Civic - Honda :: Brand New Clutch Makes Engine Sputter When Shifting Slightly Early
Nov 5, 2011
I had a new clutch put in my '94 civic a few months back during the engine rebuild. I'm anal about saving gas so I tend to shift a bit early, not enough to make the engine chug, but I might shift into 3rd gear at 17 mph. Never had a problem with it. Since the rebuild, when I do shift earlier, the car has hiccups where there is little or no power for a half to full second. The engine will sputter for a bit until I get up into normal operating range. But it's not like before, I'm shifting no earlier than I have been for the last 6 years and have never dealt with this before. The rpm's don't shoot up so I don't think it's actually slippage.
View 11 Replies
Advertisement
I have a 2002 Honda civic (manual). Lately, when I have pushed in the clutch to start it, the engine makes a bad sound. It sounds similar to the sound an automatic would make when you turn the key while it is already running.
View 3 Replies
My 2006 Honda Civic LX has 120,000 miles. About a month ago I stopped for gas, and when I got back into the car, it wouldn't start. It cranked a couple times but then after a couple tries that stopped. The power all came on as normal (lights, radio, everything with no dimming), but the engine wouldn't go all the way. I got a jump and things were fine for a couple of weeks, then it did it to me again, following a brief stop in the grocery store after my highway commute home. Again, jumped the car and went home.
After four days with no sign of trouble, it happened again at the gas station. I then took it to a mechanic who spent 2 days with it and declared my problem a mystery. He couldn't get the car to not start for him and said my battery, alternator, fuses, everything he looked at seemed fine. He thinks it could be the starter but couldn't be completely sure enough to do such expensive work. I also let it sit for two days to see if there was a battery drain, but it started up just fine after sitting for those two days. I did notice that it seems to not want to start the day or two after I use my headlights. Now, 5 days since the last episode, it's starting but the crank is a little slow. My battery is one month old. I'm at a loss and don't want to throw money at the problem without knowing. I'm tired of driving everywhere afraid to turn the car off, too.
View 12 Replies
2002 Honda Civic EX Manual ... My Honda makes this rattling noise. I noticed it only a few times on the freeway a few weeks ago, but it went away after breaking. But now it happens a lot more often, but only most of the time.
I can't figure out what the common denominator is among the times it does rattle. Any speed, any gear, any rpm, uphill, downhill, flat, a/c on or off. I just replaced the clutch (it needed it, unrelated problem) but it started just before replacing the clutch, and now is worse. Up until today, it would completely stop when I hit the breaks, or even just tapped them (though resume when I lifted my foot). Then today, that doesn't have the same effect...it takes a lot more pressure/time to make it stop. It seems to be coming from the front passenger side, but sometimes sounds like it could be coming from the passenger back.
View 3 Replies
My wife reported that her 2010 Civic LX sedan sometimes made a noise in the front, like cutting sheet metal with an electric saw. I have not heard it myself during several times I drove it. What could be the possible causes?
I plan to drive it some more until I hear the noise. What specific info should I note for mechanic to diagnose the problem correctly?
View 5 Replies
My cousin has a 2011 honda civic ex A/T and when he lets off the gas his transmission makes a quick knock noise. It's not too loud but it's very noticeable. Shifts fine and everything. Also it sounds like he is forcing his transmission from park to reverse. We hear a lot of noises not so much grinding noises but a lot of movement I guess you could say. But it engages quick. Is this normal or should we take it in? I have had multiple people tell me it's all normal. But it doesn't sound normal to me.
View 4 Replies
A couple of years ago I went through the salt water with my 2003 Honda Accord which is a manual transmission. It only has 106,000 miles and expects it to go much further. The clutch works great but when engaged is really loud. I have had it checked by 2 different auto repair places. Nothing is wrong they say. It has been cleaned and greased.
View 19 Replies
My 98 Civic ex runs and shifts perfect to have 200,000+ miles but when you try and shift to reverse it grinds. It acts like it's gonna shift into reverse but doesn't. When you shift back into park or neutral you can hear it still spinning. Sounds like a card in spoke of bike. We have drained fluid twice and replaced also added trans-x.
View 4 Replies
I own a manual 1992 Honda Civic VX. Recently, the clutch has started to stick about halfway up when I take my foot off after shifting sometimes. I pull it up with my foot when it does this, but clearly it shouldn't be happening. What could be causing this?
View 3 Replies
I have a 95 Honda civic with a d15b block and a d16z6 head millage unknown I put a new clutch in it already had a new slave and master I installed a few weeks ago and when the car is running with out the clutch pressed in I can run through all the gears shift with ease it's like the clutch is pressed in but it's not
I've tried dropping the tranny and checking the pressure plate the clutch disc throw out bearing pilot bearing all good and installed right I rebleed the system then I removed the slave to see if it was in the hydroelectric system and still no change what am I missing.
View 19 Replies
We have a 99 Honda Civic. Our clutch is sticking in all gears and won't go into 5th gear at all. There is no resistance when I push down on the clutch pedal.
View 8 Replies
I have a 2001 Civic LX; I would like the clutch pedal travel distance to be far less than it is.
As in most manual cars, I find that the clutch pedal travel is mostly useless. That is, once the clutch is fully engaged, the pedal still has a goodly way to go before it hits the stop. On pedal depression the inverse is true. As modern hydraulic clutches are self-adjusting, this once-necessary extra distance is pointless.
(I would rather clutch with my ankle than my whole leg. If I could cut the pedal travel in half (or more), I would like that very much.) Is this possible? How would I do such a thing?
View 5 Replies
Ok my car is not starting. It is not turning over when you turn the key and push in the clutch. I can here a relay click under the drivers side dash. I can push start it and it runs great, sometimes it will start and run fine but it is a frequent problem now. What could be causing me these problems. 1991 Honda Civic DX ....
View 10 Replies
Car is a 97 civic. I had a input shaft bearing replaced since i had the tranny off. I decided to change the flywheel clutch and bearings. After install I have cold not shift into gears with engine running. I fixed the problem by removing almost all of the free play in the pedal. Should i replace the master to get some of the free play back in the pedal?
Second and main problem, when i release the clutch pedal there is a ratchet/grinding noise. It changes with engine revving and the further out the pedal the louder the noise. I think i attached a noise clip. I have dropped my transmission to ensure everything is installed correctly. reinstalled the tranny with the same noise. Bleeding the clutch did not work either. Pedal does seems soft but not getting stuck.
New parts:
Flywheel
Pilot bearing
Clutch disc
Pressure plate throwout bearing
Transmission Synchs
Bearing kit
View 6 Replies
Now with the new clutch installed, it makes a terrible noise with my foot off of the clutch in neutral. I can't get into any gears; it'll just grind gears.
Here is a video of the noise. Again the noise only occurs with my foot off of the clutch pedal. Quiet with my foot on the clutch. I can't get into any gears.
1996 Honda Civic
View 19 Replies
I have a manual 98 civic with 120k miles on it that has recently developed an annoying habit of stalling. The car started fine the other morning so I backed it into the driveway to warm up, no problems there. When I went to leave for work, the car stalled and died. I got it restarted but when I tried to drive it stalled again. It happened as soon as I disengage the clutch. As I said, moving in reverse was no problem. The battery died after I attempted several times to restart it so I charged the battery overnight.
The next morning the car fired up right away with no hesitation nut as soon as I released the clutch it started sputtering so I gunned the engine to keep the RPM's up. I managed to get it into 2nd and even 3rd but as soon as I down shifted for a stop sign it died. So far I've replaced the battery and the alternator, both were on their way out anyways. Then this past weekend I got a good deal on a new fuel pressure regulator and put that on. The car started right up and ran nice and smooth. I took it out for a drive for about a half hour.
About 20 minutes into the drive I noticed that when I pressed on the gas pedal, the RPMs wouldn't move up much higher. Shortly thereafter the car started sputtering while accelerating. When I got home I turned the car off and went inside. I came out about 15 minutes later and the car wouldn't start. This has happened after every part replacement. New alternator, runs fine for 20-30 minutes,then won't start again. New battery, same thing. And tonight the gas pressure regulator. Could it be the main fuel relay, should I pull the injectors? The plugs and wires are new and the distributor is less than 2 years old and well sealed. I'm at a real loss here.
View 7 Replies
,My wife drives a 96 Civic DX Hatchback, 5 Speed. It has about 160,000 miles on it, and she only drives it to work and back (a 15 minute drive via the interstate).
Just yesterday, she told me that the clutch feels 'looser' than normal, for lack of a better term. When it's first started, it's hard for her to get it into first and/or reverse, but once driving, she says the shifting is fine. When she's driving at highway speeds in 5th for a while, then has to get off at her exit, she said it's hard for her to get it back into 1st gear. She says she feels like she has to push the clutch harder than normal to get it back into 1st gear.
I don't know much about manual transmissions, and am hoping for some insight into what the problem(s) may be?
View 11 Replies
Replaced clutch master cylinder last week. Now when I accelerate it revs the RPM's and finally catches after about 5-10 seconds. Is this related to the previous repair? They are saying needing new clutch. What to do?
View 3 Replies
I started having a strange clicking sound when pushing down the clutch pedal. I have 43,000 miles on it and I have driven the clutch well(I really don't believe I already worn it up). It goes away and then it comes back. There is no problem on shifting from gear to gear, it works just fine. It is only when I push the pedal that it starts clicking like it pushing against something. The car dealership was so useless, they said I need a new clutch and that warranty does not cover it because I may have been using the clutch badly. Also do you think that they have the right to tell me it is my fault even though I have the extended warranty for 100, 000 miles.
View 6 Replies
Had my original clutch replaced by mechanic. Had 200K on it. Car clutch petal vibrates badly when bringing clutch pedal out after shifting. Mechanic states it has to do with motor mounts that were affected when changing clutch or the clutch takes time to seal and stop vibrating in the next 500 miles. I have warranty for 12 months and 12,000 miles. Which I had no problem of vibration before having clutch replaced? What is the problem and how to proceed.
View 3 Replies
My 2000 Civic DX has approx. 55K miles on it. For the past several weeks, the Automatic transmission gear is resisting/sticking about half the time when shifting from Drive to Park and vice versa. (In November 2010 I had a local mechanic-- whom I found on Yelp and who has done other work including replacing the timing belt--replace the ATF, telling him he had to use Honda fluid). What is causing the sticking?
View 3 Replies
