Volvo :: What Causes 1991 Turbo 740 To Run / Not Start / Run Again
Aug 25, 2012
I recently purchased a 1991 Volvo Turbo 740 with 186,000 miles on it. It runs perfect for a few days and then when parked will not start. Attempt to start 1/2 hour later it starts and runs perfect again. It has done that for several days now. I have driven it to locations approximately 40 miles round trip with frequent stops for a period of time and then start up again. This AM it started up perfect as I moved it from a driveway to part in front of my house on the street. Several hours later I went to start it but it would not start. 1/2 hour later I decided to try one more time before calling the tow truck to take to a mechanics and it started up perfect again. I drove it to the library and bank later and ran perfect after the two stops. This is driving me nuts since I had taken it to a mechanic when it did this Monday and it ran great at the mechanics and he could not determine what was wrong. He told me WHEN it stops again to have it towed in and he could determine at that time when it was not running.
View 7 Replies
Advertisement
I am acquiring a 1991 Volvo 740 Turbo and am concerned about the need to change the timing belt. The seller does not have record of it being changed since he had the car for two years. He had only put about 10,000 miles on it since he had acquired it. It now has 186,000 miles and runs perfect and basically in good shape for its age. If the belt breaks does it ruin the engine?
View 2 Replies
My 1994 850 turbo will crank but will not start. it started when the car was having trouble accelerating past 40 mph and felt like it was kicking back then it died on the freeway and now will not start. i ran the error codes and got these back, from A2 452, 455, 543, 544, 545, 552, 555 and from A7 122. I'm not sure what to do?
View 4 Replies
So, first, I need to tell that my car was just turned away from the only mechanic that is a "volvo mechanic" in the region because he said it grumbled and shook too much and it was too much of a liability.
There is only one thing I am concerned about, because it has been grumbling and shaking since I bought it five years ago and it hasn't gotten worse (so why worry!)
This car is a 1991 Volvo 740 sedan with 250,000 miles, a 4-cylinder gas engine and rear-wheel drive.
I have a siren sound coming from the front end, but only sometimes.
When I first start moving forward, I hear a "whooooooooOOOOOOOOOOOPPPPP!!!!" (sounds like a siren) for about 50-75 feet while I am going about 25-30 MPH. It only happens when I first start rolling forward when I first turn the car on from sitting for a while (3 or more hours). If I come to a stop, I don't hear it. If I park and run in somewhere and come back soon, I don't hear it.
I have been hearing a small "whoosh whoosh whoosh" sound coming from the front end that gets faster the faster I am traveling, and I don't know if that is related.
View 5 Replies
This 1996 (220KM) car will run fine (perfect)for about ten minutes from cold (I'm talking -5 C)then starts to misfire when warmed up. Difficult to pull away (automatic) from a stop. Sound like its missing on two cylinders. Really chunters.
Installed new plugs, wires, cap, rotor, coil,filter. Don't know what to check next. Car will work at speed but I can feel it missing. Gun it and it will go. Doesn't appear to be a fuel problem.
View 8 Replies
I recently bought this car in its current no start condition after sitting 3 years. Initially I jumped it off and it just cranked, no attempt to start and no noise from either fuel pump.
I checked the fuses and the fuel pump relay behind/under the radio and it clicked and was dated 2006 so it had been replaced. I assumed it was replaced when the under car fuel pump was replaced at it was a replacement.
I sprayed a little starting fluid and it fired right up and ran until used up.
I ordered both pumps and strainer and installed the under car pump earlier this week. The in tank pump and strainer looked horrible and original. There was a small issue with the return line on the in tank fuel pump sending unit when I removed it that required brazing which I got back from the shop today.
This afternoon I installed the in tank pump & strainer on the sending unit and installed all that stuff. I spliced in a quick disconnect in the wiring harness for easy separation/installation next time.
Jumped the car again [yeah needs a battery] after everything was hooked back up and no in tank pump heard with key on to prime several times and no start although I hear the under car pump quit after attempting to start and they turned off.
Is there any other fuse/relay to check? If the under car fuel pump is evidently working, wouldn't it pull fuel without the in tank pump coming on? There's about 3 gallons in the tank. I'm going to test if there's current to the in tank pump tomorrow.
View 8 Replies
What are the correct timing marks and positions for a Volvo 940 Turbo? I especially need the position of the crankshaft pulley. I have read the timing mark is on the cover, but unfortunately mine has dry rotted and crumbled away.
View 1 Replies
I have a 1991 Volvo 240 Base with an Automatic Transmission. Just yesterday, I was hopping onto the highway, when all of a sudden, my car would not go any faster than 40 to 45 MPH. It has been running fine up to that point. I ended up just taking side streets, where it ran fine. I have not taken it on the highway after that.
View 4 Replies
Starts great, idles great, tested everything. Will not rev past 1500rpm.
View 11 Replies
I was driving my 91 Volvo 940 Turbo Wagon yesterday morning when, out of the blue, the warning lights came on and the engine shut down. I was still able to utilize the wipers and radio as I sat there for an hour waiting for a tow, but whenever I attempted to start the engine, I got a few rumbles but the engine would not turn over. All belts seem to be in place. I just had the water pump replaced. I replaced the alternator 2 years ago when I first bought the car and installed a new battery about 1 year ago.
Any thoughts on what could be the root problem here?
View 4 Replies
1991 940 SE Turbo ... I am trying to figure out why there is no power to the 10 amp fuel pump fuse. Drove the car all day with no issues at all.. The next morning it just wont start. Found it wasn't getting fuel..I have replaced the tank pump thinking a shorted pump would disable the system, I have replaced the in tank Fuel Pump, Nothing. The fuel pump relay, Nothing, and pulled the under car fuel pump and checked it and its fine. I don't get it?? what could it be? I went to the library to get a copy of the wiring diagram, but the Chilton's Mechanic wiring bible was so smudged I could not even read it..
View 1 Replies
94 850 turbo will randomly smoke like crazy at which time it fills the car with smoke completely fogs whatever street you're on.
View 1 Replies
It starts and idles fine and drives fine until the turbo spools and gets past atmospheric.. at this point the acceleration gets worse even though you can clearly hear the turbo blowing (gauge well into the yellow).. checked the ground connections on the head and intake, seemed good, replaced tps, replaced knock sensor, replaced hall sensor, tried another ecu, checked cam timing. Had a volvo mechanic friend looking at it prior to my fiddling with it and he seemed to think the ignition timing was retarded too much.. but I've done everything i can think of to tackle that problem.
View 3 Replies
760 turbo intercooler 2.3 4-speed auto. It will not idle properly but when you run it around town it is fine, smooth and powerful. If you take it out on the motorway it will be ok for speeds up to 55 (lumpy going uphill) if you push it over 70 it is ok, but between 55 and 70 it is rough and sort of misses without backfiring. Also a cloud of black smoke comes out of the exhaust. If you kick it down to 3rd it will go like a rocket and not miss at all!! It has been seen by the RAC and been in the garage and they say everything is working, but can't check the air flowmeter as it would cost too much to buy one and it works fine.
View 3 Replies
I have a problem with my 1988 740 Turbo. It starts and runs fine, but when cold it experiences a drop every few seconds when idling. In other words, when idling cold, it will act as though the key was turned off but just before stopping completely it catches and continues to run.
I guess I'm trying to describe something other than rough running, or a poor idle - this is more like an ignition short where the engine completely stops (but never does). The tach needle shows this also. It continues doing this while accelerating around the neighborhood but once the car is at operating temp it smooths out. I live in San Diego so it never gets cold here.
The car was tuned up last year and the distributor was replaced at the same time. New cap, wires, plugs. Car has close to 290K and still runs great except for this issue.
View 2 Replies
My 1999 Volvo has been diagnosed by a Volvo dealer to have a bad "cooling fan relay". Another shop analysis states the "cooling motor fan assembly module" is the problem. Are these one in the same? Can I replace it with one from the salvage yard? Are there any bad omens with messing up other electronic components If I make the repair myself?
View 9 Replies
1991 740 Turbo
200k
all stock
Now days I hear exhaust gas leak from inside engine room when the motor is fully warmed up and ran for some time. The other day I put seafoam treatment in the car and I saw white smoke coming from the turbo charger area.
Is exhaust gas leak from the turbo charger common? What are the possible cause for this?
View 6 Replies
1991 740 Wagon 2.3 I4 with turbocharger and an intercooler.
My rear taillamp brake lights do not come on.
Of the 4 red lights on both taillamp cluster, only bottom two red lights stay on when I turn on the head lights. When I step on brake pedal with both headlights on or off, all 4 read lights do not come on.
I only get the middle small red light on. (which probably means the brake light switch on the pedal is fine.) I do have the lamp malfunction warning on when I turn on the headlamp or signal lights on.
I changed the lamp malfunction relay (big red cylinder) but things are the same. Found the bottom right red light had one of its filament broken so replaced the bulb but things are still the same.
View 3 Replies
My '91 240 races when turned on when motor cold, colder it is the moreso, especially in Park and Neutral till it calms down It's happening under 60 degrees Fahrenheit and big time under 32. Sometimes turning steering wheel sharply will stop this. Is this ECU? Transmission? Belts? There seems too show excess transmission fluid on the dipstick, by the way lately, which may have been that way from accidental overfill and may not be related t this insane racing issue.)
View 1 Replies
My 1991 Volvo 240 with automatic transmission suddenly stopped shifting out of first. No warning. Fluid level is good.
View 4 Replies
The past summer my 1994 Volvo 940 non-turbo over heated and we worked on the coolant system and got it working god again. However just after we fixed it the headlights blew out and we replaced them and then they blew out again. The battery was also going dead when the car was turned off and all electric things were turned off. Now the head lights don't blow but once they are turned on with the switch in the car they cant be turned off unless the battery is disconnected.
Also as of now none of the dash board instruments are working. With the car on and the lights turned on we pulled the connector to the switch that turns on the lights, that is on the dashboard, and the lights still stayed on. We can only think that some water may be causing the problem but it may or may not. I need to know how to fix the headlight problem and the instrument panel.
View 6 Replies
