Volvo :: 92 940 GL - Gear Doesn't Want To Shift Into The Next
Nov 24, 2014
I have an automatic 1992 940 GL and it has been almost a year since the head gasket blew in the car. The gaskets and everything have been replaced as well as the fuel filter, transmission pulley, and timing belt. The car seems to run fine except for a small problem with the gears. When driving it's like it doesn't want to shift into the next gear unless you let off the gas a little bit which then it shifts over fine and it does this for all for gears. It has also recently started back to stalling out at a stop light or stop sign but very rarely.
View 1 Replies
Advertisement
My beautiful 1990 Volvo 240 will not shift into 4th gear! It is an automatic. The OD light will go on and off and I can hear it click when I turn it on. I just noticed that when getting on the highway it seemed as if the RPM was a little too high so I started paying more attention to which gear it was in and noticed today that it stays in 3rd gear.
I have already replaced the fuse #11. With the OD seemingly working fine, should I mess with the relay?
View 3 Replies
I just picked up this old 240 wagon with 230k miles on it for next to nothing due to a transmission issue. It stays stuck in 1st gear for about the first 15 minutes of drive time and then starts shifting perfectly after that. I took it to a transmission specialist and he thought the valve body may be sticking. I also had an experienced volvo tech adjust the kick down cable but so far its still having the same issue.
View 5 Replies
I got into my 2000 V70 Turbo and noticed that someone had cracked the gear shift box. I didn't know what to think so I checked to see if they messed with the gear shift (automatic transmission) and thus were trying to steal the car by moving the gear shift into neutral and pushing my baby away. Nope. Gear shift looked ok. I put my key in and the car was totally dead. I popped the hood, looked about, then looked at my main fuse box. Someone pulled my air pump relay fuse. Oh boy! I went back to the gear shift to see if they messed with my emergency brake. I can't tell. So, I called the police and filed a police report. Here's my question: By pulling the Air pump relay--is someone trying to kill my ABS brakes and then when I'm cruising down the highway I have no ABS and my emergency brake is gone? Very scary thought here. Is my thinking clear, or is there another reason to remove the air pump relay and break into my gear shift box?
View 19 Replies
My 1988 Volvo 240 DL a/t 200000 miles does not shift into overdrive (4th gear ). Is there a relay between the switch and the solenoid?. Is it okay to drive over 40mph.
View 1 Replies
My 2007 es350 is already warmed up, so I know its not a temp issue.
My VSC light comes on (i know it comes on with any DTC)
My traction control light is on
My engine light is on
Now, when driving, it doesnt shift out of first gear till about 4K rpm and thats at normal acceleration (not flooring it) and shifts out of range on all other gears.
I can hear a humming/winding noise coming from the left side of the car (tray side) and it does it and I can hear it very clearly when letting off the accelerator (more noticeable at high speeds)
View 5 Replies
Recently I have another problem:
When I drive uphill on the way the car's transmission doesn't shift up to the upper gear,the gear stays on 1,when I press the gas pedal more the EPC light comes on the dashboard,I must release 2-3 times the gas pedal then the gear goes up to 2-nd or 3-rd gear.This happens only when I drive uphill,when drive on flat street this problem almost doesn't come.
Another,when I drive downhill,the gear doesn't release sometimes too,the car tries to stop from 3-rd gear directly to 0,and the RPM goes straight to 100-200,even the car turns off... I heard something for the VW Phaeton transmission problems,and that it can be SOFTWARE flashed and the problems go away???
View 2 Replies
Have an 02 Auto with the 2.7, 4wheel drive, and it doesn't shift into 5th gear. Can go through the 4 gears with the manual shift, but when just in drive, only shifts up to 4th. At 65mph, RPM's over 2500.
View 3 Replies
Volvo Automatic 1992 240 - So, just started to back out of the garage and, all of a sudden, my gear shift got stuck in neutral and then started shifting without engaging the transmission at all. Pushed it back into the space and, taking a look underneath, I realize the control rod's completely detached from the lever in the transmission.
I can re-attach it, but it just comes loose again when I shift. It seems like something should be in there to hold the control rod in place with the transmission lever, but I don't know what because I can't seem to find any documentation on what everything should look like down there.
Attaching a couple shots, one with a circle around the area that's coming un-attached since the angle's a bit off.
Attached File(s)
IMG_8972.jpg ( 1.09MB )
IMG_8978.jpg ( 938.64K )
View 1 Replies
My camry has been great up until the last week. The weather has gotten extremely cold here and when I start driving in the morning or from any cold starts the transmission doesn't shift out of second gear. After I drive it a mile or so and slow almost to a stop it will shift normally until I park it.
It has 125000 miles on it and I hope this isn't a serious problem because it is a great car and has been well taken care of. Looks brand new on the inside and out and I've never had any problems until now.
View 3 Replies
I have a 1989 F-350 7.3 IDI with a ZF-5 trans. Lately, I noticed that it was a little harder to shift my truck through gears while driving than it normally is, and when I'm stopped and try shifting into first gear or something it like vibrates and makes like a grinding noise like it doesn't want to go in gear. For a while, I've also had to push on the clutch very hard in order for it to I guess hit the linkage and start, but I never had problems shifting until lately.
Today though, I went to start my truck, I pushed on the clutch as hard as I could, and the switch would not engage so I couldn't start it. So, I guess the switch was farther to link than the pedal could possibly go. I went under the dashboard and engaged it by hand then it started. I drove home and the shifting was still iffy. How can I make the switch engage normally again so its closer I guess and so I don't have to push so damn hard on the clutch to get it to start? And could the switch linkage have anything to do with the shifting being funky lately, or could that only be the clutch itself?
View 3 Replies
My car has 109000 miles and we live in SD. Recently the car just won't go uphills - the engine revs up, but the speed doesn't get above 40-45 miles per hour. Once at the top of the hill, the car just takes off and drives normally until the next hil! What could be the problem.
View 7 Replies
The system is charged, the fan looks working, but the a/c works well only when the cars is moving. What is it?
We think it works well if the "rear ac" is on, but that's not normal anyway.
The system is charged, a autozone tester say overloaded but the gauge of a technician says is ok, then who knows. The fan is working and the car never goes overheat, then I guess that fan is working good.
View 1 Replies
I owned a Volvo 2003 s60, my question is I don't whether my car has an alarm system and siren, I have tried to open the door from inside, but the alarm doesn't come on. If doesn't have how can I install one.
View 2 Replies
I have a 03 xc90 t6 came out of work the other day and it wouldn't start replaced spark plugs, both cam sensors, crank sensor. After doing all that it sounds like it wants to fire now but doesnt.
View 1 Replies
I have been having an issue with my 4-5 gear shift under hard acceleration and know that a rebuild is due soon but I was wondering if any high performance kit available with all the clutches and friction discs needed to rebuild.
View 6 Replies
So i was trying to adjust my freinds shift linkage on his o2j and i got a little ahead of myself and forgot to put the shift tower in the home position before making the adjustment. after i realized you can't shift into second ( either that or 2nd and 4th are extremely close together now and feel like the same gear ). I try to get it in home position even with the cables off ( did this for experimentation) and still wouldn't go into home position...meh. still have all the other gears including reverse .
View 4 Replies
My 1989 740GL has a blower motor that doesn't work; I looked into it and discovered a blown 30A fuse. So I replaced fuse and guess what? "POP"! No luck... It keeps blowing them, so I really haven't looked that far into it, but where I might start?
View 2 Replies
I gotta prob with my 08 camry 83k....I bought it two months ago and def didn't notice this so think its a new prob.. Whenever I take my foot off the gas the car seems like it doesn't shift smoothly... For example if I am going at 2rpms, I will take foot off, and go to 1rpm, and then it will jerk back up to 1.5 rpm..is this normal? The dealership tells me everything is fine and I am not so sure figured to consult with the pro's ...
View 5 Replies
Picked up the T-Reg on thur. Black w/teak V-8.! Had the factor hitch installed? Service dept indicated a change was needed in the on board computer to adjust for the additional strain that towing will put on the drive train. What may have been changed?
The trans does not seem to shift as easy as when I drove it first, it could be just the amount of time that I spent in it on the test drive run. If you leave from a stop and try to leave smoothly it is a little harsh, not as smooth as the A-6 Avant with Tiptronic that we had.
View 1 Replies
Background facts:
Tranny swapped from my 4 speed auto to a 1.8t o2j 5spd
13lb. Light flywheel
Powerflex dogbone mounts
Peloquin LSD
The problem: Very hard to get a smooth shift from gear to gear. Trust me, I know how to drive, but I can always feel the car shifting into a different gear if you know what I'm saying. On my friend's bone stock Jetta, I just let the clutch out without gas in between shifts and you don't feel a thing.
On my car, you feel EVERYTHING. People have told me the light flywheel will make the ride more uncomfortable in many ways, especially since the RPMs drop much quicker in between shifts than stock.
View 9 Replies
