loud Pop Noise With Clutch Depressed?
Jun 6, 2016
I've been driving manual transmission vehicles - from my '72 Pinto to big trucks - for 40 years. This happened recently in a VW Golf I had rented: While driving down a mountain in a tunnel in Norway, with the clutch depressed, there was a loud POP noise.The clutch became engaged, and the clutch pedal did nothing. I'll spare you the details of the harrowing aftermath, the language barrier issues in the sticks of Norway and such. In the end, the rental company is charging us a couple thousand bucks for breaking their car. I maintain it was not Driver Error. My local VM service manager indicated that the Slave Cylinder on the Golf has been a problem for years, and is probably what went bad, but - as a rep of VW - is not willing (allowed) to put that in writing. The garage that fixed the Golf indicated it was Driver Error. I'm guessing everything tranny-wise got beat up when the Slave gave out, making it look like I'm a bonafide Clutch Masher.
View 19 Replies
Advertisement
I've searched but can't find what my problem is , ON idle when clutch is not depressed loud ticking noise , but when I push the clutch in it goes away . Also the ticking noise will get louder if I accelerate . ONLY Im first gear will I hear a loud grinding noise which means I have to quickly switch into second . Sound similar to something being dragged along a fence . Again the grinding sound I'm first will only happen if I'm giving it gas. Car has 325,000 km . Something with the transmission ?
View 1 Replies
My son's 1988 MK2 Golf GTI recently began a most curious random rough idle, occasionally to a stall, especially when turning abruptly, or when initiating a stop with the clutch depressed, and now always when turning at low speeds in combination with brake application. This only occurs when the engine is warm. The braking clue first led me to investigate the brake vacuum booster as they will cause that symptom when they fail internally, but if they fail, the sudden low , rough idle symptom is repeatable. This is not the case. Sitting in the driveway I can depress the brakes firmly with no change in engine rpm. Idle stays steady and normal. So I checked carefully for vacuum leaks, found none. Checked all the fuel system sensors and idle speed regulators, all are in order. New battery, good output from the alternator, ignition timing strobe is steady and bright. All the air intake rubber is like new. The in-tank fuel transfer pump works. The high pressure external fuel pump works.
View 8 Replies
This is regarding my 96 BMW 328i. It has approximately 177,000 miles on it. Over the past year, I've replaced the cooling system, fuel pump, alternator and trans fluid for kicks. So, I'm understandably frustrated with it. Anyway, to my story:
On my way into work, whenever I pressed in on the clutch, it would make a loud clunk/pop and freak me out. I turned around after 1/4 of the way and swapped cars.
My mechanical skills are maybe 3 on a scale of 1 to 10. I'm not afraid of changing oil, brake pads, transmission fluid, changing an alternator, etc. But I want to have someone to blame for anything that involves anything within the engine block/head/transmission continuum.
I noticed that a heat shield was loose between the driveshaft and the exhaust. I rapped it with a hammer, and the heat shield didn't make a noise anything like I'm hearing. So, it doesn't sound like that's the real culprit here.
View 5 Replies
I read all of the threads regarding clutch vibrations and other problems but I have 1,500 miles on my R and since day 1 I have been feeling a very slight ticking on my foot when the clutch is depressed. It gets more pronounced when I rev the engine a bit but nothing you can hear. Is this a normal feeling or should I not feel this at all.
I'm getting the APR tune next week and will do HPFP/intake soon but I need to be convinced that the Carbonio Intake is actually an upgrade from the stock intake with just a K&N filter, it doesn't look much different, the intake area looks the same as stock. I don't want to have to modify the engine cover or else I'd get the VWR intake. Any experience with the K&N vs stock vs Carbino?
Not sure if it was just the hot/humid weather yesterday but the car felt a little boggy when starting in 1st gear like it was running too rich or something. Any history of this?
View 12 Replies
I own a 2003 VW Jetta 1.8T GL Model.
When in Idle the car starts to make a ticking noise and tends to get louder the longer it sits. On top of this the idle does seem louder than when I first got the car like a constant purring noise if that makes sense. I am only able to hear the ticking while in idle, but the purring noise is continuous even while driving. I'm not sure what the problem could be but have the necessary funds to make some repairs on my car though not tons.
My car currently has approximately 128,500 miles on the engine. I'd like to keep this car running for a long time.
View 1 Replies
I have a 2002 Subaru Impreza WRX and recently it started making a squealing noise while the clutch is depressed at low speeds. I've researched that it's likely the pilot bearing or bushing? My questions are: should I have the entire clutch replaced? How much should it cost? And will I cause more problems if I wait too long to do anything? How long can I wait?
View 8 Replies
Ntices a strange idling noise? At first i thought it was just something like the radiator fan but it's tied to the clutch pedal..when the clutch is depressed the noise gets more isolated and a little louder. Everyone else in my car doesn't notice it but to me it sounds like something is out of balance... car only has 6500 miles on it and has never been driven hard... 2010 Golf 2.5 5spd .....
View 9 Replies
I have a 2011 Tiguan 125TSI with the 7 speed DSG. When it starts cold, you can hear a noise that sounds like a bad gear change when going from 3th to 4th, and 4th to 5th. It almost sounds like changing gears in a manual car without clutch completely depressed. It has been there since I got the car brand new, but recently it seems to be getting worse.
Once the engine gets warm, the sound goes away and gear changes are smooth.
I've asked the VW dealer about the sound and they tell me it is normal. Is this right? The problem is it is very hard to demonstrate to VW the issue since it may happen only once when the engine is cold. I've left it with the dealer overnight and they were able to reproduce it in the morning... but again, they tell me this is normal.
View 2 Replies
In my 1998 Nissan Frontier I had the clutch replaced at about 115,000 miles. That included a "clutch kit" which included a new throwout bearing. Currently, I'm at only 145,000 miles. Much of that is highway miles.
However, a noise has developed. It's a whirring or humming that happens when the clutch is depressed (disengaged). The noise is not present when the clutch is released in any gear, including neutral.
My first guess would be the throwout bearing, but again, that was replaced only 30,000 miles ago, and plenty of highway miles. The original lasted as long as the original clutch.
My second guess would be the pilot shaft bearing. That was not replaced with the clutch. (So the shop says.)
Any other guesses or advice? No matter the case, is it a problem if I leave it be? I can live with the noise if I know it's not really a problem.
View 4 Replies
I have a 2014 Passat TDI with a 6 speed manual. When the clutch pedal is depressed between upshifts, there is an audible groaning sound and a vibration in the clutch pedal. The dealer replaced the throwout bearing but the problem persisted. They then replaced the entire transmission and the noise/vibration is still there. The noise follows engine RPM. Is this normal for the TDI powertrain? The dealer had never encountered the noise but they did find another car on the lot with the same noise.
View 2 Replies
This morning when I started my car the RPMs were all over the place. The engine would rev to just below 2k and then drop, as it it were gonna die and right before it did, it would rev back up. Then, when I tried to move it, it would not accelerate and would hardly move and while coasting it dies if the clutch is depressed. The car does not die when idling (albeit a very rough idle) but it does when it is moving.
It flashed a check engine for a few seconds at one point but went away and has not come back on. I am running APR Stg 1 and a Carbonio intake. I switched from 93 octane mode to stock and nothing changed.
View 3 Replies
I have an 06 Beetle 5 cylinder, and just the other day, after getting a new battery and they installed it, when I'm driving and step on the gas into overdrive, it gets really loud, almost like a knocking or loud muffler that has a hole it it. However, it doesn't do this when I'm in park and step on the gas. Only in drive. It still has great power, but is loud now. I'm worried that the shop did something to mess it up, but they won't check it. There is enough oil in the engine.
View 1 Replies
I have a 2013 VW Sportwagen TDI. I have been driving with my windows down and recently started hearing a noise (don't hear it when windows are up). The sound only seems to appear when I first start driving the car (after a few miles it seems to stop or at least is much less frequent), as I slowly (normal) accelerate and especially as I turn into a corner... I hear a loud "ticking" sound. It "ticks" 6-12 times (over about 5 sec) and then stops altogether. The sound has a very metallic character.
I looked at a youtube video demonstrating diagnosing and repairing of the CV joint(s) and am not convinced this is my problem. The tone and frequency of the "tick" sound shown in the video is way different than what I am hearing with my car.
View 4 Replies
2013 tdi 6mt. I am noticing that my clutch clicks when the pedal is depressed. it does not happen when I first start driving in the morning, but it seems that once the cabin is warmed slightly it starts then clicks each and every time. It is annoying and it appears to be related to the different temps outside vs the cabin. I did not notice it during summer or early fall but it is cold here now.
View 24 Replies
I have a 99 VW Passat, it is making a loud buzzing noise as I accelerate to speeds above 20-25mph. The noise sounds like a baseball card in your bike spokes (or a room fan) does. The noise disappears when I push the clutch in. Here's the really weird part: when revving the engine as it's parked in neutral, there's no sound. What the heck is going on?
View 3 Replies
My 2001 VW New Beetle has started making a loud, whining noise coming from outside the car along w/ some buzzing whenever I am driving. I find that I have to change gears about 10 miles sooner than I should in order to stop the noise. But now it's happening in 5th gear occasionally too, and of course I can't go to a higher gear to make it shut up. What could this mean?
View 3 Replies
VW Rabbit 09 - Makes a loud noise coming from the back of the car, at first I suspected exhaust, but it does not get louder from hitting the gas. The noise gets louder the faster car moves starting around 20 mph. It sounds like it is running at high RPMs but the tachometer does not read over 3000 RPM. There is no check engine light on currently, in the past the light has come on after driving through puddles and then the car could not shift into the higher gears and would be stuck at 40 mph.Eventually, it would resolve itself. I have inspected the exhaust but I can not see anything that would cause the noise. The transmission does seem a little sluggish to shift, but it is a smooth shift.
View 1 Replies
I bought my Hyundai new in late 2011. No problems with the car (other than no spare tire???) until just out of the warranty (63,000). Had a noticeable drop in power on the highway. No warning lights. Drove another 100 miles with power intermittently dropping. Next day engine light comes on. $800 later I have a new high pressure fuel pump. All seems well. after a few weeks, I notice that the car seems to be revving when I depress the clutch to change gears, like up to 4000 rpm's. If I leave the clutch in for a few seconds it will begin to decrease. But if I shift right into gear as I have done for the last 35 years of driving, it is not smooth, jerky. This seems to happen mostly going into 2,3, and 4th gear, always going up. It never happens when downshifting. I tried tapping the brakes when shifting up, and sometimes it does seems to drop the rpm's. What it might be. It probably is related to the work that was done, but I don't really trust the dealer and want to have a little info going in.
View 1 Replies
2009 Accent 5 speed 66K miles. This is something which I recently noticed with the onset of winter. When I depress the clutch pedal, I have a very audible squeak. Think old door hinge squeak. So metal is rubbing against metal somewhere inside the bellhousing without enough lubrication.....not good. I pulled off the dust boot on the side of the bellhousing and tried my best to push moly grease around the clutch fork stud, hoping that was the origin. The noise went away for roughly a half a day but is back in full force....funny how cars do that.
Space seems EXTREMELY limited on lubricating the proper area. Or....is this a warning mechanism built into the clutch pressure plate assembly to warn of replacement soon? While I am asking these questions, what is a good time to look into replacing the clutch? The parts for the car seem relatively cheap, if I replace the clutch assembly, I may consider replacing the flywheel and clutch hydraulics as well as a whole system replace/refresh.
That aside, is there anyway to eliminate the squeaking without having to crack open the bell housing?
View 13 Replies
I have a 09 Sonata which when shifting once, the clutch depressed but did not come back up. While waiting for Hyundai service to come I tried to move the car down the hill to a shady spot on curb for my son and the clutch started working normally and has for 6 months...
View 2 Replies
