My 1999 Volvo V70 is having intermittent issues starting/stalling out. Sometimes it will start right up and go, other times, it will start and the rpms will fluctuate then it stalls/shuts off or will go in gear but fluctuate rpms erratically it will do this multiple times after 3 or more restarts it will run fine until it is turned off then the same thing all over again.
View 2 RepliesWe have a problem with our 1992 240 wagon. When it rains the car starts first thing in the morning but then stalls after driving 2 miles. After letting it sit for a few min. and cranking the engine it starts and will run. If we let the car run for 10 min. before driving everything is good for the day unless the car is parked for a period of time. Then it start and we need let it idle before driving. We have had the Mass air flow sensor replaced twice and that solves the problem for a few months.
This past week the car has started to stall on a damp morning even with the sun shining. Then later in the day it runs rough at a stop or stalls.
We just brought a 2000 S70 Volvo 5 cyl. sadan. There is a problem when we start it up. Initially it starts up fine, but when you put it into drive, the rpms do not stay constant enough to keep the engine from stalling out. When you restart it, the problem repeats and repeats about five or six times, until the problem corrects itself. If in an effort to increase the rmps by applying the gas pedal, the problem may cease, but not always. Once the rpms remain constant, there are no longer any problems with the engine.
This problem is not a constant. It mostly happens when the engine is cold, but it can also happen when the car has been running and then turned off. When you turn on the warmed up engine, the problem happens again. Because we anticipate the repairs on a Volvo are likely to be expensive, we would like to have an idea of what could cause this problem and an anticipated cost.
I'm struggling with an intermittent (of course) issue where, esp. if cold, I can't start my car unless I give it lots of gas. If I take my foot off the gas at all, it will stall, which means I drive this automatic two-footed (one foot on brake, one on gas) , giving it lots of gas at all times, including when stopped. After about 10 minutes it is fine, and is then good for the rest of the day. My trusted Volvo-spscific repair shop has tried replacing booster pressure sensor, fuel pressure regulator (both indicated by engine codes) and new plugs. The end result is I've got $500 into the car that does seem to run better when it starts, but the original issue is unsolved. I was thinking something is sticking with a cold start, or idle speed is incorrect, but can't figure it out. Seems like it should be an easy fix.
View 2 RepliesIncreasingly, my s70 won't start. Turn key and nothing When this first occurred this spring I had it towed to my mechanic. He found that a starter cable was starting to detach. He re attached and started all summer with a few exceptions. Now this fall it is not starting every couple of days. Turn key and nothing. Have if towed to the mechanic and it starts fine. So should I have the starter replaced?
View 4 RepliesI have a 99 Volvo V70. Sometimes when I start it, it turns over and then dies right away. It may do it once, or it may do it several times, but it will start start eventually. I am bringing it in to the garage next week, but they don't seem to think they will be able to fix it unless it happens while the car is in the garage. Since it doesn't happen every day, I'm worried that they won't be able to fix the problem. If so, why did your car die right after starting?
View 5 Replies1999 Volvo XC AWD. There is a vibration beginning around 65 mph and continuing on up. Most pronounced at about 70 mph. It feels like when running over the little bumps in the highway designed to let you know you are straying too far off the road, but not as strong. Also no accompanying sound. I have take it to my favorite garage and they diagnosed it as an inner front CV joint. I replaced that as well as left/right control arms (they were worn) and replaced the drive shaft (also needed). The vibration continues and we are all stymied at this point. I also tried switching tires from this car with another Volvo. That did not work, so I have ruled out a bad tire/rim.
View 4 RepliesWe've had two problems within the last week with our 2002 Sport Trac (4.0l SOHC engine w/167,xxx miles). They may be unrelated, but I suspect there's good change they are. Both incidents happened while my 16 yo daughter was driving, so there's only very limited info on what happens. Both times, when I get there, it starts and runs fine. There is no CEL.
The first time it apparently stalled as she neared her destination after driving only about 2-3 miles at 35 mph or less after a cold start. She was slowing to pull into a parking lot and reported the dash lit up with warning lights, no power steering assist and no power brakes and no power from the engine. When I arrived it started and ran normally. She had fulled up the day before after two days of heavy rain, so I suspected water in the gas. I drove it more than 200 miles within the next 24 hours under a variety of conditions and filled up at a different station. I experienced no problem what-so-ever, and didn't bother adding any dry gas.
Then 5 days later (still on my fill-up) when she tried starting it after sitting all day, she reported the engine started but ran rough before stalling and never idled normally.
Doesn't the fact there's no CEL eliminate a lot of the upstream part of the control system......like sensors and actuators? This leaves things like the downstream parts of the fuel and ignition systems. I.e. from the fuel tank / pump to the injectors and the downstream parts of the ignition system.
What are the possible culprits? Fuel pump, fuel pressure regulator, injectors, ignition module, spark plugs, and....... what else? (I'm not that familiar with what these engines have) And of the possibilities, what are the most likely causes.
I have a 2001 F350 V10 Crew Cab that has 51000 miles on it so it doesn't get driven all that much, but I do start it at least once a week and it has always started on the first crank.
A couple weeks ago I drove over a friends, I backed up her driveway, turned the truck off and went inside. After returning I went to start the truck and it wouldn't start, just cranked. Probably had between 1/4 and 1/2 full.
I let it coast down to the level and it still wouldn't start. Finally had it towed home. When I got home I tried it and it started right up. Next day it just cranked and wouldn't start. The day after it started right up, I ran it for 20 minutes, turned it off, tried to start it and it just cranked....
Then I started looking at forum's for a possible answer.
I already had an IAC that I bought a few months ago since it was idling a little rough that I installed. Still started intermittently.
When I listen closely when I hear the fuel pump run when I turn the key it starts right up, when I can't hear the pump it won't start.
I have tried moving the relays around that are in the fuse panel on the drivers side hood, moving the fuel pump one to the blower motor and vice versa. Still starts intermittently and only when I hear the pump run.
I looked for the FPDM that in some trucks is up by the spare tire but apparently my truck doesn't have one, or at least in that location..
My next thought is that it must be a bad pump...Can a bad fuel pump act like this, sometimes work and sometimes not?
Have swapped the following parts from my 92 240 into my 93 240 without any change in my stalling issue:
AMM, coil, ignition module, fuel relay, spun all fuses and checked hose between throttle body and AMM for holes.
Was super hot in NM today and after driving the car about 1/2 an hour it stalled and would not restart until it cooled off for about 20 minutes.
It doesn't seem to matter what level the fuel tank is. Stalled the other day when it was full.
I have an 89 Volvo 244 DL series. I have had a complete tune-up, and oil change just recently. Battery works great, plenty of voltage, even had the fuel injection cleaned out.
Problem is the car starts right up when it is cold, however, after driving it and let it set for an hour the car starts up slower and immediately it stalls out. I do it again and the same thing happens and then I leave my foot on the pedal to keep it running at a higher idle for a bit and then place into a gear & it goes without any hesitation. If by chance I do not leave foot on pedal and put it in whatever gear it immediately stalls out. I have driven Volvo's for years, from the 70's to what I have currently. I never had encounter anything like this and have dealt with many other issues and this one has me baffled.
Could this be from bad gas? I put a bottle of Gum out fuel system cleaner in the tank was almost full and the directions say to put it in when almost empty and then fill for best results. My son bought gas at the same place I did and his car started having idle problems at about the same time my problems started (sometimes his engine races, sometimes normal, sometimes so slow it stalls out).
My car is a 98 Volvo S70
The car occasionally stalls while at a stop and the car is idling. The car is supposed to idle at 900RPM but is idling at 550RPM. What would be suggested to prevent the car from stalling?
View 7 RepliesIt can go for days without stalling. It will rev up at a stop light on its own, so I need to put my foot on the break harder to prevent taking off.
Sometimes while shifting gears, mostly to reverse. Car smells like gas when windows are rolled down.
Other people say there's an air leak by listening, but I can't hear it. I sprayed starter fluid on the hoses to see if the rpms would go up but nothing happened.
My 2000 Volvo S70 just started stalling while driving: it completely dies while in motion. This has happened 4 times in the past week, both times (oddly) in the morning on my way home from the gym. Both times, it's happened we have had very damp weather, and it's the second start-up of the morning. It has happened at slow speeds, and it feels as though it is out of gas, but it is not.
View 1 RepliesI've had this car for a little over a month, when I first bought the car it ran fine, until I drove it home. It stalled out and would not start up again, turned out I had low fuel pressure so I replaced the fuel pump. After this the car had been running fine up until a few days ago. It was stalling out and starting right up, now I am lucky if it will start up. I am still getting fuel pressure to the fuel rail. Would it be my injectors?
View 1 Replies2002 BMW 325i. It starts then stalls. It stalled in the middle of the road the other day while I was going REAL slow. Now it's totally unreliable. If it starts it leaves me stranded. Turn over just fine never engages.
View 7 RepliesI've had this intermittent issue for a while where the car won't start properly. What seems to happen to me is that it starts properly, but then immediately stalls. Normally during a start it will start at about 1200rpm then quickly idle back to under 1000 and then slowly reduce some more. Now at about the same time as I would expect it to idle back to 1000rpm it stalls. After this happens, it seems like I can keep reproducing the failed start over and over again if I try to start the car again. If I wait 30 seconds or so and then try to start it, it usually works.
On two or three occasions I got a warning on the dash about faulty steering lock. Checking in VAG the only errors shown are related to those, no other codes. This has happened many times over the course of perhaps two months. It's been colder during this period, but generally it seems the error happens more often when its a little warmer weather and not really cold. Lately I've been inserting the key part way, waiting a few instants for things to initialize and then starting and it seems to work every time.
My 1996 Volvo 850 with 254K miles has what seems like random starting troubles. Some days it starts without any problems. Other days I am unable to get it started. The battery is fine. I had to tow it to my mechanic one night and he started the car the next morning without any problems! But it has become unreliable.
View 3 RepliesMy 1994 volvo 240 stalls at idle when the engine is warm. It's happening more frequently as the weather gets colder, I'm not sure if that's a coincidence. The car is an automatic and I'm wondering if it could be something as simple as low transmission fluid.
View 1 RepliesI have my 1995 Volvo 940 Turbo that stalls in reverse and hesitates on take off. The following is a breakdown of what has been done so far:
1. Initial Issue from March to October is hard starts; it would take 15 minutes or more to start car; it would be longer sometimes in cold weather.
2. Car would have erratic idle after startup; car reaches operating temperature before movement; car would bog down in idle and die only in reverse; initial acceleration from takeoff is slow;
car runs fine once out of first gear from takeoff; car bogs down on braking with idle lowering; sometimes car stalls at braking; gas is sometimes tapped slightly to stop stalling.
3. Issue of hard start would be intermittent; it would be less prominent in hot weather and more prominent in cold weather.
4. Sometimes in rain or wet weather, car would stall and sometimes backfire; Distributor Cap is normally changed.
5. By October, a no-start condition occurs.
6. Car starts now, idle is not erratic; car would bog down in idle and die only in reverse; you barely tap gas to keep from dying in reverse; initial acceleration from takeoff is slow; car
putts a little; car runs fine once out of first gear from takeoff; exhaust flows strongly; takeoff slightly improves incrementally with continued operation; car bogs down on braking with idle
lowering; sometimes car stalls at braking; gas is sometimes tapped slightly to stop stalling.
7. During idle or operation, sometimes coolant will boil in reservoir; toggle fan brings temp down to normal in between fan cycles; toggle fan keeps coolant temp normal in really hot weather.
The following parts have been changed and are still prominently new:
-Ignition Coil
-Spark Plug Wires
-Spark Plugs
-Distributor Cap (Initially Sealed With Sealant, Condensation Issue When Raining Causes Stalling)
-Rotor Button
-Condensation Cap For Distributor Cap (No Need For Sealant Now)
-K&N Air Filter
-Turbo Intake Hose (Original Had Disentegration In Spots)
-Exhaust Manifold Gasket (With New Locking Nuts and Sealant On Manifold Side, Not Block Side)
-Power Stage (Ignition Module or Ignition Stage Amplifier)
-Engine Coolant Temperature Sensor
-Gauge Temperature Sensor
-Knock Sensor
-All Vacuum Hoses
-All Coolant Hoses (Including Oil Cooler Hoses)
-Fuel Pressure Regulator
-Oxygen Sensor
-Catalytic Converter (Honeycomb In Original Rattles, Discovered Gone When Removed)
-Exhaust Resonator/Central Muffler (Original Damaged By Honeycomb, Sounded Like Broken Glass, Baffles More Than Likely Clogged)
-Idle Air Control Valve
-Starter Solenoid (Starter Tested Good)
-Power Brake Booster (Original Replaced, Failed 2 Out Of Three Brake Pedal/Vacuum Tests)
-Battery
-Radio Suppression Relay
-Throttle Position Sensor
-Fuel Filter
-Timing Belt and Tensioner
-Crankshaft Position Sensor (Last In Chain, Resolved No-Start For Now)
The following are checkpoints, mods, and maintenance:
1. Modded Airbox for more airflow, no codes present from OBD before or after
2. Cleaned MAF Sensor with MAF Sensor Cleaner, no codes present from OBD before or after
3. Checked EGR Valve - Diaphram not broken, free movement, appears functioning
4. Had EGR Pipe Rewelded - Pipe broke from connection to throttle body, completely sealed and functional, Minimal Carbon Removed
5. No codes from EGR temp sensor before or after
6. Checked EGR Vacuum Controller through OBD - appears functional
7. Checked Fuel Pump - Repaired frayed hot wire, sealed, pump fully functioning
8. Checked Fuel Pump Relay - Functioning
9. Properly adjusted Idle Air Speed - Steady Between 700-800 RPM
10. Checked EGR Pipe to Exhaust Manifold - Minimal Carbon Removed
11. Cleaned Throttle Body with Throttle Body Cleaner - No Soot/Carbon exiting system
12. Created Toggle with Fuse in between connection, connected to slot in fuse box, cuts off with car, slight battery drain issue before and after installation
13. Checked oil in case - oil change still new, no milky appearance suggested head issues
14. Removed and cleaned breather box - no oil deposits clogging operation
15. Checked charcoal canister - stalling in reverse happens with and without it connected
16. Checked muffler during disassembly of exhaust system - no honeycomb/debris present during testing
17. Car is at Top Dead Center - Timing
18. Fuel Injectors tested fine with OBD and Pressure present at rail
The following parts have not been changed yet:
-Charcoal Box
-MAF Sensor (No Codes)
-EGR (No Codes)
-EGR Vac Controller (No Codes)
-Compressor (No A/C, issue with stalling is unrelated)
-Power Steering Pump (Slight squeaking on rotation, PB Blaster in bearing area confirms, issue with stalling unrelated)
Other Issues : Slight battery drain coming from somewhere in the car, have to remove negative from battery for now