Sonata I45 (YF - 2011+) :: Front Brake Clanking Noise?
Jul 27, 2014
Two months ago I started getting a clanking noise from the right front when I accelerated from a stop, or stopped and moved the car backwards from forwards or vice versa. I pulled the wheel and noticed pretty work brake pads, with the inboard pad completely shot. Car has 34k miles. The left side inboards and outboards were about 50% worn and were worn evenly. Sure enough, I had a sticking lower slide pin on the right. I cleaned everything up and lubed all contact points, and replaced pads and clips. I removed, cleaned and re-lubed all slide pins and holes with the appropriate silicone brake lube, and confirmed that they are siding freely. The problem is that this worked, but did not completely eliminate the problem. The noise still happens about 1 out of every 5-10 starts once the car starts to roll after the brake pedal is released. The rim seems to rotate ok when jacked up and I am not getting a pull. A mechanic buddy of mine said that in these cases he just ends up replacing the whole caliper.
View 9 Replies
Advertisement
Just got a 2012 Limited 2.0T about 3 weeks ago. Didn't notice until last week that there is a noise coming from drivers front tire area at low speed (15-20mph). It sounds like a thin piece a metal is getting snagged and then snapping back into place. Took it back to Hyundai and they pulled the wheel and said everything looks fine and that it's due to new brakes needing to "wear in". At the time it was very limited when you would hear it, in the past week it's increased to an almost constant noise until I get over 20mph. I've searched and can't find anything dealing with this particular noise, what exactly I should look for when I pull everything apart? I'm more inclined to try and fix myself than believe the dealer. I can't seem to isolate it to a particular thing when driving, it does it on turns, going straight, stopping, accelerating.
View 9 Replies
My Sonata suddenly started having front right brake sticking issue. It will happen only after an extended distance of frequent drive & stop. Something like Houston daily ride. So, after the traffic jam mysteriously clear and you can get some speed, starting at 40MPH a high grinding noise from the front (Ceramic brake pads) and the car feels very heavy. The sticking phenomenon will disappear if you wait a little with avoiding using the brakes.
I am going to check it today. So far I know that the sliding pins are not the issue. I recently cleaned them and lubricated them. The front right brake will get hot while the left are just in normal temperature. The brake pedal is getting higher while the sticking is about to happen and happening.
My first guess is the Flexible brake hose. Or maybe a bad caliper. I think if the master cylinder was the issue, I might have more than one sticking brake wheel. I don't know how common it is to have a bad ABS unit causing this issue. It feels really like a build up pressure caused by a valve effect of interior deteriorated brake hose.
View 26 Replies
So I always have the radio on so I rarely hear subtle noise like this, but lately I have tried to track down this noise I have been hearing.
Every time I back out of my garage, I would obviously have it from Park to Reverse...when I put it in D from R....there is clunking noise right after the first gear...
It goes first gear, than this clanking noise then 2nd gear....It almost sounds like a motor mount? I hope its something not too bad as a mount.
It only happens when engine is cold and it seems to only happen that one time I go from 1 to 2 right after R..
It's sound like a grinding metal but real quick...like something crushing.
I have done ATF flush at 30, 60, and 90; the 90k was done just about two months ago.
View 4 Replies
My 2.4L engine is making a clanking noise while running. When I checked the oil level today, it was low by about 1.5 quarts. There's no check engine light.
Car has 74K miles now. I purchased the car two years ago with 35K miles. I have always performed regular maintenance myself. The car had its oil control valve replaced at 55K miles.
VIDEO : 2.4L Clanking Noise
View 12 Replies
I changed my tires, brakes and rotors last August. I had installed EBC YellowStuff. I also greased(using SilGlyde) the slide pins and bled the brakes.
Last weekend, my car was making a weird noise when I hit the brake, so I removed the front tires and noticed that the front passenger side outer brake pad was completely gone and the inner brake pad still had 25% life left, but it was tapered(image attached).
I know when this happens, usually it means that the slide pins need to be greased, but they were plenty greased from my last year's brake change. I still greased them, but now I hear grinding noise frequently(not all the time) when I am accelerating at slow speed and sometimes at even high speeds.
There is no fluid leaking and I could only see surface rust on the pistons. Its driving me crazy, because I can't figure out what it is. I am thinking of just replacing the slide pins anyway to be on the safe side.
View 17 Replies
My brake booster is making noise for a few months now. It works ok and brakes are strong but the noise is there. Any way to quiet it down? Or how much the replacement might cost?
View 1 Replies
I have a 2012 sonata that has issues from day one. ?
New issue is: For a couple days now I've noticed a crackle noise when I break. It is only when I am coming to a complete stop that the noise happens, not the full time i actually have foot on break.
Not thinking it is the bearings. Thinking it may be something within my suspension.
View 3 Replies
From day one my 2011 Sonata Limited left front suspension has been very noisy especially over road reflectors or other abrupt irregularities in the road surface at slow speeds. I've always felt I had a bad strut or strut mount but I believe it's the ball socket in the front sway bar end link. Has to replace these to remove a knocking sound and had it go away afterwards? I test drove a 2013 Limited and it was solid and noise free over the same surfaces so I know something isn't right. I also see no aftermarket kits for these. I find the rear ones but not the front.
View 19 Replies
We bought a 2014 hyundai sonata on 28th of october. every thing worked fine. When we test drove we didn't notice the road noise. but yesterday we did notice it and it is unbearable. it sounds like it is coming from the front. I called the dealer and told them this is too much. We asked if we could return the car. we only had it 3 days. The dealer says he can fix it. We think it is a design problem. We just sold our 2009 sonata which was a very good car.
View 24 Replies
While the emergency brake was set, I happend to lean against the rear driver side of the the car and was surprised to hear a clanking, slapping noise coming from underneath the rear of the car; seemingly near the left rear wheel. What I think I'm hearing is the emergency brake cable (I assume this is a rear wheel cable brake) slapping against the vehicle frame or wheel axle. Even opening and closing the rear passenger door caused the cable to slap against the car.
This got me to experiment a bit, so I rocked the car back and forth and side to side. It's the side-to-side movement that causes the noise. The emergency brake works when set. The noise disappears when I release the emergency brake.
View 1 Replies
So I noticed a few months ago that a clanking noise came from the front of my GLI when I hit bumps. This noise went away if I had my foot on the brake, so enough vortex searches came up with loose caliper carrier pins.
I ordered the brake stiffening kit last month, but have yet to install it. Now just the other day, I heard this crazy noise come from my brakes entering my garage. It was like a loud 'click" when I engaged the brakes hard enough and I could repeat it many times. I know, I am silly for not getting the kit installed sooner, but I want to make sure that this 'click' is likely related to the carrier pins before I go taking the brakes apart in my garage.
I only ask because my car has 95k on it and is possibly on original suspension, so bushings and mounts might be starting to go.
View 3 Replies
I just had some H&R springs installed and my front suspension is making a funny noise.
It sounds like the front springs are clanking around..
View 2 Replies
I am experiencing a front passenger area body creak noise and recently found a TSB to get it fixed. How much it might cost be to get it done at the dealership or anywhere else?
View 1 Replies
So about a month ago my 2013 Sonata GLS started to make some clunking noise going over the littlest bumps over the road from the front end on both right and left side.
I brought it to one mechanic and they said the rack and pinion needs replacing which is an expensive fix. I couldn't believe that was the problem as I had no leaks and it was on their solid. I ended up taking it to my uncles mechanic and he stated its the stabilizer links on the front right and front left wheels. My way to work has a lot of bad pot holes... so I'm hoping that the stabilizers are actually the problem.
Anyways, tomorrow I will be bringing it to the mechanic to have them both changed. I know a lot have been complaining about this issue and instead of replacing the rack and pinion, I thought I'd try and see if it actually is the stabilizer links and provide a fix for some of the sonata owners on here.
View 28 Replies
I've got a noise in the front end of my GLS (52K miles). It's kind of hard to make it happen, but I hear it 2-3 times a day. It doesn't usually happen hitting a bump, but is usually heard when the weight of the vehicle shifts, when there's a sudden incline or drop, like when pulling into a driveway or gas station.
I had a car with a motor mount issue once, which sounded similar. However, I actually had my motor swapped 5K ago, and my noise existed before that.
I have to get to the dealer (I believe 60K is the end of coverage for this kind of thing). I would like to have a little more info or suggestion of what to check, otherwise it will be "we don't hear anything."
View 5 Replies
Layely with my 2011 SE I've been getting a low pitch humming noise while traveling at low speeds, mainly going into a stop sign or light and searching for a parking spot. It happens with the AC off as well, not so much a vibration just a low pitch hum, also does it with foot off brake too as I just let it coast. Kind of annoying and want to make sure its good.
View 5 Replies
Heard wicked vibration from front of car (almost like I hit something and it jammed under car) pulled over to realize sound was still there when stopped. after a few seconds realized it was the fan running (on setting 4) now a couple days later sound isn't as bad but still vibrating, doesn't matter where it's blowing (feet, chest, windshield). I bought sonata 20 months ago and has just under 23000 miles...
View 8 Replies
I just got a new Sonata and I find the car has a noise like bad wheel bearings in front, it sounds like driving on really rough pavement.. I have changed the tires and still get this..
View 1 Replies
I just put on some new wheels and tires (19" VMR RS4 reps) and there is a weird clanking noise coming from the front left wheel when I am going around 10 mph. It doesn't happen when I'm moving faster, but I have checked it out and don't see anything rubbing or hitting any metal pieces. Could it be the suspension or something else? I haven't heard it around any of the other wheels.
View 12 Replies
My husband and I almost bought a used 14 sonata SE last night, but it was contingent on the dealer fixing the clicking or pinging noise going on under the passenger front door. It was going on during the test drive and continued after the car was turned off. The car has 7,000 miles on it. So the dealer took it to a hyundai dealer this morning to have it repaired under warranty, and the hyundai dealer said its a normal new car noise and will work itself out with time - but there's nothing to repair.
I'm aware that sometimes exhaust systems or heat shields ping a few times when the car is turned off? Did it eventually stop? And when? It really is annoying. I'd like to get this car, but he refuses to buy it if it's making this noise.
View 8 Replies
