Volvo - 850 :: When Try To Start Engine / Turns Over And Sputters Before It Dies
May 22, 2015
I have a 95 Volvo 850 2.2 L (non-turbo.) I recently replaced the fuel pump, and filter. Now when I try to start the engine, it turns over and sputters before it dies. I let it sit for about 10 minutes and try again with the same results and the same with a longer wait time due to having to charge my battery. I have checked the fuel lines and they seem to be clear, up to the fuel rail. I also checked the plugs and although they need to be replaced, after sanding and re-gaping them, there is plenty of spark. The plug wires and distributor cap are fairly new, and the points look good. So the only problem I see as logical, is the fuel rail, pressure regulator, and injectors. I have bled the fuel rail at the shrader valve, and I am getting little to no fuel from it. I want to remove the injectors and rail, and check out the regulator along with the rest. But how do I tell if the regulator is good, and what is the best way to clean injectors so they will at least last till I can replace them with new?
View 2 Replies
Advertisement
'99 Intrigue (3.5L) with 65k miles. The car has sporadic starting problems where turning the key in the ignition turns the starter motor and results in one of the following scenarios:
1) The engine does not turn on.
2) The engine turns on, RPMs drop and the engine sputters and dies.
3) The engine turns on with no problems (like this morning).
It does not appear to matter whether the engine is hot or cold.
Reading forum posts of people that have seen similar problems, several different solutions would seem to be in order:
1) Replace fuel pressure regulator.
2) Replace crankshaft position sensor
3) Replace camshaft position sensor
4) Replace fuel filter
5) Replace spark plugs
6) Replace idle air control valve
7) Clean the throttle body
Since I rather not start throwing money at the car by replacing parts one by one until the problem is gone.
View 11 Replies
I drive a 2004 Volvo v70 (non turbo). It died on me about 3 times in 5 years on tight turns ((switchback). It hadn't happened for a couple of years but now it has stopped 3 times in the last couple of months. It is very dangerous as the steering stops working and I have to totally stop, put my car in park and restart.
View 2 Replies
A minor but persistent (year-long) rough idle on my 1991 240 has quickly turned into a Cold Start Nightmare over the past month:
SITTING HOURS OVERNIGHT (50 to 60-degree temp. overnight) - When I attempt to start in the morning, the engine idles high for 3-5 seconds and then immediately dies. To successfully start, I must keep pressing the accelerator pedal at least half-way down for 2-3 minutes. The engine sputters, almost backfires, shakes, lopes, almost dies, etc. After 2-3 minutes, everything runs just fine.
WARM ENGINE SITTING - Once the engine is warmed up, it will consistently start without problems. Still a slightly rough idle, but OK. The car does not die.
I have changed the battery, coolant temp. sensor, and spark plug wires.
View 3 Replies
I purchased a 1990 Jeep Cherokee Laredo at a steal . . . I've already replaced the head gasket sealant. My biggest current concern is the fuel pressure. The car either starts up beautifully or sputters and gurgles for a good 5 seconds before finally idling normally (either occur during cold or warm starts).
The sputtering at start-up has become more commonplace as of late. If I drive away without providing a good three-to-five minute warm-up, the car will drive as normal while applying gas pressure to the peddle, then once gas pressure is no longer applied, the car dies silently; The battery stays on, but all power steering and engine power disappear and the car coast into nothingness. If I allow the Jeep to warm up significantly, it will drive as normal for hours, except for it's struggles to compensate long upward hills.
The fuel regulator has a slight leak. Worse at start-up, lessens up over time. The seal may be improperly seated, but is in physical working condition as I can tell. Spark plugs were replaced. Battery was replaced. Injectors have been tightened. There is a slight oil leak (it seems to move around a bit), but is far better since the Head Gasket was replaced. Could this be a bad fuel regulator or something else that I have missed?
View 1 Replies
I replaced the engine computer (1346107) with one from ebay. Now it runs but sputters unless I disconnect the vacuum line (still sputters but a lot less). with it connected, the timing is off (to about 15-18 instead of 12). the distributor is rotated as far as it will go. Need to recognize these symptoms? Is there a procedure to test the ICU?
View 17 Replies
2001 F350 7.3 ... Below 35 degrees, truck is hard to start. Cranks for a while, sputters, dies. Repeat a couple times, finally starts running rough, surging and loping for 10-15 seconds before it settles down and runs smoothly. Recently had all glow plugs replaced. Next cold start didn't show much improvement (not as bad as sometimes, but wasn't very cold either).
Surfing here and other forums, I see suggestions about letting glow plugs heat longer after WTS light goes out. Some suggest as long as 60 seconds. In the past, I have tried waiting a little while longer after light goes out, or turning key off/on and letting it cycle again. But I've never really timed how long I was waiting.
We're having a warm spell right now, so I can't do much testing. But yesterday morning was about 30. I timed the WTS light and it went out after 10 seconds. I waited another 20 seconds.. about 30 seconds total. Starting seemed a little better than usual, and there was about 1 second of roughness before it settled down.
I need to do more cold weather testing to be sure, but it does seem like it might be better to wait longer than I have been.
On the other end of the scale, I saw a comment that glow plug cycle is dependent on oil temp, and they don't come on at all if oil temp is above 40. Is this correct? If so, is there any good reason to wait to start in warm weather? I'm usually pretty diligent about waiting for the light regardless of weather, but the truck doesn't seem to object if I get impatient and start it sooner in warm weather. If the glow plugs aren't even on, why wait?
Should I just totally ignore the light, and wait for some interval (or not at all) based on a semi-educated guess about how much glow plug time might be necessary for the current temp?
View 14 Replies
I have a 2003 Volvo XC90 that turns over but will not start. The fuel pump has been replaced twice, once by the car lot I purchased the vehicle from - the car worked for maybe a week and the problem returned, and the second time by the Volvo dealership - again the car worked initially, maybe another week and the problem returned. I'm not even sure if it is the fuel pump, but after two fuel pumps, I'm thinking that the issue may be something else.
I'm not sure if Volvo Dealership ran a full diagnostic or not, because they replaced the fuel pump because of the recall. Each time the car was "fixed" the car would start maybe after 3 seconds of cranking (which is long compared to my other cars that catch immediately) but on subsequent starts the 3 turns into 10 seconds, 15 seconds or so the next time, until eventually it just does not catch and I drain the battery in attempting to.
It has actually been "fixed" three times, but the second time a fuse was replaced, and it worked, and deteriorated exactly the same way as the other times until it no longer started again. I'm hoping that the nature of how it begins failing can be of some assistance, I feel as if some type of pressure or something is being lost over time, the way it takes longer and longer to start before it decides not to.
View 2 Replies
I drive an 05 Chevy Classic (that's an '04 Malibu made in '05), and it's never given me problems (though I've only had it about 2 years). This morning, I can't get it going. The engine turns over when I turn the key (though some of the time it takes several moments), but then as soon as I let go of the key, the engine dies. I tried giving it gas, but this doesn't seem to make a difference. After a couple of tries I noticed that the dashboard lights weren't coming on. They usually all light up while the starter runs, and I can at least get them to light most of the time when the key is turned to "on". None of this works. The power windows will open and close when I have the key turned to on, so the electrical system works somewhat.
View 8 Replies
Our 1985 Volvo 740 GLE sedan will intermittently not start. The engine turns over, just won't go. Let it sit a bit and it starts right up again. No rhyme or reason or pattern to the failure.
View 1 Replies
I also tried jump starting - get same same result. Engine cranks, turns, and then sounds like it is just about to start up normally but it just dies completely. It seems to want to start but just can accelerate the engine high enough to keep it running. Almost like it's flooded on a carb motor.. 2000 V10..
View 7 Replies
Okay so I ran my excursion earlier this morning and it ran fine and what have you, and now 6 hours later I got to start it up and it sputters and dies. I start it again and it starts right up but then goes to sputter again and I hit the gas and it didn't respond, the RPM gauge was lingering just under 500 RPMs. I had to hold the gas pedal for about 15-20 seconds before the engine would rev up, it kept doing this till the engine finally warmed up and I drove it up and down my block with barely and throttle and with wide open throttle and it ran fine. With the engine warmed up it started with no problems. I have a 2000 5.4L V8 gas
View 5 Replies
Drove the car, 20 min to shopping, and when I came out the car would sputter and die??!! it happened a few times.. it would crank for really a long time, engine would fire up but sputter & die. I was cussing & let the car sit at mall parking lot for a bit, thinking I'll have to cab home but it started up again after 10 min and drove fine. It happened on a parking lot, not on the highway.
View 24 Replies
My 08 escape (3.0) wouldn't go over 45-50mph Sunday on my way home. The next morning I made it about 2 blocks and the battery light came on and it died. I am replacing the battery tomorrow because it tested bad but believe there is also an exhaust problem. Last week it began making a noise I could hear inside the car only when accelerating. Almost sounded like a small,air plane. The car will start and run now but cuts out and sometimes will Rev up when I press accelerator and sometimes won't. The exhaust pipe gets hot really fast and it and the motor both vibrate we the car is started (more than normal) any clue on where to start??
View 1 Replies
I have been having issues with my 2001 sports trac 4x4 v6 sohc fuel in. 132k mileage. The problem is I can jump in and it will start first try, fuel pump is heard activating, idle is rough, feels like truck is about to die, pumping on the gas usually causes it to catch and smooth out......after 10 mins. or sometimes less than that truck starts to sputter, step on throttle it dies faster, sometimes when stepping on the throttle before it dies and a truck is able to rev up and then back to idle and not die.
But most times stepping on the gas when it begins to sputter after running for 10 mins or so causes it to die once it dies it doesn't start back up and when key is turned on and off, no fuel pump activation noise. I have scantool data take off an autel 619 saved to notebook text format. Those are my numbers for the scan tool, suggestions I have gotten so far are vacuum leak, failing fuel pump, bad o2 sensors, bad MAF.......so far replaced fuel filter and cleaned MAF....no difference.
View 11 Replies
I have had a 2005 f150 v6 5 speed for a little over two years. Got about 153k on it. Last night was sitting in a parking lot idling about 20-25 minutes, went to leave and she started sputtering hard, lost all power and died. Started back up, idled fine, as soon as i put it in gear same thing then the check engine light came on.
View 3 Replies
I use my 2011 GTI for track days and have done hundreds of laps with no issues. Yesterday, I got out on the track for the first session and almost immediately I got what has to be fuel starvation on long right-hand high speed turns. The car sputtered and lost power exiting the turn and would return to normal once it got going straight again. The only way I could avoid it was to feather the throttle, which of course doesn't do much for lap times. At that point the tank was about half full, so between sessions I filled it up. With the tank full, there was no problem, but it returned when the tank got down to about 3/4. I filled it up again, and once more it was fine for a while, but the problem returned, this time with about 7/8 of a tank, so I gave up. I drove home (about 100 miles) with no trouble at all.
I know that the fuel pick up is on the right side, so it makes sense that the problem would occur on long right-hand turns. Is it possible that the in-tank pump is getting weak, or that maybe something happened to the baffles in the tank? I have another track day in a month, so I need to get to the bottom of this.
View 5 Replies
My Honda has a strange problem that is vexing my mechanic. While I am driving, the engine spits and sputters and sometimes dies. I try to restart and it starts right up but runs rough. Sometimes it takes a while to start back up. If I wait a few minutes, it will start again and drive fine for a while. Then it will do it again. After it is warm or when it is cold at the start, it won't do it.My mechanic cannot get it to do it long enough to diagnose. The computer is not throwing any codes. I believe it is electrical because when it does this, the speedometer goes crazy bouncing up and down. Electrical problem also may explain why the computer is not throwing any codes. I need to narrow it down because my mechanic is reluctant to start trying things as I don't have a lot of money to throw at this.
View 4 Replies
I have a 1997 explorer sport 4x4 4.0 sohc It has a real tuff time with cold starts sputters won't hold and idle sits at about 500 rpm once its warm its not as bad still has a low idle.
Also i have a constant engine rattle thinking left front cam tension-er
Also throwing and check engine light odb scan tool shows o2 sensor position two is bad
I was thinking intake gaskets and new tension-er is a good place to start.
View 1 Replies
My truck's been having an occasional hard start, meaning the engine cranks strong but it fails to catch and then sputters. The 2nd start attempt usually fires up with no issues and then runs perfectly otherwise.
MPG's haven't changed, fuel filter was changed 15K ago. Air filter is clean. Plugs were changed about 10K ago. I always use Shell/Chevron gas. MAF sensor looked clean when I took it out so I didn't do anything to it.
This is starting to happen more frequently, maybe once every few weeks and I get a feeling it's the start of something. I've found myself waiting a few seconds for the fuel pressure gauge to come up before turning the key to start reliably. In the past, I could simply flick the key and it fires up the first time.
I see posts talking about the fuel pump module above the spare tire. What are symptoms of that going bad? Any pending codes that might be stored?
I'm about to get myself a scanner since I need one sooner or later. Which specific PID's to check while debugging this?
View 6 Replies
My 2001 volvo S60 starts then dies.
View 2 Replies
