Ford - Expedition :: 2003 - Lights Get Bright Then Dim And Engine Will Die / Lose Power Steering And Brakes
Sep 17, 2016
My 2003 ford expedition with the 4.6 v8 engine is having an issue i cant seem to pin point. The lights will get bright and then dim and the engine will die and I will lose power steering and brakes, it will start back up when i put it in park. Also while I am driving randomly the rpms will shoot up to between 3 and 4,000 rpms and go back down. I have seen a video on youtube that says the fuse box in this model is very likely to short out and ruin the circuit board. Mainly looking for any experience any of you have with a issue like this. The check engine light is on, Showing two codes for running too lean and a code for Idle air control valve. Mileage is 239,000 ...
View 9 Replies
Advertisement
I just wanted to share with you all a cautionary tale about belt tensioners and idler pulleys. I am now a firm believer in installing the aforementioned items when you replace your drive belt. 15000 miles ago I replaced the drive belt and didn't heed the warning of some here on the forum.
For the last month or two I have noticed what sounded like road noise which I dismissed because I had just had new tires installed that had a more aggressive tread pattern than my previous tires, I also noted that the ECT had been a bit higher than normal, like running in the high 190's to low 200's on average.
Well while driving today I get the alternator warning light and lose power steering and soon after the brakes got stiff, this was followed by ever increasing ECT which got to 242* before I could get it off the road and shut down. It is too early to tell if the noises and the ECT temp rise were the result of this tensioner going out...
For what its worth the only tools required were a 10MM end wrench and a bit of skin to get the job done.
View 5 Replies
I've got an E99 powerstroke. Recently it's been getting hard to steer, if not impossible. When I'm parked i can't turn the wheel and it gets better if i Rev the engine up, driving is usually ok and going around corners. It's just low speed, low rpm that it won't.
Also every once in a while when braking it feels like i lose all power brakes. The pedal goes to the floor and the brakes let go, then i can feel the pedal pump back up and i get a good feeling brake pedal again that actually stops well. All this happens within about a seconds time. But the steering is by far the worst.
I just did the power steering flush with atf and it didn't work. I'm thinking i need a new power steering pump, but want to ask here first to make sure. The truck has 290,000 on it, and it never has been replaced to my knowledge. I bought the truck with 147,000 however so it may have been done before that.
View 3 Replies
The problem occurs when you hit bumps while braking, or if you get on the brakes to hard. It seems like the brakes lose pressure entirely and the pedal goes to the floor. It kicks back in when the ground smooths out, or if you are braking hard it slowly grabs again. At first i thought it was sliding, but it definitely is not. The truck appeared to be equipped with abs but the previous owner seems to have cut the abs wire/sensor at the hub. Another thought i had is maybe the brakes need to be bled and have fresh fluid put in them, I have not tried this yet (Plan to this weekend along with a dozen other things). Its rather scary when it happens. but i didnt think much of it until i nearly rear ended someone..with my younger brother in the car. Now i need to fix this asap.
View 14 Replies
First, while driving, my radio dies, my lights start to dim, and I lose my power steering. The first local shop I took it to installed a new alternator and I drove it home. Died again while I was driving. They then replaced three alternators with same results thinking they were bad. Ended up refunding my $400 and putting my original alternator back in and I had my car towed to the Hyundai dealer.
They had car for four days while testing it after charging the battery. They could find nothing wrong with it(again, no charge). Picked it up and drove it home(with someone following me). Two day latter, dead again. What is draining my battery? Do I have a short or something?
View 11 Replies
Yesterday while driving, i lost all power steering and power brakes (you would automatically think Booster). I pulled over, popped the hood and fluid was spewing from behind the power steering pump somewhere. I limped the truck home about 20 miles. I checked brake fluid and it was full. checked power steering fluid and it appeared to be empty. Yet when i added fluid it took less than a half quart. I started the vehicle to pressurize the pump and find the leak. Yet the pump never pumped any fluid. (one would thing pump was out) I am baffled as to if the pump went out, why fluid loss? If the booster was out, why do i still have brakes just without power assist? Andif a hose is blown, why such small fluid loss? I dont want to just start replacing parts till it get the right one
View 1 Replies
I put a re manufactured alternator in my 2000 f150 with the 5.4 liter. Now all the lights flicker, go dim and then come back on bright again. I noticed when the lights dim, the heater fan speed also drops. The light flickering is constant and bad enough, that I can notice it in daylight also with the headlights on. It is really noticeable at night with the truck in drive (or any gear for that matter) sitting at a stop sign or sitting still in my driveway. I changed out the old alternator because it was making a loud chattering noise. I didn't have any trouble with the lights or fan with the old alternator. Why doesn't the battery volt gauge in my instrument cluster fluctuate all the time while it is doing this? It reads in the normal range all the time and doesn't move. The flickering lights are also noticeable at highway speeds, its just not as bad.
View 2 Replies
I've got an 01 7.3 lariat 4x4 with an 03 7.3 engine in it (long story behind that) but basically I noticed one day I had a hissing underneath my dash and my brake pedal was a little spongy but my truck stopped, well before I could get it to a shop and checked out it went bad. Coming up to a stop sign and as normal hit my brakes and right before it came to a complete stop the pedal shot to the floor and I lost power steering as well as brakes and went rolling out in the road and almost got hit. So it's been parked ever since and I have changed the hydroboost, the power steering pump twice, flushed everything and bled everything and still nothing, can't even find any leaks. What to even replace now or whether to just take it to a shop and spend another small fortune.
View 7 Replies
Driving home from movies tonight, I lost power steering and power brakes and the pump started growling. Looked in the reservoir and it was all foamed up. Within the last 20k mi I have flushed the system and refilled with power steering fluid. No apparent leaks at this time. And happened like someone flipped a switch. Fine one turn, nothing the next. What are the chances this is a fluid issue and not a mechanical one? Start with flushing system and adding Mercon V? Or is it likely pump is damaged?
View 7 Replies
All of a sudden steering is WAY to easy i can flip it one way or the other with my finger. Front end is tight no lose tierods etc and no play in steering box when you turn it the steering turns immediately.
Thinking power steering is going bad maybe over pressure? Repair will be a pain has central hydraulics lines all in way. 2000 F450 7.3 ....
View 2 Replies
I have a 2005 Dodge Caravan, modified for use for someone in a wheelchair. On two occasions now I have been driving and have lost ALL power, including all dashboard lights, signals, power steering and power brakes. Luckily both times I was able to pull over without much problem (aside from problems steering and having to mash really hard on the brakes). Turned off the motor, restarted, and everything seemed fine. The first time this happened I took it to my mechanic who said he was unable to duplicate the problem. The second time this happened (yesterday) was after a severe rainstorm. I can't remember what the weather was like the first time it happened.
View 3 Replies
Today I noticed when I was parking at work that my back tail lights don't seem that bright. When I apply the brakes and such or the backup lights are very bright, but just the normal tail lights didn't seem to come off as that bright. At night they may appear brighter but this morning in cloudy overcast sky's with some light snow falling I am not sure if the person behind could have seen my taillights at all. I have a 2003 Impala LS, it's just over 102,000 miles. Is there a way to test to see if your back taillights are bright enough or is there a way to increase how bright they are when on?
View 15 Replies
Was making a U-turn, and out of no where, had no brakes and no steering.. Not a fun situation to be in....
View 14 Replies
Problem started 2 days ago, driving around and my truck would stumble and lose power. Give it gas, won't rev up but it cleared and ran fine for a mile or so then it comes back (off and on all the way home). Check engine light didn't come on the first few times, came on a couple times on the way home (maybe 4 mile trip) but goes off when the truck runs fine. Thinking it was maybe the fuel pump (got 140K on the stocker). Talked to a few friends, some thought it was algae build up in the tank that was clogging the filter on the pump, underhood filter changed a couple hundred miles ago. Looked fine with slight brown build up at bottom of bowl when I replaced it.
Ran it around yesterday with a friend of mine and his scan tool hooked up, acted up once, check engine came on for a few seconds and shutoff. No code and for some reason we couldn't get it to live data while driving. I dumped in an algae eater yesterday and left the truck overnight since I had to work. Got home this morning to run her around the block to circulate the eater. Truck started and idled fine, went to pull out and she won't rev up, pumped the gas and NOTHING! Check engine light is on now but don't have a scan tool handy to read it. I heard the truck will store the code?
What this problem might be? What's a good scan tool for our trucks that can live data as well? CPS is good and already did the UVCH mod.
View 14 Replies
I have a 2010 Corolla LE w/ about 90k miles. I took it to work. parked. Went back to car. Engine cranks. Won't start. Lights are bright. Radio on. Jumped it and it started up no problem. Took it and got a brand new battery. turned car on and it worked with no problems. took it home. next day went to work. started w/ no problem. After work, started with no problem.
NEXT DAY... Engine cranks again....won't start. Tried to jump it again but NOTHING.
(also, just want to mention there is no history or indication that this was gonna happen. no jumpy starts...no shaking...nothing.)
Someone came out and checked: alternator, battery, starter, everything checks out good and working.
Spark plugs: GOOD but no spark...thought it might be crank sensor. Tried to change that out, still won't start.
In the midst of all this my key was acting up. finally it broke out of the lock part....the actual key separated (not broke) from the alarm part. i went to go make a duplicate w/ the key part and tried the duplicate key and it still won't start. do these things have a chip in them that activates the crank sensor? I've been w/o my car for about a week and i feel as though it's right in front of me.
View 7 Replies
I have a 99 F 250 7.3. It runs fine at idle even for a long time. When I drive around the block a couple of times it will start chugging and lose power and shut off. I have been mixing fryer oil with the diesel. I changed the fuel filter, oil change, crank sensor and fuel pump. I added 15 gallons of diesel and diesel treatment. Pulled fuel filter and bowel is full I'm not sure where to look next.
View 1 Replies
I picked up a 2003 6.0 awhile back went ahead and did studs,gaskets, delete. Was driving it and seemed to lose power, started coughing and carrying on blowing bluish white smoke then shut off. Ended up hydrlocking #5, Oring on injector was tore when took out. Put all back together, ran horrible, did a balance test with AE, showed #3 injector, replaced, ran horrible, did AE dropped #1 injector. So in process of replacing the rest of the injectors. Just wondering why it is or was dropping them 1 at a time. Ficm was showing 47.6 to 48.6 volts, could that be it?????
View 14 Replies
I have a 2001 F350, 7.3. My service engine light came on and immediately the truck started to run rough and lose some power. I've checked the under the cover connections and they were both connected, I replaced the cam position sensor and I still have the same problem. The worse part of the hold thing is that there are no codes stored so I'm flying bind. Where to go next.
View 8 Replies
I was driving my 2006 Prius on the highway (120,000 miles on it). I'd been driving about 10 minutes and all of a sudden, the dash warning lights lit up.
Red triangle with exclamation point.
Yellow circle with exclamation point.
Yello check engine.
The car did NOT lose power. It kept driving fine with no noticeable change in how it operated. Fuel consumption stayed the same. Braking worked fine. I had a completely full tank of gas (had just filled it up before I got on the highway). Temperature outside about around 60 degrees.
I kept driving to my destination (another 20 miles at highway speeds). The car sat parked for about 3 hours. I returned to the car, started it up. The same warning lights appeared, except for the Yellow circle with exclamation point. Plus, this time I noticed on the energy monitor screen the graphic of the red car with the exclamation point.
Again though, everything seemed to be working fine. While the car had been parked for 3 hours I did some browsing through the owner's manual and saw a notation that is the warning lights were only yellow and not red that it was okay to proceed with caution to the nearest dealer.
View 9 Replies
The engine on our Ford Expedition (2003) has started quitting for no reason. The engine light does not come on. We might be driving and it just stops or stopped at a light or turning into the driveway and it just turns off. Often it we simply turn it back on and it is fine but occasionally it is difficult to restart.
View 3 Replies
I had a dead battery on my '97 power stroke Ford F250. I realize now that when I was jumping it (successfully) I clipped the (black) ground cable to the alternator itself! Doy. The alternator is definitely dead now as I lose power after a few minutes of running the engine. My question is: did I blow a simple fuse or do I need to replace the whole alternator? How likely is it that I did further damage? I ask because I'm contemplating replacing the alternator myself. But maybe it would be wiser to get a tow to the mechanic.
View 4 Replies
