Dodge - Grandcaravan :: 96 - No Fuel Pump Activation / Crank Or Start In Cold Temp
Feb 23, 2013
1996 Dodge Grand Caravan, 3.3 L engine. When the outside temp is a good range (50 degrees F & above) there is no problem starting. But when it gets below 40 deg. F and really chilly outside temp, I still have strong battery power, but when I switch on the ignition, I don't hear the normal fuel pump activation swirl sound and does not crank - simply silent click. Then I can wait when the outside temp improves and cranks up no problem.
View 6 Replies
Advertisement
I have a 1998 Grand Caravan 3.8L engine with 157K on it. A month ago changed the EGR valve and replaced the transmission oil. Two days ago, went for shopping, parked the van. Came back and did not start (no crank, nothing). Called AAA, checked for battery, which was good. Radio, wiper, lights work. Had to tow to the shop. The mechanic checked for all possible problems. Said everything (Fuse, battery, starter motor, alternator) is good. He is clueless. Told him to check the ignition switch (may be worn out). He says it doesn't seem so.
View 19 Replies
Replaced the ac compressor/filter dryer/exp block on 04 dodge grand caravan. pulled vac for 45 min, let sit for 1hr. No movement of needles no leaks. charged system to 2.69, start van turn on ac compress clutch engaged but will not cycle off stays engaged. Air temp from vents 60 to 65 deg, low side 55 psi high side 250 psi at 85 deg air temp needles do not move up or down stay steady. high side hose from compress very hot ( burned hand on it ) low side hose to compress warm/cool.
View 5 Replies
Our 1997 Grand Caravan with 170K loses more air conditioning every year. So, I assume I have a slow leak. Is recharging something I can do myself with the new type cans offered by auto parts stores? Also, I think the radiator fan no longer comes on, I never hear it and the engine temp will go up when driving slowly around town.
View 1 Replies
vue would crank, not start. 5 min later it started. done this 3 times in 1 month. changed original fuel filter. am leaning towards fuel. vs spark. no codes. I see pump assy's for $175. or a pump alone for $30. if I remove tank and pump assy, would there be any issue with changing pump alone? not paying shop so its my effort the last gm pump assy I did had a working pump but corrosion on leads to pump inside tank. I replaced assy because I had already bought assy.
View 13 Replies
1999 Jetta 2.0L manual trans
One day out of the blue the car would not crank or start. Checked and found that fuse #14 was blown and would blow the instant another fuse was inserted. Checked all the typical locations for wiring issues usually associated with the comfort module because it had all the symptoms of a faulty module (the power windows did not work and the fuel pump didn't pressurize the system when the driver door was opened, the alarm didn't set, automatic door locks also inoperable).
I checked the dome light, trunk hinges, rubber boot between doors and body and found nothing. Put a jumper wire into the neutral start relay and was able to crank the car. I then replaced clutch safety switch, neutral start relay and installed new (junkyard) comfort module and the car cranked up, started and everything was working normally again...for about 3 weeks. Then it did the exact same thing again. Fuse #14 was blown again and would blow the new fuse as soon as it touched the terminals in the fuse box.
I reinstalled the jumper wire in the start relay in order to be able to drive the car for the last week, and then last night out of the blue the car would crank, but not start. I turned the engine over several times and could hear the fuel pump pumping and even smell fuel, but no start. 3-5 minutes later after random tries to start, the car stumbles to life as if it wasn't getting fuel, and then drove 10 miles home with no issues. I returned the 'faulty' comfort module Monday and got another one but haven't installed it yet because I fear the same thing happening with this one as the other one.
Last night after I got the car home, I plugged in the comfort module and everything worked like it was supposed to. Can a faulty fuel pump damage the control module? I'm trying to get to the bottom of this and fix the problem and not the symptoms so I'm looking into anything that could potentially cause the problem.
View 3 Replies
I know this has been an issue for awhile and many may know about it but many probably don't. The issue is dirt and salt debri etc get packed behind the Fuel pump driver module rot it out and without warning you have a crank no start or worse it dies going down the road then you and the family are stranded or worse while towing on a trip. I made a video on how it happens and how to fix it with the solution Ford came up with. It is worth checking even if you don't seem to be having any issues yet......
View 5 Replies
I have an 04 Ford Explorer XLT 4.0 Flex Fuel. There has been loss of power to fuel pump. Relay and fuse both good, replaced the inertia switch...still nothing. Could a FPDM (fuel pump driver module) have anything to do with this issue? Or what should I check next? I am definitely at a loss as to what the issue could be! I know it is fuel related because I used starting fluid and it started right up and run for just a few seconds, so that should rule out ignition I think.
View 3 Replies
Sometimes after running my 94 Limited, it doesn't want to start - it does crank - like it's not getting fuel. I have found the work around and want to know if it would be fixed by replacing the fuel pump relay.
The symptom is just after starting, it starts to run poorly, and then dies out, then will not start at all. I use to keep trying to start it for 20-40 minutes and suddenly it seemed to work.
It seems the work around is to turn the key to on for about 5 seconds and then turn it off - then it starts and runs as good as ever.
So, is this a symptom of a bad relay? I thought I'd start there because of the cost of the relay is fairly cheap. 1994 Explorer Limited 4x4?
View 14 Replies
I own a 2003 Limited with the 6.8 V10. I drove the truck on Sunday and all appeared to be fine, gas gauge was setting just under a half tank. When I went to start it yesterday, it would not start. Strong crank, no start. I checked my fuse and it was fine. Fast forward to this morning, since I had kind of depleted the battery with attempting to start, I put my little jump start pack on it and gave it a whirl. Truck started fine but the gas gauge was sitting on empty. I had five gallons of gas in the garage so I added that to the tank then drove to the local gas station to add more fuel. I put another 10 gallons in the tank so it should have roughly 16 or 17 gallons in the tank. Gauge shows 3/4 tank but miles to empty is right around 175 miles which would seem right with 17 gallons in the tank. I suspect the fuel pump. I don't really want to spend $500 on the Motorcraft unit but was wondering if the group believes the Delphi or the Bosch units are quality replacement parts?
View 7 Replies
Black Beauty finally gave up. Replaced battery, replaced fuel pump relay. Would only run with starter fluid sprayed into the air intake. She'll crank but not start. Here she sits at the dealership.
View 14 Replies
Sometimes I'll walk my wife out to the garage in the morning when she is leaving for work. When she starts up her 2006 Dodge Grand Caravan FWD sto n go I hear a clicking noise for about 2 seconds. To me it sounds like the lifters prior to getting the oil delivery. I was wondering if that was going to eventually cause some engine damage and also if there is a problem with the oil pump or something like that. Is this a problem that I should check into or is this normal for this van. We hit a deer several months ago and the whole front end was wasted. I don't remember hearing this clicking sound when the van was newer.
View 10 Replies
Intermittent fuel pump problems in '96 Dodge ram resulted in new fuel pump 50,000 miles ago. Happened again 100 miles ago, so another new fuel pump. Now to start car must turn the ignition on several times before going to the start position. It appears the latest new pump may have defective one way check valve, so the pressure is depleting after turn off. Any favorite brand of fuel pump for the Dodge "pump in the gas tank" arrangement? Or solutions such as installing an external pump to do the work of pumping the fuel?
View 1 Replies
I have a weird A/C issue on my 2002 Dodge Grand Caravan. It has steam coming out of vents randomly and when this happens the A/C no longer cold. I turned off A/C and let the fan running for a while, then turn A/C back on and it's cold again. I also notice the A/C will be cold when the fan in 2x speed. It has water dripping out at the right rear and in the front, I understand this coming from A/C but at the right rear?The cabin air filter is clean (replace last week), this could have been something dirty or the vent stuck open/close that cause cold air re-direct its flow to somewhere else!
View 4 Replies
I just got delivered a 7.3L from down south. Batteries were dead so replaced both. Fuel was a couple notches above red line (much closer to red line than 1/4 tank) so I added about 7-8 gallons.
It will crank forever and ever...Won't start.
With starter fluid it starts but not strong enough to pump the pedal and rev it up to keep it idling.
I know s-fluid is bad but if I continuously spray with key turned forward it will run but as soon as I let go of key it shuts off.
20 degree weather and it was delivered to a parking lot so I cannot plug it in.
Was told to check filter cap, turn key, and see if it fills bowl with fuel....if not then it is fuel pump. Someone else mentioned that it could be bad crank position sensor? Does this sound like fuel pump?
View 2 Replies
1995 Ford Explorer, 4 ltr. engine, pushrod. Will not start. Replaced fuel pump, fuel filter, every relay, pressure regulator, and the crank position sensor. I realize there's a whole bunch more parts under the hood, but I am ready to give up. Before the fuel pump would not run. Reason for replacing the parts. Now it won't stop running and you can feel the fuel by-passing at the pressure regulator. When checking the pressure at the rail I get zero !! I used a tire pressure tester for this. And, like I said no pressure. This vehicle has around 170,000 miles on it.
View 8 Replies
I got a great deal on this van, and I love it, with one exception. On hot days (73 degrees and hotter) the van will not start if it has been parked in the sun; until the temperature returns down to around 61 degrees (usually overnight, but I have waited it out in the parking lot at work a few times).
When this happens, the lights and radio work fine; the starter motor will not engage. No click, no chugga-chugga vroom-vroom. Sad Curto.
Note: October through about May in North Carolina, this car is fine.
I have replaced the steering column (after replacing the clock spring); I have replaced the Power Distribution Center.
When the problem first surfaced two years ago, I had a mechanic install a wire directly from the starter motor relay to the solenoid. That was an expensive lesson. I'm not sure what the lesson is, so it was REALLY expensive.
So, I thought maybe the Auto Shutdown Relay. Nope... pull that out, and the starter still turns, so that is not my problem. Now I am starting to thing Powertrain Control Module, or something else that could have a temperature-sensitive component.
View 10 Replies
ok, i just became the proud owner of a 71 dodge dart.. fuel pump was not working, and am converting to an electric (airtex e8016s) and am told i need a relay. airtex doesn't seem to have one, is there another i can use? fairly new at this sort of thing, but have fixed a 72 honda motorbike, so not afraid of engines or whatnot.
View 19 Replies
I have a 1993 Grand Caravan 3.3L V6. When I leave the van set for a couple a of days (or even overnight) and then start it, I have no oil pressure for a minute or so. After the engine has been running for about a minute or so the oil pressure finally comes up but not to normal. Once the engine has warmed up the oil pressure returns to what could be considered "normal". After the cold start, no oil pressure problem, the engine and the oil pressure is fine for the rest of the day. Let it even set overnight though and I have a repeat no oil pressure with start up.
I am thinking that there is a problem with the pick up tube not sealing properly and allowing the oil to bleed down while the engine is off for an extended period of time. So, in effect, I have to basically prime the oil pump at each start up. I haven't noticed any leaks of engine oil anywhere, so I am thinking that this is an internal problem. Is there a check valve or O-Ring associated with the pick up tube or oil pump that may cause this problem? Is it a fairly easy problem to correct? On this engine the oil pump is located in the front of the engine block behind the timing chain cover. (As best as I could determine from the Haynes Manual).
View 13 Replies
We have a 2003 Dodge Grand Caravan which keeps on shutting off or sometimes will not start up. When it has problems starting up, there is no turn over of the engine. Just nothing. After awhile, it will start up. During driving, it will just shut off. At first it would start right back up but now it will not start right back up. We have replaced the computer and the crank shaft sensor. We have taken it to two dealerships and they do not have any ideas as to how to fix it beyond what we have done. Our mechanic is baffled. He has checked the wiring and sensors but cannot find the problem.
View 3 Replies
I have an ' 87 Caravan/mini ram van with the Mitsu 2.6 4 cylinder engine. It has 180k miles. Always ran great until now. It'll start right up (the first time) on a cold morning with no problems, but runs a little rougher than usual. Before the engine is warmed up on a cold day, needs to wait a little while before starting to drive it. Recently, I've been starting it and letting it idle for about 5-10 minutes. When I start driving it, normally I don't even get out of my driveway, it stalls and won't restart. It seems like the carb might be flooded, but not sure. Could this simply need a tune up? I haven't replaced the plugs yet since I've owned it, I've had it for only a year so far. The previous owner was very meticulous about maintenance.
View 3 Replies
