I had my rotors turned and pads replaced 2 years and approx. 11k miles ago, now I have a violent vibration when I brake. The new mechanic is saying the rotors are warped. Can this be so? I'm very easy on brakes...really. The car is an 2005 Honda Civic with 74k miles. Did I get ripped off by the last mechanic?
View 7 RepliesI have a 2009 Chevy Malibu that gives through rotors every 6 months. I have replaced them 3 times now in 102,000 miles and had them turned multiple times. What happens is about 6,000 miles after I put new rotors on they warp and I get a violent vibration when braking at high speeds. I have been to 3 different dealerships and none of them can figure out why they continue to warp.
View 12 RepliesI have an 04Honda Civic manual transmission that suddenly started making an ugly groaning sound whenever i accelerate, apply the brakes, or turn. It sounds like a metal-on-metal noise like something is loose or cracked. It even happens if I turn the steering wheel when the car is stationary. I tried to listen to where it's coming from, but all I can tell is that it's somewhere in the front suspension.
Mechanic said he didn't see anything wrong on the front suspension, but recommended replacing rear control arms.
I own a 1997 Honda Civic EX. Automatic. 160,000 miles. I have had the front disk rotors and pads replaced five (5) times within the past two years due to "warped" rotor issue. I recently changed the two front calipers as well to rule out caliper issues. Yet I continually end up with a warped right front rotor weeks after putting on new rotors. Here is what happens. Car brakes fine for a week or two with the new rotors. Then shortly afterwards, the right front rotor (passenger side) quickly develops a rubbing -like noise (not a grinding noise) when braking at a low speed. It's not a constant rubbing noise but a rhythmic swoosh swoosh swoosh noise as the tire rotates and the brake is softly applied. You can feel it in the brake pedal. This noise eventually gets louder and louder the more I use the brakes (or, the hotter they get?). It can also cause the steering wheel to vibrate at certain speeds when braking.
I have had it into four different mechanics.
Mechanic 1: Your rotor is warped.
Mechanic 2: You are too hard on your brakes causing the rotor to warp.
Mechanic 3: Did you go through a puddle of water lately?
Mechanic 4: You need new brakes. Period.
This is getting ridiculous. In all my years of driving, I have never encountered this problem. I am not hard on my brakes. I do not believe the "water puddle" theory at all. I should mention, although these are not oem rotors. they are not some cheap Chinese ones either. Something must be causing this rotor to "warp" if it's really warping at all. I have had the tires rotated to rule out a bent rim. It happens no matter what tire is on the right front car. What could be causing this? A bad front end alignment... bad wheel bearing... (although no mechanic ever indicated that as a problem)... bent splash guard... bad master cylinder? Air in the brake lines... old brake fluid???
I get a rhythmic thumping sound from my right front wheel when braking. The sound gets slower as the car slows, and when very slow sounds more like a grind than a thump. I can feel the vibration through the brake pedal. I've had this problem before, and had my wheel bearings replaced -- fixed the problem, but after about a year the sound came back. Just had the car inspected and brakes are in good shape (at least those parts checked out by the state inspection). Could it just be that I need to get the wheel assembly tightened up? (It's a '99 Honda Civic with about 145K on it, if that matters)....
View 11 RepliesWe have a 2005 honda civic hybrid; there is a squealing noise coming from front passenger side, when braking, when accelerating, decelerating, but not while driving at speeds of 30 mph, straight. Also when backing up, turning wheels. It's going to the mechanic on monday for regular maintenance, 100K miles, etc.
View 3 RepliesMy honda just celebrated its 155000 mile and low and behold it was greeted with a vibration in the steering column. It gets worse on uneven roads and pretty much goes away on smooth roads... What it might be?
View 1 RepliesJust had engine replaced by dealership due to oil plug coming out on highway and subsequent engine damage (their fault).As soon I picked it up, felt left to right vibration going from front to back during acceleration.Took it back to dealership. They balanced/rotated tires and checked alignment (they said within specs). Still feeling vibration and so did technician who rode with me.The service advisor pulls me over and said that per the "Honda Master Mechanic" they spoke to via phone, vibration is being caused by engine timing not being correct because, being it it had to be reset, the computer needs 500 miles to set it correctly. Does this sound like bull to you to? I'm thinking damaged strut when they dropped front end to install engine or motor mount.
View 3 RepliesI have a 2004 Honda Accord EX (4 cyl) with 102k miles. I bought it brand new and kept it completely in shape with regular service. For the past few months I start getting front end vibration at braking, mostly when slowing from high speeds and without any repair this vibration has now became common at all speed.... my diagnosis - I need to replace to turn disk/rotors....
While I have not remedy the rotor issue yet, I started getting this new vibration at 60 to 80 mph.... Below and above this range of speed i have no vibrations - the car will drive fine. This type of vibration in my experience for front wheel drives is mostly due to balancing or bad tires. so i took the easy way ..... and as i already needed tires well i dished out the dough and replaced all four with Michelin Primacy hoping that it will resolve the speed related vibration.... Well it did not?
I continue to drive as-is without addressing the real problem - coz I'm not sure what is causing the vibration.... now new additional vibration started on acceleration; any time I hit the gas pedal (normal acceleration or kick-down) I get vibration very similar to when a stick shift's gearbox required replacement/repair of the worn out pressure plate's (fingers/springs gets bent or weak) or the thrust bearing needs replacements/repair/grease packing. I'm from the old school stickshift transmission, my knowledge in automatic is very little - I have repaired Acura's automatic transmission before but I don't think repairing once will make me an expert in automatic.
So to summarize my issues or current state:
Issue# 1 front end vibration on braking
Issue# 2 front end vibration 60 to 80 mph speed only
Issue# 3 front end vibration on acceleration at all speed
The list above is in sequential order as I have experienced.
My 202 Honda Civic EX is having serious 'bad vibes' that the mechanic has not been able to fix. actually, i don't think he has even driven my car, much less even tried to fix the problem. meanwhile, it's driving me crazy. the mechanic just replaced the motor mounts. I got in the car and the problem is STILL there. the vibration is easy to see when the car is idling - the hood vibrates and the rear view mirror also shakes, I can feel the vibration in the driver seat and steering wheel. i can also feel the vibration in the passenger seat, though it is a little less noticeable. There is also a noise to go along with the vibration, especially when idling, it sounds as if i need a new muffler, but i can't hear the sound outside of the car, only inside the car. What the problem is?
View 5 RepliesTruck is a '99 2WD with drum rear brakes. 81K miles. I rebuilt the rear brakes due to a leaking wheel cylinder. The old shoes were not completely gone, but were worn evenly - everything looked normal.
Not a professional wrench, but I've been re-doing my own drum brakes since the '60's, so it is not rocket science to me. Still, as a precaution, I did them one side at a time so as to have reference point, and also snapped a few cellphone pics just to be safe.
Replaced both wheel cylinders, all hardware, and of course the shoes. Gravity bled the cylinders first, followed by the old tried-and-true, wife in the driver's seat, "down-and-hold, now up" routine. Adjusted shoes to just contact drums lightly, and buttoned it up.
The problem is that I'm getting a violent chattering from the rear axle with either light or normal braking. The chattering is worse as the brakes warm up - shakes the whole truck. At first I thought I had a bad rear ABS sensor, but then I did a couple of stops just using the parking brake, and got the same chattering.
Now I've pulled the drums off to re-check. There is nothing loose, nothing out of place, nothing leaking, but there was a heck of a lot of brake dust in there and the lead shoes on both sides were noticeably more worn than the trailing shoes - and I've driven maybe 100 miles since the rebuild.
You can't reverse these shoes, since the trailing shoe has a peg to hold the automatic adjuster, so that is not the issue. The drums were turned less than 1000 miles ago, so I did not have them re-done at this point.
I had my "assistant" partly depress the brake pedal while I had the drums off to confirm that the cylinders were expanding both shoes, and they are.
So my 07 with 125k miles has had new rotors for about 50k miles or so, but for a while now when the brakes get hot it gets a violent shudder on braking at highway speeds....the odd part to me is nothing at lower speeds, and not always at higher speeds....do I just have warped rotors again? The rest of the front end I good and tight....
View 9 RepliesJust had new tires mounted and balanced on my 2011 Santa Fe. I purchased Toyo Celsius tires. I purchased the tires on line and had Faulkner Hyundai in Harrisburg PA mount and balance them.
When I drove to work 2 days later, I found that the vehicle starts to vibrate above 65 mph. When I get to 80 mph (typical traffic speed on I83 in the morning), the vehicle vibrates so badly that I shake in my seat.
This shaking leads to a feeling of lack of control. I'm hoping the dealer just screwed up balancing the wheels. Faulkner Hyundai uses a road force balancing machine.
My old near bald tires (the factory original Bridgestones) had a tiny vibration around 65 that went away as speed increased. With the new tires, the faster you go, the worse the shaking gets.
My 2011 Santa Fe still has under 30,000 miles on it!
Well after another visit at a local track, I am having a wired problem with my brakes. After a couple of aggressive slow downs the car developed a violent vibration and a steering wheel shake. Also vibration during 60 mph and vibration in the brake pedal. So, i thought, I overheated and warped the rotors. But after a short drive through town. The problem disappeared completely. I thought "lucky me", but as soon as i got on to a HWY, the problem returned for about 20 miles. It got so bad that i thought my wheels would fall off. The car would be almost jumping at the touch of a brake pedal. Then it went away again, and drove fine for the next 60 mi. Just before the problem started I had Centre dif locked, on somewhat slippery surface, driving fast and braking hard, not sure if this somehow could have contributed to the problem. Could it be a stuck piston in the caliper?
View 5 RepliesIt took me a while to realize it, but my Phaeton vibrates as it rolls. My wife and friend only noticed it when I called their attention to it, but I've come to pick up on it every time I drive the car, as shortly as a few blocks away from home, from about 30 MPH and upwards.
How do I know? Well, we have two other cars, including a Touareg and a smart, and those two sure do not vibrate the way the Phaeton does! My wife and I just pick up whatever car, so I am likely to drive two or three cars on any given week. I've tried to ignore it, but to me, every time I pick up the Phaeton, it is very bothersome to me.
I've put new tires on the car, had them "force balanced", the computer scores came out great, and the alignment technician at the VW dealership said he can't feel the car vibrate while we rode together. The rims are good and straight. But it clearly does vibrate.
By the way, the front suspension shudders very un-German-like in potholes. I speculate it is related. But I am dreading taking the car to the VW dealer service technician and have him come back that the car is fine.
I have a 99 Chevy Cavalier with the 2.2L OHV engine, and I've been dealing with vibration when braking, especially at highway speeds. I just had it in for service and my mechanic replaced a warped front rotor and said that was the problem. It's better now than it was, but I'm still getting some vibration.
View 9 RepliesYesterday when I was on my way to a funeral, I noticed that whenever I braked kind of hard there would be a lot of noise and vibration on my car. The noise seemed to be coming from the front passenger side of the car and seemed to pull to the right a bit. I pulled over and took a look and everything looked fine but the sound and vibration was still there.
I drove about 10-15 minutes tops like this, parked the car, did the funeral home service, and 2 hours later while driving to the burial site (about 20 minute drive on the streets and freeway), everything felt fine. No vibration, no noise, nothing.
After the burial site I drove another 15 minutes to my parents house but this time you could hear the sound faintly and only when I braked hard. I jacked up the car and took off all the tires to take a look at the brakes/rotors and everything looked ok. I had plenty of pad left and the rotors seemed fine. With the tires on, I am able to spin the tires with my hands no problem.
This morning I drove to work and had no issues at all. No sound, no vibration, nothing. So at this point, I am stumped at what could have caused the noise and vibration earlier yesterday morning.
My 03 Passat is going in for 40k service this week. I think they're going to tell me I need new brakes and rotors (felt some pretty heavy vibration during braking in the Tennessee hills). I was thinking of changing the front brakes myself. My mechanical abilities are modest, but I've done the brakes on my 94 Ford Ranger before.
1. Is this an easy task?
2. What parts will be needed?
Noticing excessive vibration when braking after 50-60 mph speeds.
View 4 RepliesNeed to diagnose what I assume is a brake problem. On track, first lap is fine. Second lap start to get a vibration under braking. By the third lap the car is shuddering horrible under braking. Let the car cool for 5 minutes and it's back to the same pattern. Car is fine on the street - no vibration. StopTech slotted rotors and EBC Yellow pads. Rotors and pads have one track day on them and a few thousand commuting miles. My OEM rotors with the same brand pads lasted 4-5 track days and 30k miles.
View 11 RepliesMy wife has an Acura, and when braking at higher speeds, she is getting a really bad "vibration". I am assuming the rotors are warped. We had both axles (rotors/pads) done last year (about 40k ago) at Midas. After they did them, we had to take the car back about 3 times for squeaky pads, and I swear a slight vibration, but they didn't fix them. Anyway, even though they offer "lifetime pads," I refuse to go back there.
So, her pads now started squeaking again. We were dealing with the warped rotors until we had some extra money and time to take it in. At this point, I am wondering where I should take it. I have no clue if the pads are good, and I'm guessing the rotors just need to be turned since they were just put on last brake job.