Volvo :: 1983 GL 240 Not Running Correctly When Cold Or Wet
Aug 2, 2013
I have a 1983 Volvo GL 240 Auto trans. I've owned this car for a very long time ~20 years and have never had a problem with it. Since mid Autumn this year (currently Winter in Australia) when starting the car after it has been raining, left overnight in the cold or it is a particularly moist day the car will not start properly.
What happens is the car will start and I accelerate to take off the car will lose significant revs, stall and die. If I can get it out from the driveway and onto the road continuously for 5 minutes the car will run fine for the rest of the day.
But if I stop (to a halt) during this period and try to accelerate the car will again lose revs, stall and die. It is very hard from this point to get the car started again as the same thing continues to happen.
I have changed the spark plug leads, engine oil and trans fluid.
View 11 Replies
Advertisement
Car runs and idles good until I turn on lights or fan rpm jump up about 500 to 700 above normal much worst with both on 1000 1500 and fluctuates. Engine runs rough the higher the rpm the rougher.
View 1 Replies
I have a 1983 E350 RV with a 460 engine. It would appear that many "Mechanics" have altered the wiring in different ways. That being said I think the charging and starting electrics are fairly untouched. My issue is that once it has been running for a while the interior lights start to fluctuate so does the radio display. The AC fan speeds up and slows down and I feel like there is not enough gas being pumped up too due to some coughing and sputtering. When I press the brakes the radio stops playing and if I have the AC on it gets worse. Today I changed the voltage regulator and it made no difference. This vehicle has two batteries, one for starting the van like normal and one to run the coach part. The alternator charges both. I think it must be a bad ground somewhere but not sure where to start.
View 2 Replies
I have a 2006 Passat 2.0T (UK Model), and I'm having trouble with both the outside temperature reading and the climatronic's cooling ability. When I bought the car the air-con was blowing cold and warm air without any problems, but the "cold" air is just a little too warm to be working correctly. I've had the system re-gassed but this didn't solve anything.
As I said, all the features of the air-con work perfectly, it's just the cold air just isn't cold enough - so it seems to me that the compressor is working fine. Also, the outside air temperature reading on the MFD reads about 5-10 degrees too warm. Would this have anything to do with the air-con issue?
View 5 Replies
I have a 2003 F250 7.3L. I put new injectors in my truck four months ago and all of a sudden, I have 2 cylinders not working correctly, making the truck to run really badly. I sent the 2 injectors from the bad cylinders back for warranty and they replaced both of the injectors but nothing was wrong. I put them in and the truck still runs badly. I have a new fuel filter, new ICP, new CPS and glow plug relay. I cannot drive the truck, it smokes white at idle. I can unplug each injector at a time and cyclinder 5 does not change how the truck runs
View 14 Replies
I have an 81Volvo 240 sedan with a little more than 200k miles on it. I've had this issue with the ignition for several years now. Sometimes when I turn off the car with the key as normal, the car keeps running as if nothing happened. I've tried several fixes:1. moving the steering wheel violently and put the car out of park2. replaced the ignition switch.3. replaced the ignition switch relay.
Now the only way to turn the car off when it does this is to pull the relay under the dash. When I reconnect it, it works fine. But, I'd rather not have to pull the relay every time I want to turn off the car!
View 3 Replies
My 740 (1990, B230E, non-turbo) has been running rough at low rpm. Once above 1800 rpm or so it's fine. I've changed the Distributor cap and rotor arm (they were both shot), but the problem persists. I'm thinking injector relay or ignition stage amplifier next, but I don't want to just through parts at it.
The plugs were changed 3 months/1,500 miles ago. The misfire is intermittent.
View 1 Replies
I just been told my volvo 850 estate is backfiring and running on 4 cylinders instead of 5. I have been told he will have to run diagnostics and go from there.
View 5 Replies
First time Volvo owner. Love the 97 850 that I got, but it runs really rough, and I don't know if that's normal for these cars or not. When I say it runs rough, I mean that it vibrates like crazy (not shaking, but vibrating) and it's loud. Every other car I've owned sounds smooth when it's idling or accelerating, but not this one. And I don't mind the noise at all, but the vibrations are a little frustrating.
View 3 Replies
I have a 2003 Volvo S40. I just replaced the battery, spark plugs, coils, fuel filter along with a fuel system flush. Because the car was running very rough. It's been 4 days since i got it back from the shop and now my car won't start unless I give it gas. The car won't stay on and it smells like it's running very rich.
View 1 Replies
First off, vehicle is a 1993 Volvo 240, 5 speed with 131,000 miles
1) Temperature gauge is reading hot, but I believe it's running at a normal temperature. I read a few things discussing this issue. First off, a yellow wire that runs through the firewall becomes corroded (as do all Volvo wires of this age!) What exactly is this wire and what does it lead to? Could I just rerun that wire with possibly a thicker gauge? My dads an electrician so no worries with the wiring. More commonly, however; I read that the temperature compensation board fails and gives erratic readings! is this board expensive and how difficult is it to replace? I have experience with this dashboard because I rebuilt my odometer and installed a tachometer, that gives you my basic level of expertise.
2) My passenger side rear fog light won't work, a new bulb didn't fix the problem, what could it be?
3) My car shakes kind of vigorously while braking, especially at LOW speed!? I replaced front pads and rotors, what else could the problem be?
Volvo.jpg ( 2.19MB )
View 3 Replies
1992 Volvo 240 ... I'm having car jerking problem after running for about 20 minutes at speed between 90 -110 kph. Car stabilizes again when the speed comes back to 90kph. There is no problem initially when running beyond 120kph when the engine first started up. The problem only starts after a short while.
View 1 Replies
I own a 2005 volvo s40 i5. Recently I noticed that my dashboard gets extremely hot after just couple minutes of driving. Originally I thought this has something to do with the car's black interior. However, my suspicion changed when I noticed that the dashboard became very hot even on cold rainy days. (Below 60 degrees) This presented couple issues while driving.
1) On cold days, my windshield would fog up very easily.
2) on hot days, the cabin of the car can be intolerably hot. Both of my check engine light and my airbag warning lights are on.
However, auto mechanics cannot diagnose the problem because they can't get a reading through the diagnostic scanner. They said most likely the car has a electrical short somewhere.
What the problem is? Could it be an electrical short that cause excessive heat in the dash? Maybe the engine heat is venting into the dashboard? Fix?
View 2 Replies
I have a 2005 XC90, 2.5T with about 210K miles.
The issue began while driving at about 70mph on the highway. The car acted like it was running out of gas, skipping and hesitating. After getting off the highway the issue persisted. Accelerating from a stop caused the car to once again act like it was running out of gas sputtering and lurching. The CEL came on and it stalled once before getting to an AutoZone. The codes came back as P2177 (too lean off idle bank 1) and P0089 (fuel pressure regulator).
I limped home and parked the car for a few days to check out my options. After a few days the car drove perfectly with no issues. But the issue returned the same as before within a few more days. So here's what I've done thus far....
1. Replaced the fuel pressure sensor (no change)
2. Replaced spark plugs (no change)
3. Replaced fuel filter (car ran perfectly for a few weeks, self clearing the CEL)
4. Ran some Seafoam cleaner through a tank of gas (car continued to run fine)
5. A few days ago the issue returns, same as before
6. Cleaned MAF (no change)
After replacing the fuel filter and running the Seafoam it ran great. Then all of a sudden it's doing the exact same thing again.
I've scoured the web for more info but come up empty handed. My thoughts now lean toward the following...
1. Leak in the turbo system or TCV issue
2. Bad injector(s)
3. Bad coil(s)
4. Failing fuel pump
5. Random O2 sensor freaking out
View 3 Replies
About 3 months ago the check engine light came on. Scanner read rear o2 sensor and it was replaced. After about 100 miles CEL returned. This time it is the front o2 sensor. It was replaced and CEL returned after about 70 miles. Reading was same exact sensor and it was replaced again but same reading returned after about 80 miles. Now the scan is reading P1132 which is MAF sensor. Car is running a little rougher and starting a little harder. What can solve the problem? I have a rejection sticker on my car.
View 3 Replies
My car is blowing cold air but no heat at all. I checked the codes and it's throwing a B1 1-3-1. It's also throwing a A7 1-2-2. a buddy of mine is a mechanic but not too familiar with Volvo's. But he said that he thinks the B1 1-3-1 Driver's side air duct short is the problem. Is this the problem and how do I fix it?
View 3 Replies
I have a 1998 Volvo S90. I usually have to charge the a/c once a year to keep it cold. Today while driving the a/c went from cold to hot almost instantly. I turned it off, waited a minute and turned it back on. Cold just like normal. Two minutes later, hot air again. Turned it off again, waited a few minutes, turned it on, cold air but only for about 30 seconds. This was all done while driving. What might be causing this?
View 2 Replies
We have an 04 Volvo V40 which won't idle when it's cold out, especially at altitude. Not all the time- it seems to be somewhat random, but it is getting more frequent. Our mechanic has replaced the MAP and TCV sensors and that didn't make any difference. What to try next? It recently passed an emissions test, so when it idles, it runs fine.
View 6 Replies
There are two issues with my 1994 Volvo 940 (automatic). They may or may not be related, but that is why I'm asking.
1) When the engine is cold and at a stop sign the engine will rev up and down. After the engine warms up, the issue goes away.
2) Also when the engine is cold, when taking off from a stop the car doesn't seem to want to go.
You can mash the gas all the was down and it just kind of slowly gains speed. Eventually (5-10 seconds) it will act like normal and go and shift fine. I hope that is enough info and makes sense. I'm just trying to see what the problem could be and how to fix it.
View 2 Replies
Motor seems to burn out spark plugs every month. I was using non volvo sparks. I took car to Volvo dealers and repairers who gave car a diagnostic check but nothing showed up. They told me to use Original Volvo Spark Plugs which I did. The Car went great with no problems for about 3 months thinking problem was fixed. Low and behold the same problem came back.
I changed spark plugs again (original Volvo) and car only ran for 10 ks and then ran very very rough with no power. Motor felt like it was running on a few cylinders. It seem this problem happens mostly in hot weather. Motor also heats up but when cooled down runs well again. I intend to buy new rotor Bosch and Distributer cap and if needed coil.
View 2 Replies
I have a 2005 VOLVO TRACTOR, Autoshift, Cummins ISX. Recently the Dashboard only works at "cold" condition, after 5~20 minutes of starting the engine, the information Display shows up: check lights control module, check vehicle ECU, check air bag, check climate module, finally show "check datalink". Speedmetre, RPM, oil pressure, water temperature gauges and gear position are all dead, only Fuel, Air, Pressure and Turbo gauges work. We have replaced new dashboard, but nothing changed. And we checked J1939 communication wire OHMS is 60 at either back of dashboard plugs and data link. All modules are working good except information module. When dash was out, we did connect the laptop via datalink. We could communicate with ECU normally. The problem looks like the dashboard is so sensitive and easily quits working. We had checked batteries and main ground cables and all fuses. We did the test, after removing all lights control module fuses, ABS module fuse, climate fuse etc., the dashboard sometimes works
View 3 Replies
