Sonata I45 (YF - 2011+) :: Gas Fumes Smell In The Cabin
Jan 6, 2015
Well I started smelling Gas fumes in the cabin of my 11 GLS. The smell was intermittent for about a month now. Then last weekend it started getting bad. I found it only smelled when pulling fresh air through the HVAC, so it had to be under the hood. Pulled the engine cover to find the foam backing was soaked with gas. Started the car and could see the Hard fuel line dripping.
I saw from other post on the forum that this tube has one time use fitting on both ends and that a special tool is needed to torque the fittings. Dropped it off at the dealer yesterday and they are replacing the line today.
I tell you all this because the Dealer said that their records show my car had the short block replaced at 24000 miles. When replaced they probably didn't torque the line correctly causing it to leak.
The question I have is, Should I be more or less worried about the bottom end of this engine now that I know it has been replaced? The car has 44000 miles on it now.
View 11 Replies
Advertisement
After I start the car, warm up a bit then drive, there are exhaust fumes that get into the cabin as you can smell them.
It's happening more often now. I have spoken to my Phaeton tech who said that the car has a sensor that goes off and shuts down external air if it notices exhaust uses getting in.
I have been hearing a little bit of road noise on the driver side so I'm thinking some fumes are coming in from the door seal (although it looks fine).
Sometimes it's bad enough that you have to open the windows or you will feel sick. It passes within 5 minutes or so and the car is fine after that. It only happens right after ignition for a few minutes.
View 10 Replies
I have a 2010 with 5k miles - bought <4 mos.
Last week, I started noticing a petroleum smell in the cabin. I've also had trouble with the inside windshield. When I tried it wipe it, it just smeared. Finally, I used some cleanser and it's clear. It took several applications to work.
I read in the Gen II forums about a loose oil filter cap. I checked mine today. I was able to turn it about 1/2 inch. Now, I'm getting headaches after I drive for more than 15 minutes or so. I've tried switching the circulation but I can't tell which way is better.
View 1 Replies
Filled up with gas recently and afterward I have a distinct gas smell in the cabin and trunk. I see the 2011 Sonata has an issue with this. Apparently a pcv valve hose problem. The car is a GL. I did not overfill the tank and the cap is on tight. Has the pcv hose issue been fixed with the 2012 model? Are there other possible issues that could cause this? Plan to call the dealer tomorrow.
View 4 Replies
I have a 2000 Ford Focus ZTS with about 135,000 miles on it with a fume problem. Once it's warm, I'm noticing what smells like exhaust fumes in the cabin when stopped or at low speed (not at highway speed.) It runs perfectly otherwise. I took it in a few months ago (before I noticed the correlation with engine temp), and the mechanic could not replicate the problem, and he said there was no exhaust leak, I now suspect this is because he only tested it cold.
View 4 Replies
Why when I come to a stop with the heater on, the car smells like exhaust? I took in into our local Subaru shop and they couldn't find anything wrong. When I'm driving it's fine, but in town or in traffic, I have to keep shutting off the heater. If I forget, the car fills up fumes and I have to drive with the windows down or my daughter's asthma flares up.
View 14 Replies
How do you fix the musty smell from the cabin airbox when it is always on recirculate and must be wet inside? I have a 2011 Camry.
View 6 Replies
Car: 2007 2.4L Hyundai Sonata 76k miles
Problem: All of a sudden my car has developed an intermittent smoky smell in the cabin (I'm NOT a smoker). There are no check engine lights on and the car is running fine. The smell is not the classic "hot engine block" smell of the car overheating (which it is not according to the gauge). The smell I am getting is a hot smoky smell, doesn't smell like rubber either. No visible smoke in the cabin or the engine compartment.
Smell usually shows up after driving the car for around 2 minutes, but can vary and sometime not show up at all. The only thing that I can comment is a chirping sound from the pulleys that seems to be associated with humidity (power steering, radiator, etc) and the A/C blower intermittently not working (have not had any issues in past 3 months). How I can diagnose this?
View 17 Replies
I have a 1996 Volvo 960 station wagon which I love dearly. It's been a wonderful car, however something new has occurred that has me quite concerned. Whenever I turn on the heater, I smell gas fumes. This doesn't occur when the A/C is working or when I turn the temperature dial beyond the numbers to the red mark. I understand this is a different heat source than the regular heater. When I took my car in to the dealer for its 150,000 miles checkup I told them about this problem. They experienced it, but couldn't find the source of the challenge. They want me to bring it in again and keep it overnight so they have a lot of time to decipher the source of the problem.
View 1 Replies
My mom has a 2000 Passat 1.8T Sedan. For the last six months the car has the distinct smell of engine fumes in the cabin. The smell becomes more prevalent whenever the fan is running (A/C or not). She has constantly been back and forth to the dealer but to no avail. The smell is there are idle or just driving around and requires a window to be opened for fear of passing out.
View 1 Replies
I am getting fumes in my 1990 4Runner SR5 6 cyl. I believe them to be exhaust or oil burning, not fuel. The condition does NOT exist when the windows are closed or when the fresh air vent is open or closed (recirculate).The fumes exist in the cab only when I open a window (driver side), and is mitigated some when I open the fresh air vent. This may mean that the leak is not coming through the ventilation system. What could be causing this?My mechanic says it is worn valve cover gaskets, dripping oil onto exhaust system and finding its way into the cab, it does leak oil. This may be true, but how are the fumes getting into the cabin the first place? The fumes came on suddenly, after a rear window repair at the shop - unrelated?The vehicle has been inspected by a muffler shop, no issues with the exhaust or manifold system.The fumes are inscrutable, not strong enough to easily detect, but persistent exposure gives me a headache and dizzy feeling, and then I get polluted enough, that I cannot really smell it anymore, hard to trouble shoot.Interior smells of exhaust, even when parked.?
View 4 Replies
Our prius is 13 yrs old and the fan of the heat/ac broke. We had it replaced at the dealer and also had them replace the cabin airfilter. Since then, whenever we use the fan (heat or AC), we've been getting fumes in the car, a gas smell (even when there are no cars in front of us, so it's not from other cars). We brought it back to the dealer twice and they have not fixed it. They found a hole in the exhaust system and replaced the muffler etc. My questions:
1) Is there a way to measure the air quality in the cabin and find out what fumes are coming in and how dangerous they are?
2) What could it be and how can we finally get it fixed.
View 6 Replies
I have been getting exhaust in my car cabin since last fall. It is worst when I first start up the engine. Once I get driving, it's not so bad. Switching off the heat or recirculating the air does nothing to change things. I used a CO detector in the cabin and the alarm didn't go off, but it still worries me that I might be breathing in carbon monoxide. And none of the shops have been able to diagnose it, let alone fix it. The first shop installed a new 'flex pipe'. The dealer thinks it's coming from a gasket near the flex pipe. The exhaust manifold is not cracked. A muffler shop said there was no leak. Is it possible that exhaust is somehow getting mixed into the air via a faulty valve or vent?
View 6 Replies
Love the car; hate the noise. Very quiet up front, well-isolated engine and wind noise. Perhaps that is why I am hearing a bunch of road or tire noise from the REAR only. Noise varies somewhat with speed but it is driving me crazy. Somewhat muted with the stereo at volume level 12 (or higher). I have not been to the dealer yet but am wondering if something is NOT properly sealed or undercoated in the rear. I noticed the wheel wells are partially coated but mostly plastic. Plus, since this is a GLS, there is a large void in the underbody where the second muffler & associated hardware/piping goes on the SE. Not sure if the LIMITED model has additional sound deadening material but my GLS is too noisy.
View 42 Replies
I have been smelling raw exhaust in the cab, especially when the weather is colder and when standing still.
I took it to the dealer and in the process of fixing minor coolant and oil leaks on the turbo, they located a small exhaust leak with visible soot on the back side of the turbo.
They tell me that there is no way to repair it and that only Ford can rebuild or repair these turbos.
2011 SD 6.7
View 14 Replies
About two years ago, I noticed the smell of exhaust fumes in the cabin of my 2000 Honda Civic any time the vents were set to pull air from outside the cabin. Switching the vents to recirculate would prevent the fumes. Looking under the hood, I found the exhaust manifold was cracked, so I replaced it along with the catalyic converter (actually one piece in this model) and two O2 sensors. Since the replacement, the problem with exhaust fumes remains. I have asked my mechanic to look at this a couple of times, and he could not find the cause. What to try next to diagnose the problem. We use the car frequently, and just have to leave the vents set on recirculate. This becomes an issue on rainy, humid days when recirculate causes the windows to fog.
View 7 Replies
I have been having an issue with exhaust fumes in my 13 GT (16,000 miles on it). I am positive its from the exhaust. Its definitely the "rotten egg" smell, not raw gasoline. I don't hear any leaks though.
It only happens when going up a hill when the engine is under more load than usual or under heavy acceleration. I am going to call the dealer about it and have them look at it.
View 5 Replies
Looking for pics of how to change the cabin filter?
View 8 Replies
Newly acquired 2002 Accord.
At idle and while at a stop, the cabin receives a heavy dose of exhaust fumes (nope, not from the auto in front of me - I'm often alone at stop lights/signs)... what is the most likely culprit?
This did not seem to occur until AFTER I had the timing belt (package) replaced...coincidence
View 9 Replies
When I'm idling my car at a stop, I notice a slight vibrating through the car... The vibration could also be felt through the steering wheel.
Not a major issue. Tried pushing car into neutral to see if it made a difference... Nothing.
View 6 Replies
I recently acquired a 2014 Sonata Limited 2.4L. Don't know if its me or not but engine noise seems to be excessive in the cabin especially when I am accelerating from a very low speed, almost like something in the engine is loose. Had it at the dealership today for warranty work (seat belt) and recall work and asked the techs to take a listen when the do their inspection. They came back and said that the noise is coming from the electric fuel pump and that it is totally normal. Previous car I had was a 2011 Honda Accord Ex and it seamed quieter.
View 1 Replies
