Toyota - RAV4 :: 1997 - Headlight Assembly On Both Sides Is Loose
Mar 17, 2013
Several weeks ago someone backed into my '97 RAV4 in a parking lot. Body shop charged around $900 for the repair (estimate indicates labor for both headlights, but doesn't look like they replaced them). This afternoon one of the low beam headlights burned out. I went to change both sides just to be safe. On both headlight assemblies, grasping the wire assemblies to the low beam bulbs, the headlight assembly on both the left and right side is loose within its housing. I've changed the bulbs in the past, this is something new. Take it back to the body shop? What happened????
View 7 Replies
Advertisement
I have a broken headlight adjuster assembly, it's a steel bolt with a Plastic nut on it, the Star piece behind the nut is broken. What is the source for this part ?? A Ford part number????
View 4 Replies
My 97 Rav4 shut down on the highway yesterday. Checked the oil when I lifted the hood. It has only been 4500 since the last oil change, but the oil was barely registering on the stick. The engine will turn over, but will not start. Do Toyotas have an auto shut off mechanism when the oil gets too low or is my Rav4 toast? There were no warnings, temperature, low oil light, nothing.
View 15 Replies
I have a 1997 Toyota RAV4 with 137,500. I got it in 2004 with 93,000 miles. Since I've had it, it burns about 1 quart of oil every 1,000 miles or so. I don't think it's been getting worse since I've had it. I had the compression in the cylinders checked last year, and the compression's good in all four of them. What the problem might be? It the problem worth repairing, or should I just keep adding a quart of oil every 1,000 miles? Also, does burning oil damage other parts of the car?
View 5 Replies
My wife’s ’97 RAV4 has 135,000 miles on it. Two days ago it started bucking/hesitating (feels more like bucking, and its worse if you try to give it the gas) at speeds below 25 -30 mph. No loss of speed/power when going uphill. Its worse when the engine is cold.
I cleaned the throttle body with spray cleaner, no change. I added Prestone fuel system cleaner to the gas and have driven 20 miles since then. Very little if any change so far. I always use good gas (Chevron regular) and the car has been well maintained (primarily by me).
Timing belt, seals and both bearings were replaced two years ago. Just about a year ago I changed the plugs, air filter, distributor cap and rotor. The fuel filter has never been changed, and the spark plug wires have never been changed. What I can try next? Where is the fuel filter located? I have the Toyota repair manual. It shows a pic of the filter, but not where its located. I have one ready to install if that could be the problem.
View 12 Replies
1997 Rav4 with 185k miles burns some oil. I replaced the PCV valve thinking that may be the issue. That seemed to stop the visible smoke at a cold startup but alas, the problem still persists. We bought the car for a song at 180k so I don't feel I'm out much. The previous owner took incredible care of the car so it is solid in most areas.
I did learn the previous owner followed a dealer recommend oil change interval and changed the filter with every other oil change so this may explain some things.
My real question, if the engine does need a refresh, what is the best option? I've not at all afraid of tackling a major overhaul myself and, in the past, have had pretty good luck with aftermarket rebuilt short blocks. But that was years ago. The dealer cost for a crate motor is outrageous and not justified for a '97 anyway. So at this point, I'm just looking for some advice from others who may have been down this road. Again, the rest of the car is solid and we don't have much money in it at this point so would like to keep it as our 'second' car for awhile.
View 30 Replies
Two years ago a mechanic told me that my rear differential mount was broken - hitting the floor board. He told me this was not dangerous - just annoying. This is a car I rarely use but now considering using more. It currently has 170000 miles on it driven in the mild climate of California. Just what is involved and what should the cost range be?
View 2 Replies
I have a 1997 Toyota Rav4. 2nd owner. No accidents. Regularly maintained at a mechanic. No issues until this one. I searched the forums looking for an answer, seen similar but not exactly my issue. The car has an intermittent starting problem. This never happens in the morning. It only happens when the car is driven a short distance. When the key is turned to start the car, the engine does not crank. All the electrical comes on. We had the starter rebuilt. I have had it towed to my mechanic five times. Each time, when it is unloaded from the tow truck, it starts right up. We have left it there overnight and all day. They cannot replicate the problem. I drove the car to a friend's house 1 mile from mine and it would not start for 24 hours so I had it towed to the mechanic. Again once it was unloaded it started right up. A couple months ago we did a major service with a timing chain/belt. It did not happen for a couple months. Now twice in a week it has happened. My mechanic will not do anything more until it fails completely.
View 2 Replies
I recently purchased a 1997 Rav4 (3F-SE Engine) with 162000 miles. Overall, it is a great car. The only problem (besides a clutch, which can wait) is that it hesitates/bucks between 1500-2100 rpm while accelerating. This happens usually on a shift change from 1st to 2nd, or while in 2nd and after decelerating to make a turn. This only happens after the engine has warmed up, i.e. the temp gauge is above 25%. When cold, there is no hesitation at all. It just passed emissions testing. Check engine light is off. I recently replaced the TPS (and adjusted it properly), with no change in symptoms. This car does not have a MAF sensor.
View 8 Replies
On the way home yesterday I was caught in a deluge. I ended up having to go through one spot where the water was pooled, but not really that deep. Anyways, 45 minutes later I arrive home, park the car, and 15 minutes later the car horn starts blowing constantly. This went on for several minutes, stopped and started a few times, then eventually stopped. Nothing I tried would make it stop, it just eventually stopped on its own. So as not to wake the neighbors last night I pulled the fuse to the horn. With the fuse back in, the horn still works, what caused the problem?
View 5 Replies
I had the timing belt, water pump and thermostat replaced on my '97 RAV4. The next morning while braking at a red light I heard a rapidly repeating sound that sounded like metal on metal. The car never made that sound again but now I'm hearing a noise coming from the passenger side of the engine (timing belt side). When the engine is cold I don't hear it. After driving a while its starts, then once the engine warms up it generally goes away (except for this morning which was the coldest morning since this started, temps in the 40s).
I was only hearing the noise when the car was stopped either in drive or reverse (reverse sounded louder) if I lightly let up on the brake pedal (there's no pulsing in the brake pedal). Once under way the sound goes away. This morning it was making the sound virtually every time I came to a stop (once the car warmed up) even with my foot firmly on the brake pedal. I recorded the sound Saturday while standing still with the car in drive and my foot slightly easing up on the brake pedal. The sound starts at the 20:30 mark, what it could be?
View 10 Replies
Today I happen to notice that both sides of my running board rear light is loose. Tried a bit and did not figure out how to put them back in place. Since both sides got loose, I guess it is a quite common issue?
View 4 Replies
I can see where there is a 1/4 inch post that if turned will push the assembly out, but i can only get it to come out about 1 inch. Is there something else that has to be released ?
View 2 Replies
My headlights suffered from the dreaded condensation problem. I brought them to Lexus after getting the warranty enhancement paperwork and had them replaced. Shortly after the passenger side wheel cover was ripped off after getting caught on some ice during a storm. It was very shortly after that that condensation begin appearing in my passenger side headlight.
At that point I was unaware that the wheel well cover had been ripped off. I brought it back to Lexus to have it looked at since I only had the headlight replaced a few weeks before. I was told it would be at a cost of $2,500 to replace with an additional $400 for the wheel well cover. Needless to say, I did not have the work done that day. While I was waiting them for them to finish the paperwork I bought the wheel well cover for $50 online but since then I've had difficulty locating the headlight.
I brought it to my mechanic and he was unable to find the headlight as well. I have a 2009 rx350 with HID AFS headlights. I have looked on ebay, Amazon and just through the internet to see what I could find but I'm finding only halogen headlights. Most of what I'm seeing on eBay are for non-adaptive lights that are damaged.
View 2 Replies
I'm trying to replace my dads 2007 Camry XLE japan built headlight assembly because his are insanely oxidized. Besides OEM's and CAPA's, what else are there? Any good aftermarket headlight assembly and achieve great results?
View 8 Replies
New owner of a 2000 Passat. The headlights are dingy on the inside and I would like to be able to clean them. How I can get to the inside of the headlight assembly? Can't stand the look of them like this!
View 13 Replies
I've removed 3 bolts ( Headlight assembly removal)and loosened the number cover to be gridlocked by something I cannot see or just a bit more friction than the amount of force I'm willing to give for fear of breaking something.
View 9 Replies
I am in need of replacing the passenger side Front Headlight assembly. I was wondering, how to assemble it outside of a repair shop. I was also looking to possibly get the part number so I can make sure I am purchasing the correct product for my 2012 VW Passat SE.
View 8 Replies
The drivers side headlight assembly on my 2008 Prius has moisture in it. I have 52,000 miles on the car, so I do not think it is covered under warranty. What / how can you replace the headlight assembly?
View 7 Replies
Is it hard to remove the headlamp assembly. I am only asking because i am considering purchasing smoked/blackened headlamps and tailights on ebay.
View 14 Replies
I have a 2001 Excursion and I need to replace my headlight assembly. What is the difficulty level of replacement? Any recommended assembly they would suggest that throws out some great light?
View 14 Replies
