I have just bought a 1988 740gl turbo and I was driving it the other day and when i came to a set of lights just as i stopped the car stalled on me then wouldn't start...
I left it for a hour or so came back and it started and i drove away and only went a few kms home.... what would this be I haven't driven it since!!
i have just bought a 1988 740gl turbo and i was driving it the other day and when i came to a set of lights just as i stopped the car stalled on me then wouldn't start...
i left it for a hour or so came back and it started and i drove away and only went a few kms home.... what would this be i haven't driven it since!!
About 6 weeks ago I became the proud owner of an '88 240 wagon with ~ 235,000 miles.
When turning the key over to start Lucy (that's her name) most times she will crank for 3 to 5 seconds before indeed starting. I can avoid those 3 to 5 excruciatingly long seconds if I let her crank for a time or two then let her rest for a second - after that she will start up immediately when I turn the key again. This situation happens probably 14 times out of 15. The 15th she will start like a dream the first time. I have had the battery tested (although I could not find a date on the battery and the previous owner did not know when it was purchased), and I have completed a full tune up (plugs, wires, rotor and cap) among other maintenance issues as well.
Attached File(s)
Lucy.JPG ( 3.4MB )
Lucy_Under_the_Hood.JPG ( 3.87MB )
1990 740 gl with 225000 miles and as a routine maintenance I want to clean my solenoid and maybe flip the contact and clean up the plunger on the bendix (inside the solenoid). No biggy right. I know my way around this car, replaced water pump, fuel pump, fuel filter, injector o rings, etc., sensor, etc over time.
The starter though wow - how do you get access to the top bolt? From top side I took off the bellows to intake manifold ( air breather element)but that top bolt I cannot see how to access with a short socket.
From the bottom I can get at that bottom bolt easily enough and actually got it out no problem but that top one wow. From underneath it seems like there horizontal room not vertical room due to the tranny dipstick.
This is the only part I am having trouble with, everything else on this car is pretty clean and clear. Again top starter bolt access tips on how to get it out without stripping it.
My friend like to get his 1990 740GL back on the road. It starts and dies. Narrowed it down to injector pulse. Noid light is bright the first couple pulses then gets weaker and weaker while cranking to almost nothing. Tried a new radio suppression relay.
Tested the voltage to the positive side of the injector plug and it is full voltage with no drop from battery voltage. I tested the negative side of the injector plug for resistance to pin 19 on the ECU and it was perfect no resistance. I thought that was a pretty good sign the ECU was bad. Replaced it. Jetronic and same exact number. Same exact symptoms. I checked the grounds on the valve cover to firewall and the ground on the intake from the harness.
What else could it be?The ECU I replaced is in the passengers kick panel. Is there another computer for the injectors?
My 1989 740GL has a blower motor that doesn't work; I looked into it and discovered a blown 30A fuse. So I replaced fuse and guess what? "POP"! No luck... It keeps blowing them, so I really haven't looked that far into it, but where I might start?
View 2 RepliesThe past summer my 1994 Volvo 940 non-turbo over heated and we worked on the coolant system and got it working god again. However just after we fixed it the headlights blew out and we replaced them and then they blew out again. The battery was also going dead when the car was turned off and all electric things were turned off. Now the head lights don't blow but once they are turned on with the switch in the car they cant be turned off unless the battery is disconnected.
Also as of now none of the dash board instruments are working. With the car on and the lights turned on we pulled the connector to the switch that turns on the lights, that is on the dashboard, and the lights still stayed on. We can only think that some water may be causing the problem but it may or may not. I need to know how to fix the headlight problem and the instrument panel.
I have a 1994 Volvo 940 non turbo wagon. I just started having issues with the brakes lights and taillights not working. I have checked all the fuses visually and also did a continuity test on each one found all the fuses were good. I have replaced the all the relays, I have replaced the large red relay ( bulb failure relay ) and even did a continuity check on the bulb failure relay pins that are specifically for the rear brake light, everything checked out fine. I hesitate to change the brake light switch because the third brake light is working fine. I have considered replacing the headlight switch due to the taillights won't come on when the lights switch is on. My headlights do work though. There is no light on the dash indicating a bulb is out now since I replaced the third brake light bulb.
1994 Volvo 940 wagon
Non turbo
I have a 94 EB AWD I am restoring and have recently picked up an 88 EB to restore as well. The 88 did not run. Here's a list of things done.. New head gaskets, new fuel pump, full tune up, radiator flush n fill, oil change, new transmission and rear seal, new battery, new iac valve, many new lights etc. Well here's where your expertise may come in.. the van starts and runs fine for the first minute or two, but when stopped at red lights the van wants to stall.. and while idling actually has stalled. I was going to replace the MAP sensor as I have found that sometimes causes idling issues. I assume the 88 does not have the MAF sensor to clean/replace? Any other things I could check before heading to the vaccuum lines? Also, both power mirrors are inop, the horn is inop and the gas gauge reads CO. I will check the fuses for those problems..
View 4 RepliesWhat are the correct timing marks and positions for a Volvo 940 Turbo? I especially need the position of the crankshaft pulley. I have read the timing mark is on the cover, but unfortunately mine has dry rotted and crumbled away.
View 1 Replies3 months ago I bought a beautiful dark-blue 1988 Volvo 240, manual transmission. This is my first Volvo and I'm already hooked! It's the car that's going to teach me to work on cars because for the most part it's beautifully simple. I bought a repair manual to be prepared, and have now encountered my first real issue.
For several months, even in the rain, it would start and run beautifully. Now when it sits in the rain overnight it will not start the following morning, or until the weather subsides. Once it has a few hours to "dry out" after the rain and humidity stops it starts beautifully. In the wet weather it wants to start, the starter goes and goes and at points it sounds like it almost catches, though ultimately won't. I imagine moisture is getting in somewhere and preventing spark at some point in the ignition system, but, like I mentioned, I'm new to this. Where to begin; what I should replace to begin troubleshooting this?
In a separate issue I can't get fuses for the rear tail/brake lights to keep from blowing when I replace them.
My Volvo 85T sometimes stall while driving, but most of the time while sitting at a light or stopped. I had someone look at it and they replaced the battery. it kept stalling. I had others look at it and they can not figure it out. Finally last night on the way home it stalled while driving. I charged the battery and nothing. it makes no sound when I try to turn it over. it has oil, trans fluid, gas.
View 11 RepliesMy 1988 240DL is miss firing #4 cylinder. I cannot get it to fire. this is what I have done:
Swapped plug wires with the #3 wire. Miss fire does not follow the wire
Swapped plugs with #1 plug. Miss fire does not follow the plug
Tested injector power with a tester and it lights up properly
Replaces #4 injector with a new one, still miss fires.
Replaced cap and rotor
Compression test shows 150 LB in #4
sworn and thrown a few tools, still miss fires.
Spark seems good with the plug out and grounded on the block. What else should I test and or try...
I have a 1988 Volvo 240 DL that I just replaced the battery. It started right up after it was installed. We drove it home and parked it for one week without trying to start it again because we still have parts to buy to pass safety. I live in UT. My son went out to start it today and it would not make any sound or turn over. What should I check next? Starter Solenoid? Alternator?
View 2 RepliesI have a 1988 Volvo 240 DL station wagon that has been in my family since just before I was born. It has somewhere around 300K miles on it (the odometer broke 7 years ago at 250K). It drives around town more or less fine, usually. But sometimes it loses power on me. Usually this happens when I take it on highways, up big hills, in situations where I need to accelerate quickly, etc. It just starts to slow down, and I have to downshift and ease slowly through whatever stretch of road I'm on until I can get back up to speed (usually on a downhill). It's not totally consistent--sometimes it has this problem, other times it doesn't.
The car will go through stretches where it runs fine, then I'll have this problem on a highway, and then it's a little more likely to happen for a period after that (even on surface streets). This has been happening in some form for a few years. When I first had the problem, it happened continually until I heard a terrible rattling in the engine. When I took it in, they found that a spring in the piston/cylinder had broken off and shot up, breaking the cap off one of the cylinders (sorry for the lack of a more technical explanation).
When they fixed that, the problem seemed to go away for a while, but eventually came back (though there has been no rattling since). The most recent time, it had been running around town just fine. Then I took it out on the highway and really lost power--had to slow it down to 35-40mph going up a hill on a 55mph highway. For the rest of the drive it struggled up hills, even as low as 2nd gear. But on my drive home (about 1.5 hours later), the car ran smoothly (though I continued to baby it, and there were fewer upward hills). Since then, even around town it sometimes feels like it might lose power again, but it never becomes a huge issue because I haven't demanded a whole lot of the car.
After that long-winded explanation, I'm wondering: could this be something as simple as spark plugs? Or is this definitely a bigger issue with the engine? If it's a cheap fix, I'm happy to go for it, but if it will require putting several hundred (or more) into the engine, I'm inclined just to let it limp along until it's finally time to take the car out back and shoot it. Figuratively, of course.
I was driving home just a few minutes ago when my headlights flickered and then cut out for a few seconds. They came back on, but I hadn't driven another 1/2 mile when they flickered again and went off for a further few seconds. This was repeated once more about a mile later, though when I pulled over (first time I was able to do so), they stayed off til after I restarted the car and banged on the dashboard.
Further symptoms: running lights, brake lights, and tail lights seem unaffected. Turning the switch for the headlights off and back on does not affect the issue.
Recently my old workhorse started coughing and stalling. This isn't consistent at all. I'll be driving and the car will lose power and come back to life. It also stalls at stop signs. Brought to my mechanic and left it for a week with him and he can't figure it out. 1988 Volvo 240 over 200,000....
View 3 RepliesI believe my head gasket is blown, but no one really knows what's wrong with it.. Car stalled & then smoke came out the oil tank an coolant tank an muffler? I just got this car used a month ago.. where to start..
View 3 RepliesThe car idles fine, but after a couple seconds in each gear (5spd. manual) it looses power and starts to stumble, but if i keep it at a low rpm, it will run. So, if it is the catalytic converter. how can i un-clog it? Dearborn protocol adapter.
View 1 RepliesI have an 88 244 dl. I recently changed the battery charge bulb in the instrument cluster and no I have a no start. The starter engages and the motor turns over but makes no attempt to start. I checked all the fuses including the 25 amp fuse under the hood.
View 2 RepliesI have an 88 volvo 244Dl with major hesitation while driving down the road. I recently had a no start issue and after a week at the shop it was fixed. During that repair it received: New Dist, cap, rotor, timing belt, coolant sensor, plugs, wires. With the hesitation I checked vacuum lines, cleaned T/B and MAA.
One thing I noticed, which seems weird... When the engine is hesitating, missing.. the radio becomes somewhat staticy. The reception of the radio mimics the hesitation of the engine.