Civic - Honda :: 2005 - Replaced Entire Cooling System Still Overheating
Aug 5, 2013
I have a 2005 honda civic. About a month ago it started overheating. Drives Ok on the highway but heats up to the H mark almost as soon as I get off the highway. Have replaced the water pump, thermostat, radiator, flushed the system, most hoses, fan, 2 sensors, timing belt, spark plugs and had the head gasket checked 3 times by 2 different shops. Both said it was fine. The mechanic that has done most of the work is baffled. Says he has never seen anything like this and is at a loss as to what to do next. I am supposed to drive this car halfway across the country in a week to meet my husband who is in the air force. Should I just sell this piece of junk!?
View 10 Replies
Advertisement
My 2005 Civic is overheating at random times. My mechanic couldn't find the problem so I took it to the dealer and they replaced the thermostat and a fan switch. That didn't work so now they tell me I have a blown head gasket ($1,458)... but there's no water in the oil and no gray smoke. They say the coolant leaks into the block until there's not enough circulating and it overheats. Then, when it cools, the coolant goes back into the reservoir and that's why it never seems to be low on coolant. I've seen other Civic overheating letters (including a 2005 that sounded like my exact problem) but I never saw an update about what fixed the problem.
View 12 Replies
I replaced the pads and rotors on my 05 Civic 3000 miles ago. Now it is pulsing badly again when stepping on the brakes. I can feel the pulse in the brake pedal and the steering wheel. What should I be looking for when I pull off the wheels again.
View 8 Replies
This video is about the Toyota Prius Gen 3 Temperature Indicators and cooling system overheating. I thought the prius did not have temperature indicators but found out it did, so this video is about how to know if your toyota prius is overheating and understand the basics of its cooling system.
View 2 Replies
I have a 1998 isuzu trooper. it is over heating and there is air being put into the cooling system. there is a lost of fluid but only the same amount each each time and i dnt knw where too. i replaced water pump had radiator serviced and it flowing at the right flow for truck. it still over heated. i tried chemical called blue devil it worked for two days then failed it is freezing cold here and no garage but do have all tools.
View 9 Replies
Alrighty. I have replaced everything dealing with my coolant. New water pump, mishi radiator, pusher fans, thermal switch, temp sensor, t stat, t stat housing coolant pipes, also new gasket and o rings. All new coolant pentofrost sf. Today I went to bleed the cooling system and waited til it did not suck any more coolant down, and we're no signs of air bubbles. Today when I drove it a to Walmart it began to over eat quickly. I pulled over and looked ubder the hood. Coolant was dripping out of my 19-21 pounds moroso cap. And my coolant hoses were rock hard.
Although my top radiator hose was very hot and my bottom was not, but closer to the motor it was. Like if there was a blockage but there isn't in the hose that goes to the block on the bottom of my radiator. Even with the air flow and my fans manually turned on when I first started the car it was steal overheating. On my vehicle there is not a reservoir it has been deleted. I have just my hoses and my radiator that's it. I don't know what can be causing this to happen. Also I ran an air pressure test and my head gasket is not leaking. Any clue what could be going on????
View 4 Replies
2003 F-150 Supercrew w/4.6 V-8, 2-wheel drive, 219,000 miles and very well maintained. I'm getting an intermittent overheat condition that I can't figure out. Coolant level is good and I just replaced the thermostat. My OBDII app showed it running at a constant 207 degrees (195 thermostat) after the thermostat. Appears to have good pressure at the cap. It ran great for 30 minutes at idle and then did fine for a five mile test drive.
The next day in the morning it overheated within 3 miles of the house (heat was on) and you could smell it. Pulled over and let it sit for 20 minutes and started back up and it stayed constant at 207 all the way to work (11 miles). It sat at work for about 7 hours and ran great all the way home (without heat, with heat, with air cond). Then this morning it did it again, overheating about 3 miles from home. This time I pulled over and shut it off for about three minutes. Turned the key on without starting and the temp was already dropping again. So I started it up and it continued to drop down so I drove to work with no more issues. This afternoon again went home and it never overheated.
I'm expecting it to overheat again in the morning. I'm gonna go live on the OBDII for temps during the drive tomorrow.
View 2 Replies
I borrowed a friends 2000 Excursion with the Triton V10, along with his 3300lb, 28' trailer to tow a car from Ashland, OR to Reno, NV to begin a restoration project. His Excursion has 175,000 miles on it and made the trip down flawlessly, but as they say, "No good deed goes unpunished." When attempting to return last Sunday, had to turn around due to overheating problems. Analysis at a local automotive shop concluded a bad radiator cap. Attempted the return trip Tuesday and the same thing happened (only got farther due to the new cap and ability to hold pressure longer).
Finally got into a Ford dealer and have been informed that the truck has a bad head gasket causing pressure to leak into the cooling system. They suggest replacement of with a remanufactureded engine as opposed to replacing head gaskets, due to the time on the entire engine (who knows what else might be bad?). The vehicle can be driven around town for miles with no problems. But put that heavy load on it and grades and it spews out nearly "all" of the coolant.
View 9 Replies
I have a 2010 IV Prius that has been having the following issues starting up / turning off:
On February 4th in the evening: car wouldn't start. Started on 5th try - showed "HYBRID SYSTEM OVERHEAT."
On February 15th in the evening: car wouldn't start. During multiple attempts to start hybrid screen to the right of speedometer flickered / went in and out and was faint. Started on 5-6th try.
On February 16th in the afternoon: car wouldn't start. Hybrid screen to the right of speedometer flickered and went in and out during startup attempts. Eventually car started at 5-6th try - but display to the right of speedometer did not come on at all. Car felt like it was running on engine only.
Took car to Toyota dealership. They had it for 2 weeks and could not figure out what the issue was. Car did not show any error codes. Said they did not experience issues either. Gave me the car back.
On March 3rd, as soon as I got the car back and while still in the dealership parking lot, I pressed the start button with my foot on the brake and only the AC / radio came on. Called over service advisor and when he came tried it the car started up fine.
View 10 Replies
Original owner of a 2005 Excursion 6.8l v10, 155k miles. About a month ago 10-15 minutes or so into my ride to work on a 50-60 degree morning the check gauges light comes on, noticed the temp gauge pegged to H followed by the check engine light, then limp mode. Turned on front & rear heaters and cold air was blowing. Pulled over, checked under the hood, coolant wasn't boiling, tank was 1/2 full and cold air was blowing thru radiator. 1st thought was T'Stat. So I removed T'Stat added some antifreeze & continued to work w/o a t'stat. Then had heat thru radiator & heat in front & rear heaters. Engine ran cool with no overheat issue.
Bought aftermarker T'Stat (slant) put that in and everything back to normal. About a month later same problem happens at about the same point in my trip to work, temp pegs, no heat from heater and goes into limp mode. Shut the truck off release pressure from radiator and coolant level goes down, seems to feed back into engine. Start the truck up temp goes back to normal and everything is fine for the rest of the day with several starts/stops. Bought FORD OEM T'Stat & replaced. Next morning same problem. So i think maybe there's an air pocket somewhere, add more coolant & fill to proper level when cold. next morning from cold start same problem. Coolant is clean, just changed oil and no coolant in oil. Problem only happens from a cold startup in the morning.
I'm at a loss. I'm thinking of drilling a small bypass hole in the T'Stat.
View 9 Replies
My daughter's 2002 Honda Civic is overheating unless you drive over 60 mph. The heater is also not working - it blows air but the air is cold. It is full of coolant - we checked. The thermostat was replaced about 2 months ago.
View 4 Replies
I have been driving my 2002 Honda Civic for about 6 years now. For the past 4 years its been all highway, driving 50+miles a day. I have just moved to a small town where its all town driving.
When I would get off the highway before, I would notice a burning type smell, but no smoke and no signs of overheating. Once I moved here where the winter has been significantly colder than what my car is used to, and I am doing all in town driving, I have noticed smoke coming from my engine, but my temperature gauge shows all is well. I have always done regular oil changes etc on the car. I will be making a long trip this summer back home and i am not sure if I should be worried about the car overheating. Should I try and find someone to investigate this problem further or is this just some engine gunk burning as the car gets hot?
View 3 Replies
I have a manual 2000 Honda civic that is acting up. When I drive it after about 15mins it gets really hot. Then right before I pull over it starts to cool off if I have the heat pumping . It also seem to over heat when ever I am sitting idle . I replaced the radiator and thermostat but I'm still having the problem.
View 7 Replies
I have a 2004 Honda Civic Lx and I was driving one day and I look down to see if I was speeding or not (easy to do) and I see that the thermostat is almost all the way to the red line. So I pull over to a store and check my fluids. The oil was low so I put two quarts in. There are no signs of leaks anywhere. I also topped off the coolant. Ever sense the care has been fine so could of it been the low fluids?
View 5 Replies
Can this make sense, or is this just some weird coincidence?
View 2 Replies
'04 Honda Civic-1.7LFirst the car started overheating only it was sitting in idle. As soon as you would go or if you revved the engine the needle would immediately drop after a few seconds. Replaced the thermostat. It seemed fixed, but started doing it again, put in a new thermostat incase other one was faulty. Still having same problem.The system was pressure testing and everything was fine. Then had the system flushed and new thermostat put in. It worked for about 150 miles and started doing the same thing.Brought it in for the water pump, the old one was corroded and warped so it seemed like the problem.
After about 100 or so miles still overheating when idle.We had the radiator replaced, the old one was complete junk, thermostat replaced too. I drove it like normal in town for a day, the next day it started overheating, this time it was doing it while driving, got to about 3/4 up. Turned the car off for a bit, and it didn't do it anymore on the way home.Today I was driving and it was fine for 4 miles, I sat idling for 1 minute, after driving 1 more mile it started overheating, temp gauge got to halfway.
I parked it for a bit and started driving, there was no heat coming from the heater, I had it full blast, nothing but cold air. The car started overheating again, once again halfway. Parked for about 3 minutes and then turned it on, temp was fine and it was blowing full heat out, the car temp was fine the whole way home, no more overheating.
The next step we will take is to replace the head gasket and/or heater core. Is there anything else that this could be? Literally the same week the overheating started, the rear lights were having issues and one time there was no power to the windows. Then the door locks would stop and then work again intermittently. The door locks no longer work at all. Not sure if it is just a coincidence, maybe everything is breaking at once. But there has been no loss of coolant and the oil and coolant consistency have been normal too.
View 19 Replies
I have a 2004 Honda Civic. I just drove the car to Texas this weekend, 1800+ miles. On the way home it started to overheat if I was going slow, 45MPH or less. I pulled over, shut it off for about 2 minutes, started it up, the guage read about normal. I drove for a little while and it worked fine. Awhile later it started doing it again. I turned off the A/c and let the engine build up temp. At about the normal reading, both the fans on the radiator started cycling (I think one is the A/c cooling fan, and the other is the radiator cooling fan). So, both fans are at least working. I checked the fuses, they all looked good, and the fan relay worked as well ( I switched it with the horn relay, and they both seemed to work the same). What should I check next? Does it sound like a thermostat issue, or a temp sensor, or the fan switch? And how could I troubleshoot this further?
View 10 Replies
I have a problem with my 2005 gti 1.8t , I had a issue with my cooling flange leaking, I changed it yesterday refiled it with g12 and distilled water took the car for a test drive about 20 min in see the temperature go up, no steam or water leaking any where, turn on the heat notice no hot air from the vents,turn on the ac no cold air, and the fans are not turning on. Everything worked the day before I did the coolant flange, am thinking is this possible because the coolant temperature sensor broke? fans will not turn on at all even if it overheating. If I leave the radiator cap off the coolant is spiting out of the overflow expansion tank don't know where to start looking for some pointers. Would bad thermostat cause the fans not to turn on?I think is impossible that the fans and the thermostat broke at the same time with the fact that everything worked the day before..
View 9 Replies
2005 Dodge Neon SXT 206XXX
Long story short on a trip (about a 1 hr. drive) got about a block away from destination and gauge showed it was over heating. Stopped the car started up after five min. just fine. Got home replaced the thermostat and cap (old cap was junk). New cap was junk aftermarket so yesterday I took the same car on a half hour drive to get a Mopar cap ran just fine up again until a block away, pulled off the road turned it off let it set a few min. then didn't even show it was over heating. Let the pressure off and replaced the cap and added in a bit more coolant ran fine all the way back (even pushed speed in a few spots).
The above is just what seems to be the mechanical side of the issue. After noticing the gauge was going a bit above the normal spot I noticed my cooling fans are not coming on. Checked fuse and tested relays out to be fine. First thought is to check voltage to the fans but also tempted to check coolant temp sensor with bench test. Will be going over to my dads to do voltage testing later today.
View 4 Replies
This has been happening intermittently for a little over a year now. When sitting in traffic, my car begins to overheat. I've had two different mechanics look at it - the first swapped out the radiator cap.
The second said my coolant levels were low, but he pressure tested the system and found no leaks. He recommended I check my levels before taking long trips - so this weekend, before driving 380 miles to Phoenix, I checked my levels. They were a bit low, so I topped everything off with coolant and everything was fine on the drive out.
On the drive home, however, stuck in traffic, the car began to overheat. I pulled over and checked the reservoir and it was mostly full of coolant, but I added a little more, let it sit for a while, and then made my way through the traffic and home.
Also, I tested the fan, and it comes on.
View 16 Replies
I have a 2004 Honda Civic ex coupe. I have changed the thermostat (twice), fan sensor, temp. sensor. The fan works and when doing an oil change the oil looks normal. No white smoke coming out of my exhaust and I got two radiator flushes, no dirty coolant, and I have replaced the cabin filter. The car doesn't overheat as long as I keep my temperature on hot. If I were to change the temp. to cold it seems like the coolant goes into the reservoir, but it seems like it doesn't go back into the engine. The mechanic that did the flush said that the hoses doesn't to be clogged because the coolant that was removed was green. They stuck an air blower in the heater core hoses and to show that was not clogged as well. The AC worked, I haven't checked in about couple of months. Also when the car overheats there is no smoke coming from the engine. radiator has been burped as well.
View 14 Replies
