Sone water from the air conditioner drains on the carpet on the right side of the car. The drain hose is open and water in draining from it. Where could I look to find the problem? It is a 2003 caravan
View 1 Replies1990 Dodge Grand Caravan, 3.3L
Three weeks ago, I had the starter rebuilt locally by a shop I've used confidently for years, most of their business is rebuilds like this. Besides a substantial coating of oil on the starter which was no benefit to the contacts, the tech also found a broken insulator which presumably was the primary issue. I installed the starter and have had no problems since (three weeks).
Yesterday morning, the battery was dead - no click, no lights, no horn. I could be wrong, but I don't think the interior lights were left on overnight.
I put my 1 amp trickle charger on it for several hours and when I reconnected the battery, the horn sounded right, interior lights looked good....until I tried the starter. In an instant, I got the chattering clicky sound of a starter with inadequate power , then nothing, and the lights and horn were gone too.
After charging overnight -almost 24 hours now, that same scenario has repeated: first good horn and lights, then clicks from the starter, then very weak lights and horn.
Is this simply that the battery is down and needs more charge? Or could there be something wrong in the starter causing this rapid discharge? A few months ago the same electrical shop load tested the battery and it was surprisingly good considering its age. I don't want to put a new battery in the car if the starter is somehow damaging the battery. I do have another battery I can swap in, but for the same reason I'm reluctant to install that without some better idea of what's happening.
Does this point conclusively to the starter? Or is this clearly the battery? Is there some way to diagnose the starter without removing it? I'm sure the shop would fix any mistake, but I don't want to pull the starter again for no reason. The cable connector on the starter looks normal.
I have a 2003 Dodge Grand Caravan and while I was driving it stopped on me. It will turn on but once you put it in gear it will turn off and wont turn back on. I have replaced the fuel filter and fuel pump.
View 3 RepliesWas driving home just now when my car (2003 Dodge Caravan SE) started acting strange. Stopped at a light, it started going back and forth a little, like the transmission was stopping and starting. As I drove I noticed that it kept doing that when I had the accelerator pressed slightly. When I pressed the accelerator more fully, the problem seemed to mostly (not completely) go away.
When I got home (after driving like that for about 2 miles), it seemed worse. When I stopped the car and had it idling in Park, the engine died. I was able to restart the engine, but it seemed like it was having trouble staying on (though it did for a minute or two until I turned it off).
When I got out of the car, I noticed a bad smell coming from the engine, like burning. Also noticed a loud sound, like knocking. My first thought was that I didn't have any oil. So I checked the oil and the transmission fluid. Both were fine. After about an hour I restarted the car, and it wasn't doing it anymore. Maybe because the car had cooled down?
What this might be or what else I can check?
My 2003 Dodge Caravan instrument and radio/heater lights stopped working. I don't see any bad fuses or fusible links. Odometer and other service lights work fine.
View 1 RepliesI have a 2003 dodge grand caravan with about 111,000 miles on it. Overall it has been a reliable car. In the past month we had to replace the ECM because the computer died on the car. Now, very intermittently, while driving at about 60 mph the car will suddenly drop to 40 mph then shoot right back to where it was at 60. This only happens for about a second and then its fine.
Its quite startling but it has only happened to us 3 times in the past two weeks, so its very hard to replicate. There are no engine codes and it seems like the tachometer does not change during this sudden drop, although to be honest I wasn't paying that close attention to it when it happened.
Could it be related to the recent ECM replacement? The dealer "reprogrammed" the computer so I'm assuming all parts electrically have been checked.
My 2003 Dodge Caravan is shutting off while I am driving, starts up ok but goes a little and then shuts off, has to cool down all day and night to go about three miles, got a diagnostics done and it says I need an engine wiring harness and controller. My question is, is there a curtain part of the harness or wiring that could be bad that causes it to shut off, and what part would that be, can it be repaired instead of replacing the whole harness and wires?
View 11 RepliesVehicle: 2003 Dodge Grand Caravan 3.3 Litre
I also have my CE light on. Hooked up my reader and got the "P1491 Radiator Fan Control Relay" code. I have checked my rad fan fuse and it is okay. My attempt to locate the rad fan relay took me from the rad fan wire to a device that looks like a heat sink. It is located on the vehicle frame between the rad. and front grill. Is this the rad fan relay? If it is I'm not sure how I would replace it. It seems riveted to the frame.
We recently had some oil leaks fixed on my wife's 2002 Dodge Caravan. The oil light comes on whenever she stops at a stoplight. It seems like it comes on when the RPM drops to about 600 or 700 RPM and then goes off when RPM increases. Is this something to worry about? If so what needs to be fixed?
View 8 RepliesI just had all 6 fuel injectors changed as they were rusted. But the 4 and 6 are still miss firing. I am going through gas more than I should. I had the EGR replaced as it was stuck open. I do not want to pour more big money into this thing. What can I do. Sea foam is not working. Could it be another problem. I am starting not to trust the mechanics.
View 12 RepliesI have a 2005 Dodge Caravan. I drive very little locally - usually just a couple of miles a week. But every couple of months I drive an hour and a half away to THE BIG CITY. Last week I took such a trip, and coming home I noticed my van was making a "jingley" noise. Just like the sleigh bells in the barn. With the windows open I can't tell where the noise is coming from. And it isn't associated with the a/c, since the a/c was off when the noise started.
Since then when I take my little local trips it only made the noise once - when I went over 35 mph. Usually drive slower locally. So, I don't know whether the problem is associated with length of drive time or speed, but I'm thinking it's associated with a higher speed.
Yes, I have an apt. with a mechanic, but I can't get in to see him until the middle of next week.
I've been fighting with these vehicle for months, and I've only been able to narrow down the list of possible issues. Tried replacing the ignition switch, battery terminals and cables, starter, and even a PCM since according to the dealership it was bad. I've checked all the fuses and relays, and they're all ok.
I'm getting fuel and spark, but no crank from the starter. The voltage going to the hot post on the starter is 12.7, but the voltage from the igniton wire is only reading around .5-.6, fluctuating a bit. Before I spend the money on taking it to a mechanic I wanted to know what your opinions were on what the next step is. I know a bit about electrical systems in cars but I'm no expert.
My van went from drive to 3rd gear while i was driving. and now its stuck in 3rd gear. its a 98 dodge caravan. i checked the transmission fluid it was full. how do i fix it?
View 7 RepliesI have a 2006 Dodge Caravan that started experiencing engine whining and some leaking. I went to my local mechanic thinking it was the water pump and told them as such. They dutifully replaced the water pump but that didn't stop the whining.
I took it back after Sandy and Athena and they now say the steering rack needed to be replaced and was leaking badly as well.
I have a 1990 Dodge Caravan complete with collector plates. I bought new bulbs to replace the burnt out map reading lights, but how to open the enclosure for the lights. There are no screws and no obvious places to pry open.
View 1 RepliesI have a 2001dodge caravan that I can't seem to get the engine temp up on. I've replaced the thermostat and the coolant temp sensor and topped off the coolant. It raised the heat to the first line but once the vehicle is being driven the temp drops to 0 and heater blows cold. During the summer the vehicle runs at normal temp. Have disconnected the ambient temp sensor which did nothing to better or worsen the problem.
View 10 RepliesMy front suspension has been making some noise for a while now, and lately has been getting worse. So I want to replace whatever the problem is, but having trouble figuring it out. Everything looks ok, and the methods I researched aren't giving any clues. The one question I Have is, should I be able to move any of the parts by hand? There are two that I can wiggle back and forth pretty easily, but I don't know if this is normal or not. One is a thin vertical piece parallel to the strut, the other is behind the wheel and low in the back (a tie rod?). Don't know the part names, have worked on my vehicles for a long time but never the suspension.
View 19 RepliesMy 96 caravan started misfiring and then it clears ..and then it misfires.. if I get on the highway it clears after a mile or so.. and stays running smooth till I stop and shut it of , thought i got water in the tank but that was 2000 Miles ago ....it's old but it's My work truck...
View 3 RepliesMy 1997 Caravan 3.0 acts as if the EGR Valve needs to be cleaned. Where is the EGR Valve?
View 3 RepliesFor about a week I started smelling gas. Checks things out and didn't see anything until today. It is the lone on top of the tank where the plastic piece (fuel pump?) connects to the hose. What is the size? The auto store has three generic replacements but said they don't know what size mine would be. Otherwise I have to take it off and bring it in and try to eyeball it. Not sure what the part is called, but is looks like some two piece clip.
View 19 RepliesI have a 1998 Dodge Caravan with just over 50,000 miles on it. This summer It started having this issue where when I turned the key, all I got was a click, and then nothing. The starter wouldn't turn over, but all other electronics seemed to be working properly. If I continued to try turning the key (2 or 3 times) eventually the starter would engage and the car would start right up. Assuming a bad connection somewhere I cleaned the battery posts, and a couple other connections I could get to, and the problem seemed to go away. About a month later the same issue started up again, and I was able to fix it the same way.
About a month and a half ago, I went to start my car, turned the key, and NO click. After turning the key a couple times the car would start as before. Then the next time I tried to start the car I again got nothing. On the third try the starter turned over, but only a few times before it died (and it sounded like it was really struggling to turn over too). The fourth time I turned the key the car started right up. This new behavior continued for about a week and then I took it into the shop.
At the shop they first started by cleaning all the connections, which did nothing. Next they put in a new starter which also didn't fix the problem. On the off chance the new starter was bad, they tried a second new starter, and again the problem continued. Finally they pulled out the wiring harness and found 3 "Bad wires" which they replaced. The then also concluded that the bad wires were causes the starter to short out, and that is why the two new starters they tried didn't work. They gave me a new starter, and that in conjunction with the new wires seemed to fix the problem.
Now, every few weeks, I'll go to turn the key, and all I'll get is a click again. The second time i turn the key, however, the car will start right up. This issue maybe happens more when its cold in the morning, but it hasn't happened enough for me to be sure. The clicking issue doesn't bother me that much because the car always starts, but I'm worried that the problem will just get worse again. Did my mechanic actually fix the problem I had? Or am I going to need to take it back in to the shop in a couple of months and put another new starter in? Also, I have had my battery tested three times throughout all of this, and it always comes back fine.