Dodge - Grandcaravan :: 1998 Not Starting / No Crank
Jun 3, 2013
I have a 1998 Grand Caravan 3.8L engine with 157K on it. A month ago changed the EGR valve and replaced the transmission oil. Two days ago, went for shopping, parked the van. Came back and did not start (no crank, nothing). Called AAA, checked for battery, which was good. Radio, wiper, lights work. Had to tow to the shop. The mechanic checked for all possible problems. Said everything (Fuse, battery, starter motor, alternator) is good. He is clueless. Told him to check the ignition switch (may be worn out). He says it doesn't seem so.
View 19 Replies
Advertisement
OK so I have a 2001 Dodge Grand Caravan 3.3L V6 with 125,000 miles. Recently about a month or so ago I began having a starting issue. Basically what happens is that when I go to start the car, all I get is one click. The engine does not crank at all. Now this will only happen once or twice in a row and then when I try to start it again the car will start fine and it does not have any issues at all.
This will sometimes happen 4-5 times in one day and then it works perfect for a week or two before it starts acting up again. Two weeks ago when I had this issue, I took it to have the battery, alternator and starter tested. Supposedly they all were good except the battery had a lot of corrosion around it. I cleaned the corrosion off and it started fine for 2 weeks straight before it started acting up again yesterday and today. I am worried that it will get to a point where it wont start at all. The battery was last replaced in December 2011.
View 4 Replies
1996 Dodge Grand Caravan, 3.3 L engine. When the outside temp is a good range (50 degrees F & above) there is no problem starting. But when it gets below 40 deg. F and really chilly outside temp, I still have strong battery power, but when I switch on the ignition, I don't hear the normal fuel pump activation swirl sound and does not crank - simply silent click. Then I can wait when the outside temp improves and cranks up no problem.
View 6 Replies
My father inlaw has a dodge van that is having problems starting. When starting it will crank, but will not fire. We have discovered that if you remove the 20 amp Oxygen Sensor relay, under the hood, and jump it directly to the battery, while starting if will start. The fuse appears to be good. Can the O2 sensor relay prevent the van from starting, but run after initially bypassing after starting? What it might be?
View 4 Replies
I have a 2007 Dodge Charger. Battery light came on, I had AAA come out to me to test everything because I didn't want to be stranded just in case the car died while I was out doing errands.
I forget the name, but he connects it to the battery. It tested the alternator, battery and the starter. Turns out, the alternator had an open diode. Battery was in good shape and the starter too.
I ordered a battery, and had to wait to get it installed because my mechanic was busy working on a whole bunch of other cars. So I had to use the whining alternator for a whole week before I could get the new one in.
But he got it installed. And put everything back together where it should be (I think). He told me to start the car. It started up beautifully! No troubles at all.
A couple days later, it started to struggle cranking to start. Taking into account the battery and starter are good and the alternator is like-new (refurbished). I do not understand why it's having issues.
There's no battery light on. Why would it, a couple days later, start having an issue? Could my mechanic have not fully connected wires to the alternator? When loosening the idle arm to loosen the belt, could the have messed with the timing?
View 19 Replies
Already replaced the starter relay will not crank from the key but even when I jump the starter the car still wont start and the switch is in the on position I checked all the fuses and replaced the ecm ....
View 15 Replies
I have a 1988 Dodge pickup 1500 with a 5,9 gas engine. It used to pop right over all the time. Now, in the morning, I have to crank it forever until it starts, and if it sits for 1 hour or more, same thing (have to crank for a long time). It is my understanding there is a valve called a one day valve that holds pressure on the gas line. Is it possible this valve is not working properly? And if so, do I have to replace fuel pump to fix problem? once started it starts up with no problem until it sits for hour or more then hard to start.
View 15 Replies
I have a 2004 Grand Caravan 3.8 engine. For the last 2 months the oil light has been coming on when car is first started. If I stop engine and start again the light will be off. I don't think its actual oil pressure because the car runs fine with light on or off. I'm thinking a bad pressure sensor?
View 17 Replies
Sometimes when I start my 2006 Dodge Grand Caravan, 3.3 liter engine, the oil light comes on and stays on, even if I rev engine up. Engine sounds normal, does not sound like oil pressure is low. If I turn engine off and the immediately back on, light goes out and stays out. I replaced the oil pressure sending unit - didn't work. I hooked up a gauge - engine has 60 psi oil pressure at idle - plenty! I'm guessing an electrical problem in the circuit.
View 4 Replies
I have a 2005 Grand Caravan, this winter has been a cold one. The GC has always started without problem but after I back out of my parking spot, it sits outside, I put it into Drive and it will not move and after I give it a little gas it would still not move. None of the gears seem to work, but if I wait a little bit and the Van warms a little more it will go into gear and all is good. This does not happen all the time and when it does go into gear and I drive I do not have anymore problems until the next time it will "act up" on me again. Is this a problem or is it a cold problem and not a transmission problem?
View 7 Replies
My 2000 Dodge Grand caravan loses its gauges every so often. engine light comes on as well as ABS...
View 2 Replies
I got a great deal on this van, and I love it, with one exception. On hot days (73 degrees and hotter) the van will not start if it has been parked in the sun; until the temperature returns down to around 61 degrees (usually overnight, but I have waited it out in the parking lot at work a few times).
When this happens, the lights and radio work fine; the starter motor will not engage. No click, no chugga-chugga vroom-vroom. Sad Curto.
Note: October through about May in North Carolina, this car is fine.
I have replaced the steering column (after replacing the clock spring); I have replaced the Power Distribution Center.
When the problem first surfaced two years ago, I had a mechanic install a wire directly from the starter motor relay to the solenoid. That was an expensive lesson. I'm not sure what the lesson is, so it was REALLY expensive.
So, I thought maybe the Auto Shutdown Relay. Nope... pull that out, and the starter still turns, so that is not my problem. Now I am starting to thing Powertrain Control Module, or something else that could have a temperature-sensitive component.
View 10 Replies
I have a 2004 Dodge Grand Caravan with 120,000 miles. Starting at about 45mph the car has a really bad shimmy when accelerating. The shimmy fades starting at about 55 mph. There is no shimmy when not accelerating. Gently applying the breaks has no effect on the shimmy. I've put on new tires, Change the steering rack and struts and the engine and tranny mounts. what could be causing this?
View 2 Replies
I have a '09 Dodge caravan. The ABS, ESP, TCS, and Brake lights are on. As we drive along the brakes apply, probably on only wheel. After we stop, we can drive on for a short way and it happens again. A mechanic told us that the steering sensor was telling the computer that the steering wheel was turned all the way to the left. I wonder if I pulled the fuse for the ABS pump and ABS valve if it would be safe to drive, at least until we can get it to the dealer for repair. I am cheap and like to get by as cheaply as I can/. I am not fond of ABS, or TCS any way?
View 19 Replies
I have a 1993 Grand Caravan 3.3L V6. When I leave the van set for a couple a of days (or even overnight) and then start it, I have no oil pressure for a minute or so. After the engine has been running for about a minute or so the oil pressure finally comes up but not to normal. Once the engine has warmed up the oil pressure returns to what could be considered "normal". After the cold start, no oil pressure problem, the engine and the oil pressure is fine for the rest of the day. Let it even set overnight though and I have a repeat no oil pressure with start up.
I am thinking that there is a problem with the pick up tube not sealing properly and allowing the oil to bleed down while the engine is off for an extended period of time. So, in effect, I have to basically prime the oil pump at each start up. I haven't noticed any leaks of engine oil anywhere, so I am thinking that this is an internal problem. Is there a check valve or O-Ring associated with the pick up tube or oil pump that may cause this problem? Is it a fairly easy problem to correct? On this engine the oil pump is located in the front of the engine block behind the timing chain cover. (As best as I could determine from the Haynes Manual).
View 13 Replies
Lifters are rattling. They have been replaced and are still rattling.
View 17 Replies
The 96 Caravan I bought a year ago came equipped with an aftermarket dent in the oil pan. It's a bent up generally flat, not all at one point, but there's no leak and no other apparent problem, though of course it does reduce the oil capacity. When I had some overdue warranty work done at a dealer, the service writer told me the dent is exactly where the the oil pickup is, which mostly sounded like the dealer looking for some extra work. I decided I'd replace the pan myself when I had enough miles on the car to see if it was worth the effort.
The pan has a lower sump area that measures roughly 5" x 7" and that entire portion is pushed up somewhat evenly. I'd estimate the deepest part of the deformation is almost an inch, so less than 35 cubic inches lost capacity. 35 cu in = .606 quart.
I can buy a new oil pan w/ gasket at Rock Auto for a shade over fifty bucks to add to an order I otherwise need to place with them. A used pan at the local junkyard would cost ten or twenty bucks plus my labor plus the gasket, which I judge as not enough cheaper to be worth my time and inconvenience (they want me to capture the used oil and take it with me). So it's either buy the new oil pan, or fix something else. Or pull the pan, bend it back to shape, and replace the gasket? It appears to me that the pan gasket may be seeping, though not enough to drip, so it's probably due for a gasket anyway.
Should I care about this, or learn to love the dent?
View 16 Replies
One tech wanted to replace both rotors and sanding down the pads to re-use (he said my brake pads can last up to one year). The guy in auto part said the surface of brake pads having hard spots could cause the pulsation, replace the pads. Of course, replace both rotors and pads is recommended but I have tight budget! What options do I have? can I just machine the rotors?
View 12 Replies
I know if you smell antifreeze when you turn on the heater that is a bad thing. I don't have this issue, but when I walk into the garage after my wife turns off the van I get a whiff of what smells like antifreeze. There isn't a leak that I can find and nothing on the floor the garage out the normal.
2006 Dodge Grand Caravan 80K miles
View 7 Replies
Our van shuts off while driving. This means I have no power to brakes or steering. The only warning light that comes on is the traction control light. Therefore when hooked up to diagnostics there is no information. We have had it to 3 different places with no results or answers. We did have the ignition switch recall performed. We have filed claims with Chrysler with no answers other than arbitration and with the NHTSA.
View 4 Replies
We have been having an issue with our gas tank not filling up continuously for over three years. It automatically trips the gas shut of switch every couple of seconds so it can take a while to fill up. Then every once in a while it fills up totally normally.
View 1 Replies
