Volkswagen - Jetta :: 2003 - Stalls Randomly When Cold Or Hot
Jun 27, 2011
I have a 2003 Jetta. It runs great until it just stalls out with no warning. There doesn't seem to be any particular thing I do to make it stall. I could be accelerating onto the highway, just driving down a residential street, moving along at 60 mph, or just starting out of the parking lot. It happens when it is cold and when it is hot. It could happen twice in one day and then not for two weeks. I have taken it to the dealer, a VW specialist, an excellent auto electric specialist, and the local mechanic. No one can figure it out. I have so far replaced the fuel pump, ignition wires, distributor, several engine sensors, complete tune-up, all filters, battery, and some misc wires and hoses. All told, I have spent over $3000. replacing stuff and trying to cure this car's ills. The dealer could not get it to duplicate the stalling. No codes have shown up at the VW dealer, the local guy, and Autozone. The auto electric guy drove it over 100 miles on one week with no problem, then it stalled on him. He immediately hooked it up to the diagnostic machine....and no codes! He was perplexed.
View 7 Replies
Advertisement
I am having a problem with my car stalling randomly. It happens when I am driving and it also happened when the car was idling in the driveway. I believe it to be an electrical problem as there are no lights on the dashboard when I try to turn it over, however after a few minutes it will start and run ok. At first I thought it was the fuel pump, but now I'm not so sure. There is no pattern to when it happens either. When driving the car will start sputtering then stall. I'll let it sit for a minute or so, then it starts again. What can be causing this?
View 5 Replies
My 120,000 mile 2003 VW Jetta will not start in cold weather. It starts fine when the temperatures are in the 30s, sporadically in the 20s and not at all in the teens and single digits. When I turn the key, the engine does nothing; it does not crank. Three mechanics have not been able to figure out the problem.
View 7 Replies
My 2003 VW Jetta TDI has a major problem. The engine has likely been damaged by an oil leak that was not discovered until the oil ran out. I now have much reduced compression (340lbs or less) and the car doesn't like to start in cold weather and when it does it smokes much. I need to know if it is worth rebuilding and, if so, where I might have this work done.
View 3 Replies
2001 VW Jetta wagon will randomly not start it up. Jumping it or popping the clutch doesn't get it going. I've made sure there is nothing draining the power and the battery is new and clean. My mechanic has run diagnostics on it to check the codes and kept it for a week to use it when he ran errands; it never gave him any problems. He wants me to give him a call if I get stuck again so he can hear what it sounds like when it won't start. A week later, it wouldn't start for me(of course it was on a Sunday). I waited an hour and it started. It does this whether it's been sitting over night or after using it for an hour or two. I'll go somewhere, park,and return 10 minutes later and it makes that sound like there isn't quite enough power to start (starter is new).Now it does have over 382,000 original miles on original motor, timing belt replaced a few months ago and the mechanic said it's clean and strong. I would love to know what to do other then getting rid of it!
View 3 Replies
I have an '04 Jetta TDI that stalls occasionally for the past 9 months. The stalling almost always occurs when I am stopped in traffic and then it restarts immediately. Recently it also stalled as I was driving down the street. Any clues? Seems to me like it might have something to do with the battery or alternator but I really don't know anything about diesel engines.
View 2 Replies
I own a 2006 VW Jetta 2.5 (Automatic transmission) with 68k miles. I purchased the car new in Nov '06. Beginning in August '10, the car began stalling while in motion. As a result, I lose power brakes & power steering. The car has been in for repairs on 4 separate occasions. Currently, they have had the car for 3 consecutive weeks. They claim they cannot find a problem and have advised me to return to the dealership to pick up my car. I am terrified to drive this car. A VW mechanic has advised me that should the car stall on the highway again (as it has in the past) I may not be so lucky as I was previously (I was going uphill) and likely lack the body weight to apply enough pressure to the brakes to stop the vehicle while maintaining control.
View 4 Replies
So, I recently bought a 99.5 Jetta. (99 with a 00 body), fixes a few things. Alternator, oil pan, head gasket. I recently drove the car just up the road, drove it back. Went to pull in to my spot and it shut off! Wouldn't start but would crank over. Days go by, same problem. Runs for about 10 minutes then just dies. Fuel pump works, fuel filter isn't clogged. And the fuel relay works.
View 1 Replies
Why my 2004 Jetta 1.8T Stalls out while Driving? It usually happens while on the Freeway, 60-70 Mph, I Coast to the Shoulder then it starts back up again...
View 3 Replies
I was at the pump getting gas. Left the engine running. Put in gas. Put the cap back. Checked to make sure it was tight. Got back in the car to find that the engine had stalled. I thought maybe just a fluke. Then it happened again a few days later. Same situation. Last night I was sitting at idle (not at the filling station) and same thing. The engine is not running rough --nor is the idle. I seems to take around 5 minutes or so before stalling. It starts right back up no problem. I had a dealer tune-up about 2 months ago. Replaced spark plugs, plug wires, coil, PCV valve, etc. It cost a small fortune. Why this is happening? 2013 VW Jetta 2.0 ....
View 10 Replies
Twice now in the past week, my 2001 Jetta has become possessed. While driving along, the radio turns off. Then the warning lights all come on. If I use the turn signal the radio springs back to life and other weird electrical things happen. Eventually the car stalls. When I try to restart it, the warning lights all come on and the dashboard makes a click-click-clicking sound, and that's it. The first time, my mechanic said the alternator wasn't working correctly, but that he revved the engine and it kicked in. He then tested the alternator and battery and said both were ok. Is this an alternator problem? Something else?
View 2 Replies
We have a 2004 Jetta with about 92,000 miles on it. We bought it used in October 2012 after 3 months needed rebuilt transmission, and many other problems but the most recent has been costly with no mechanic being able to repair. These are some of the problems that we are faced with. While in drive the vehicle feels like its gonna stall but starts to beep the clock resets and car continues to drive with no problems or the car won't start at all.
You open the car door no keys are in the ignition but the car is clicking and clock and miles are fading in and out, light on door panel blinking, you push flashers and it makes a strange noise but flashers are not blinking. You put key in and try to start the car and nothing the blinking and clicking stop and it does nothing turn key back in off position clicking and blinking start again.
Car just stalls when approaching stop signs. No mechanic has been able to fix problem or duplicate issues. I do have video of the interior clicking and flashing and noises it makes.
View 6 Replies
I have a 2006 Jetta with a 5 speed manual transmission and 35,000 miles. The engine randomly misfires causing it to stutter or stammer. The check engine light is on and has been for several weeks. Occasionally the check engine light flashes. I took it to a local mechanic who ran a series of diagnostic tests (no vacuum leaks) and they recommended having all the ignition coils replaced for all 4 cylinders. They also replaced the fuel filter. I did so but the problem soon returned to which they referred me to the dealer.
I decided to take it to a VW specialist in town and they replaced the spark plugs for all 4 cylinders. They noticed that some of the plugs were black with a buildup and some were clean. The problem soon returned. The VW specialist also recommended that I take it to the dealership as they too had no clear idea as to what the problem is.
The car did suffer rodent damage in 2007 but was still under warranty so all the wiring that had been chewed on was replaced. I experimented using premium gas and regular gas. Premium gas seems to make the problem worse. Also, the misfires seem to lessen as the weather gets warmer. I would like to fix the problem to avoid any catastrophic failure but am trying to avoid throwing money away on any more guess work.
View 7 Replies
1995 vw Jetta 110K miles.. My car has a hard time starting in the mornings or when it sits idly for a while (when I park overnight) . On any bright and sunny day, it's like the car is brand new - starts with no problems at all. Tried several mechanics and none of them have been able to diagnose the problem. To make it simple, cold outside - car will not start, warm/hot outside car will start.
View 3 Replies
My Jetta runs great in the summer and all seasons around town... the temp stays around 195 or so, the heater works ok, etc. When I get on the interstate however (now that the temp has dropped) , the story changes. The temp gauge falls below 150 and the heater gets cold. I assumed the thermostat was stuck open, so I replaced it but it didn't solve the problem. I called a local dealer and on his recommendation, I replaced the Engine Coolant Temperature (ECT) Sensor. That also didn't solve the problem. I have had cars overheat in the past, but never one that overcooled! Wy my car cools too well at highway spheeds? It affects my gas mileage and makes for an uncomfortable ride on cold days!
View 12 Replies
have had many problems with my 2003 Accent. I am not a mechanic, but I suspect the problems are related. My engine sometimes stalls when I sit at a red light. I drive about twenty miles to work. On a good day it will just sputter occasionally. On a bad day it will stall as many as three times. It also frequently "skips" a little while driving. It's like a split second hiccup in engine power.
I also used to have a really hard time filling the gas tank. It would take about fifteen minutes when close to empty. I have had it worked on three times over the past three weeks. First they replaced the timing belt (which I already knew needed to be replaced). Then they replaced something called a charcoal canister and blew out all the vapor vents(?) ( Again, I am not a mechanic). After that the car ran ok for about two days, and I can now fill the tank in about two minutes. But, it began stalling again, just as bad as before. So, they replaced something called a MAP sensor (MAFF?).
It has been a couple of days and the car hasn't stalled . . . yet. However, it still skips occasionally while driving, and my engine light has come on again. The mechanic says the code has something to do with a barometric pressure problem. what might be wrong with it?
View 2 Replies
No AC... Its not the fuse box on top of the battery, I recently already changed that. The air coming out is not cold at all, so I checked the pressure, and it was even higher then it was supposed to. After letting some pressure out, still no cold air. What could the issue be? Should I maybe bleed the system?
Also, its a 2001 GLX so I have climatronic....
View 4 Replies
I have a 2003 Camry 3.0l v6. Stalls at lights random.
Currently the car stalls at stops but this doesn't happen all the time it can go a month in between the problem occurring its very random. While sitting at a light the rpms drop and then it revs up and cycles like that for quite a while. This will also occur while cruising at a low speed while I'm just coasting the rpms will go up and down. I can compensate while stopped by power braking and keeping it at its normal idling rpm. I have no check engine lights and can't seem to determine what would be causing this issue.
View 5 Replies
2001 Excursion 7.3 - stalls randomly, sometimes will not start. After the IPR was replaced it was rough for about 4 miles (I thought maybe air in the system), next 40 miles was flawless with 3 stops and restarts. Then it sat for a few hours and I went to leave again and the problem was off and on again for another 5 mile drive. Now it won't start in the driveway. It will start if I disconnect the ICP but the idle is still a little rough.
I replaced the normal culprits after a lot of searching on here:
CPS - replaced with autozone part, thought maybe it was bad new so went to ford and replaced with official part from the dealer
ICP - had oil in the plug and it would idle better removed so I replaced the plug and as much wire as I could - soldered, heat shrunk, good connections - both the pigtail and sensor came from Ford dealer
IPR - replaced with part from the Ford Dealer (FYI - 1 1/8" 1/2" drive craftsman deep socket from sears fit in the ratchet and on the part).
Grounds - found somewhere that the ground on the firewall for the windshield wipers can interfere with the CPS so I pulled it, clean the connections and made sure it was tight and secure.
No check engine light now - I received a few through the process, but did not clear them and there are no codes at this time (self cleared on the 40 mile drive)
I'm thinking it may be some electrical issue/short or a fuel issue at this point, bowl is full and the filter is fairly new (few thousand miles). I haven't done the Hutch mod, but have over 1/2 a tank.
I'm trying to get this going as quick as I can so I don't want to waste too much time, but I also don't want to miss a critical troubleshooting step to take.
Below are my thoughts on the next steps.
Research and test fuel pressure
Tow it somewhere to test each injector - I only have Torque pro to read codes and engine status
If fuel delivery checks out ok, start testing wire by wire on all of the above parts.
View 14 Replies
When the weather gets cold, (lower than 45 deg. F) my Jetta does not want to stay running. It turns over and starts just fine but it does not like to stay on. When I turn the key to the #2 position I can hear the fuel pump fire up and pressurize the system. I always attempt to start it after that, and after 1-2 seconds of running, it seems like it chokes itself out. I have the new coolant temp. sensor (green top), my MAF has been replaced, all spark plugs are new with the correct gap (approx. .030"), new air filter, I run 93 octane fuel.
The worst part is, once the car is warmed up (After forcing it fuel and starting it over, and over, and over again) it runs awesome! I have had this problem since I bought the car (about 2 years ago). The owner told me about it and mentioned that he has never been able to figure it out either (trips to the dealer included). I have been dealing with it for 2 years, but it is getting much worse. Over the past 2 days I have not been able to get my car to stay on long enough to get it to move.
View 2 Replies
2003 NISSAN Xterra
Problem started a couple of days ago. While driving the car normally it suddenly stopped. I was able to restart it but it turned off again 60 seconds later. This has gone on with the engine running from 10 minutes to 10 seconds. The battery terminals and all cables are clean. Distributor cap and rotors have been cleaned. Fuel pump replaced last night. I still get the problem. Error codes listed were: P0328 - Pre Detonation (knock sensor) Bank 1 causes could be restricted fuel - over temp engine. Now this error has been coming up for five years and I've replaced the sensor numerous times. P0732 - Gear 2 Incorrect RatioP0102 - Mass Air Flow Low InputP1148 - Closed Loop Control Function, BANK 1P0420 - Catalytic Convertor, BANK 1P0134 - O2 Sensor No Activity, BANK 1
Regarding Fuel Starvation - NOPE, Engine Too Hot (it wasn't), Second Gear Not Within Ratio (never had gear problems), Knock Sensor and most error codes have been related to bank one. Error codes on car computer were erased and engine is still hesitating slightly and stopping. Just checked Mass Airflow Sensor and it looks clean.
View 8 Replies
