Volvo :: 2005 XC90 - Clunking Sound Coming From The Driver Strut
Oct 20, 2012
I purchased my 2004 XC90 2.5T today. it's got 150k miles.
1. there is a clunking sound coming from the driver strut, I'm thinking it is the bushing on top.
2. should i just replace the whole strut assembly? if so is there a diy? and a kit for this?
3. Rear window doesn't stay up, im thinking the sliders on the window are broken?
4. most importantly, whats the best iPod / iPhone hook up for the volvo.
5. also what mods for keeping it clean.
Attached File(s) : IMG_4763.jpg ( 1.44MB )
View 2 Replies
Advertisement
So I installed my H&R lowering springs about 2 months ago and I am very happy about the stance, ride, and handling up until about 2 weeks ago. The car always had a bit of a spring clunk coming out of the driver's side strut tower, but it has become more apparent and pronounced over the last few days. I already tightened the strut nut and shock tower bolts, what else is there to check out?
View 14 Replies
Just changed out the struts on my ACV36R Camry Altise. Fitted up some nice Monroe GT struts and Kings Springs (front and rear) as well as new Nolathane bushes throughout.
Now, everything is tight, checked over every nut and bolt with a torque wrench to the correct specs but I have a loose rattle sound coming from the front right strut. What it could be before I tear the whole lot out again? I've been around it with a rubber mallet trying to isolate the rattle but I can't replicate it by hitting any of the components that I've replaced.
View 6 Replies
Pitching noise coming from front end - Replacing Xc90 Front Wheel Bearings / hub Assembly? I believe they are bad based upon the pitch of the sound coming from the front end. Are they press in?
View 2 Replies
Last week during the extreme cold my 2006 Volvo xc90 dropped a nearly full tank of gas onto my driveway. I had driven each if the three sub-zero days and on the third day drove about a mile, parked for about an hour then came home to get my phone. I left the car running while I ran inside for about a minute and came out to a hissing sound and dripping gas. I moved the car away from my house and watched the fuel indicator go to empty. Once it was up on the flat bed tow truck the driver pointed out big splits in the tank. I am sure I didn't drive over anything or through deep snow. Could the cold have caused this? Did I mention the driveway is new?
View 19 Replies
I have a 2005 XC90, 2.5T with about 210K miles.
The issue began while driving at about 70mph on the highway. The car acted like it was running out of gas, skipping and hesitating. After getting off the highway the issue persisted. Accelerating from a stop caused the car to once again act like it was running out of gas sputtering and lurching. The CEL came on and it stalled once before getting to an AutoZone. The codes came back as P2177 (too lean off idle bank 1) and P0089 (fuel pressure regulator).
I limped home and parked the car for a few days to check out my options. After a few days the car drove perfectly with no issues. But the issue returned the same as before within a few more days. So here's what I've done thus far....
1. Replaced the fuel pressure sensor (no change)
2. Replaced spark plugs (no change)
3. Replaced fuel filter (car ran perfectly for a few weeks, self clearing the CEL)
4. Ran some Seafoam cleaner through a tank of gas (car continued to run fine)
5. A few days ago the issue returns, same as before
6. Cleaned MAF (no change)
After replacing the fuel filter and running the Seafoam it ran great. Then all of a sudden it's doing the exact same thing again.
I've scoured the web for more info but come up empty handed. My thoughts now lean toward the following...
1. Leak in the turbo system or TCV issue
2. Bad injector(s)
3. Bad coil(s)
4. Failing fuel pump
5. Random O2 sensor freaking out
View 3 Replies
I have a 2005 Volvo XC90 with 120K+ miles. About 2-3 months ago, the car alrm started going off randomly, while sitting in my driveway. Generally it would go off around 9-11 pm, but also at any other time. It has gone off 5 times in a row within 5 mins. It has gone off at 3 AM, 4:10 am, 5:15 am, and other totally random times.
It happens anywhere from 2-5 or 6 times from when I get home til I leave in the morning. But here's the thing......it ONLY GOES OFF IN MY DRIVEWAY. Only. I have taken the fuse out, had the remote starter and alarm disconnected, tried leaving it unlocked, tried parking in a neighbors driveway. It still goes off.
The time are so random that no one can figure it out. The weather makes no difference. I literally keep my keys in my hand at all times when I'm home so that when the alarm goes off, I can turn it off as quickly as possible. I keep them on the floor outside when showering and in my hand when I go to bed.
The Volvo dealer says he's seen it 100's of time and he can fix it, but when I told him it only happens in my driveway, he said he had no idea what the problem could be. It's going to a car shop next week to see if they can disable the factory installed alarm but I hear that's nearly impossible.
View 2 Replies
The drivers windows when engaging the auto up will close then go back to it's previous position. I physically have to keep the button engaged for the window to close... Otherwise, it works...
View 2 Replies
I have been having intermittent issues with the driver's side headlight. It will randomly fail for no reason while driving. This can often be remedied by turning the lights off and then back on again. The headlight will also fail not-so-randomly. Two triggers are driving on a bumpy road (we never get potholes in the winter in Ohio), and - here could be the clue to the problem - when I make sharp left-hand turns (90 degrees). What could cause the headlight to fail by making a left turn? The ballast has already been replaced once under warranty (which has since lapsed), and the dealer has wanted to replace the bulb since the xenon bulbs are quite expensive, and may not actually be the cause of the problem.
View 1 Replies
03 xc90 with 83k miles.
Its got the "no oil pressure stop engine safely" light coming on when it gets up to running temps.
I am having my mechanic drop the pan, clean for sludge and replace all the seals and O-rings.
Which O-rings need to be replaced. I read somewhere there are 5, I bought the set along with the volvo sealant but need to give exact instruction to my mechanic on which seals to replace (he is not a volvo guy) and I dont remember which ones.
View 1 Replies
We purchased her GLI a couple of months ago, as is, knowing the issues it had and whatnot. We talked the dealer down so much that he refused a warranty.
This pesky *clunk* sound coming from the driver side front-end. Usually on bumps, it sounds like a suspension deal... We took it into a shop, they "re-torqued" the suspension, and did the alignment. It was good for about a week, then it came back. Also, there's a creaking sound when turning, my guess is CV boots? Axles?
[IMG] [URL].....
View 6 Replies
Just installed raxle on my driver side. All clicking sounds are fixed but I noticed if I take right turns sometimes you can hear a constant clunking sound coming from the driver side wheel. It doesn't happen all the time, you kinda have to turn and hit a certain angle of the steering wheel. Also, only happens when driving low, if I raise the car just a little bit its gone. Never had issues with my oem axle binding so Im not sure how exactly does the binding sound?
View 24 Replies
I just joined this forum some minutes ago, I own of a 2004 XC90 T6 AWD, delivered to me a couple to days ago, just barely getting to know the car, hear a knocking sound from the front passenger seat when i drive on rough roads, and this morning check engine warning sign remained on while driving out, had to park the car at home.
View 4 Replies
Transmission Problems in 2001 Volvo XC70 with 123k... A year ago, I had the input and output speed sensors replaced after the service light came on indicating a transmission problem. The transmission has always made a clunking sound and now it is having a hard time shifting from 1st to 2nd and 2nd to 3rd when doing city driving for a while. It jerks significantly when it finally shifts. It is usually fine in the morning on my 3 mile commute but if I am running around town or after coming off of the highway, it has a hard time shifting. The book states only to have the transmission fluid changed every 52,500 if you use the car to tow which I do not. Should I just give it up and get a new car as everyone I know is recommending? I love this car and otherwise it is in beautiful shape.
View 3 Replies
Scenario- Start car, back up, and cut wheel to the left out of the driveway. There is a loud, crushed can noise. Yes, just as if I had run over a can, but didn't. This only happens if the air conditioner is on.
View 5 Replies
I've been in some version of a Volvo since I inherited my parents brick-colored sedan in high school. It was a tank, ran forever and kept me safe and protected. Years later I bought a new black Volvo sedan. In 2006 with a hubby and two kids, I decided that I could graduate to the SUV. Feeling like I'd made a fantastically safe and practical decision, I drive my silver XC90 to work and on road trips. It's not the fanciest nor sexiest vehicle, but I feel my family is safe.
Hard working folks should not have huge budget surprises like my Volvo SUV has turned into. Little did I know what I was getting myself into when I made this purchase. When I took it into the Culver City dealer for my 30,000 mile service yesterday, I found out that my Volvo XC90 needed it's second replacement rotors and brake pads. I'd already been through this expense at 17,000 miles, much to my surprise. I'd never heard of needing to replace brake pads and rotors at 17,000.
Now, at 30,000 miles the local dealer's service department told me I needed another set at a cost of $1,000.
I have friends driving a Toyota or a Honda that rarely require maintenance or repairs. Volvo is an expensive vehicle to buy and it gets you every time you visit the service department and all repairs are expensive. It's disappointing to say the least.
View 17 Replies
I have just replaced the rear discs and pads on a 2008 XC90 which has solved the problem I had with them. However, the parking brake is not working. When the old discs came off they did so easily without any resistance and the new ones went on just as easily so as far as I can tell the parking brakes weren't disturbed. The parking brake did come on after 3-5 clicks before this work was completed and now they are not operating after 8 clicks so am at a loss to understand this problem.
View 5 Replies
RE: 2007 Volvo XC90 90k miles
Pulled into my driveway last night with the power steering working intermittently for last 5 minute leg of my trip. Woke up this morning with no power steering and sqealing noise coming from engine.
No fluid leak on driveway. Drove to dealer with no power steering. Very hard to turn wheel - even while moving.
Dealer checked and said it was not a fluid issue and that they thought a screw might have fallen out and needed to take apart the rear of the engine (a 5-6 hour job) just to diagnose the problem.
A screw from the steering column in the rear engine?
View 4 Replies
I have a 2003 Volvo XC90, 2.5T AWD ... Since two weeks no start, no crank, when I turn the key in the ignition nothing happened, only the navigation screen is going off. I try the second key and it is doing the same. It happened when battery goes very low.
I try to scan it with different scanners and the same DTC is showing: (ECM-720A: Immobiliser communication)
Someone said I must remove the ECM and the ECU, read the both and use "Volvo Synchro V1.4 Loader" synchronize and program the key but i do not really know how to do it. Is it possible to do immo off ?
The VIN number is: YV1CZ59G741071108
View 2 Replies
I have a 2003 Volvo XC90 that turns over but will not start. The fuel pump has been replaced twice, once by the car lot I purchased the vehicle from - the car worked for maybe a week and the problem returned, and the second time by the Volvo dealership - again the car worked initially, maybe another week and the problem returned. I'm not even sure if it is the fuel pump, but after two fuel pumps, I'm thinking that the issue may be something else.
I'm not sure if Volvo Dealership ran a full diagnostic or not, because they replaced the fuel pump because of the recall. Each time the car was "fixed" the car would start maybe after 3 seconds of cranking (which is long compared to my other cars that catch immediately) but on subsequent starts the 3 turns into 10 seconds, 15 seconds or so the next time, until eventually it just does not catch and I drain the battery in attempting to.
It has actually been "fixed" three times, but the second time a fuse was replaced, and it worked, and deteriorated exactly the same way as the other times until it no longer started again. I'm hoping that the nature of how it begins failing can be of some assistance, I feel as if some type of pressure or something is being lost over time, the way it takes longer and longer to start before it decides not to.
View 2 Replies
Have 2014 XC-90 w/10k miles. Problem is sporadic (has happened approx 10-15 times over past year).
From standing stop (stop light, etc) -- press on accelerator and VERY LITTLE to no acceleration. Engine continues to run smoothly -- no indication of fuel starvation, no roughness --- just no acceleration. It does NOT appear to be transmission oriented because when it finally "kicks in" there is no feeling of transmission shifting or wild tach movement (to indicate that there was a changing of the gears, etc). I get things back to "normal" by pumping the accelerator (usually a reflex action because the are vehicles behind me wanting to "go"). VERY disconcerting issue.
Local Volvo dealer says "cannot find any error messages", etc. My only complaint with the car -- second XC-90 and 5th Volvo.
View 3 Replies
