Sierra :: 1992 GMC Truck Fuel Pump Went Out
Apr 8, 2009
I have a 1992 GMC step side, short bed, 350 engine, Sierra, auto trans, factory air, factory exhaust, power steering.......
Three years ago the fuel pump went out. I have to work alone so I lowered the tank after draining and went through a lot of agony with floor jacks, supports, etc. but finally got the job done in 3 days.
The replacement was a Bosch fuel pump.
It went out today while I was at Sams stores. I got a pull home and it is in my driveway.
It started up once I got it home, but that is what it did the last time it went out, 3 years ago.
Question...should I check the ground first to make sure it is not getting intermittant ground or just do the job with a new pump?
Also, can I do this job by raising or sliding the bed after I unbolt it? I have heard war stories but no actual person that has done it.
Also, when moving the bed either up or sliding it back, isn't there a concern about wires that go to the tail lights?
I cannot afford the 500 dollar shop fee to have it towed and fixed.
View 6 Replies
Advertisement
I have inherited a 1992 Ford Ranger 4.0 with an unusual problem. When the temp drops outside the truck will not crank. The relay is coming on for a sec or 2 to bring the system up to pressure but the pump never turns on. This happens every time the outside temp drops below 60. I can wait until later in the day or until a warm day, hit the key and drive it till it runs out of gas. A week later (and another cold front) and it is sitting dead in the front yard. I have traced the grounds, checked the power thru the relay (and replaced the relay too), but it still does this. What I want to know is am I the only one to ever run into this and if not then what is causing it. Pump shows no sings of trouble on a 70 degree day, even runs the proper pressure and volumes. I am stumped at this point and I am ready to try replacing the pump (though the one in it looks brand new). comments?
View 11 Replies
I have a 92 caprice 5.7. Vehicle had suddenly stopped ... Providing fuel to the tbi. I immediately checked relays etc all were good. Then I figured it had to be the pump because I didn't hear the whirl of the pump with the key forward engine not cranking. I replaced the fuel pump. Still same problem no fuel. I found the 20 amp fuse blown that sits next to the 2 relays. I replace the fuse then the fuel pump got energized as I cranked the engine it almost started but then the fuse blew again. I have a short in the circuit I believe. I don't have a wiring diagram,what else is on the fuel pump circuit so I can have a direction to start in to find a probable bad wire.
View 3 Replies
My 92 F250 5.8 won't start but fuel pump runs all the time the key is on. Some times it runs. But has no power and check engine light is on.. But I cant get it to flash codes, only steady light on.. It did this before then ran good. Now back to no start.. I checked grounds and relays ..
View 2 Replies
My 1992 3.0L V6 is showing it's age. My 4Runner problem is getting worse by the day. It started the day after I bought it. My truck won't accelerate with the RPMs over 3k. My truck smells like fuel. The fuel filter is 3k miles new. I can't get it to start like it used to now. It will take me at least three cranks for it to turn over. The battery is new too... less than one year old.
View 6 Replies
Truck quit running yesterday suddenly and unexpectedly. It sputtered briefly and the motor total quit running. I pulled over and tried to start and it briefly fired but then totally quit. Got towed home. And now testing to see what all to repair..Thinking fuel.
I don't get any codes from the tester with KOEO..just the good to go etc..no codes or the good to go 111..etc. Guess this problem can't be identified without motor running.
My wiring diagram doesn't give me all for my Calif car..I don't see where the relay is but my fuses are all good, and I'm getting voltage when I crank the motor at that inside firewall switch on both its wires(incoming/outgoing)..forget what its called..Inertia Switch?..that will shut off fuel pump during accident or impact etc. And I've read that this switch is upstream of the relay(if I read that post correctly) so guessing it's the pump itself that is bad.
Does that sound right? Should I go ahead and pull the fuel tank etc and replace the pump? Or is there more testing I should do? When I turn the ignition key on..the pump makes zero sound. That's not the way it normally operates. Usually with the key on the fuel pump comes on momentarily and I can hear it. Forget how to drain the fuel tank etc..I don't see a drain plug? I did it once many years ago..but forget how?
View 7 Replies
We have a '92 Pontiac Trans Sport with a 3.1L V6 TBI engine. Last Sunday evening it refused to start like someone left the transmission in Drive and the Park/Neutral switch was preventing it to start. There's the buzz sound from the fuel pump when you put the key on then nothing when you turn it to start the engine.
I checked the Park/Neutral swith by connecting an ALDL cable to the OBD port and it indicates correctly when I move the lever to Drive or Parking/Neutral. The only error code stored is "Fuel Pump Relay" but the Fuel Pump appear to be working?!
Battery is good, fuel pump fuse intact and the Park/Neutral switch appear to be working. How we can tackle this problem?
View 12 Replies
I have a 92 f150 w 302 . My front tank leaks out of the gas cap and builds up pressure. Even though I have never put fuel in it (owned it 7 mos). I siphon fuel out of it weekly. If I switch from rear to front. The truck stalls out.
View 1 Replies
Im looking to upgrade my radio and speaker system in my car but I do not want to lose my steering wheel controls.
View 1 Replies
I have a 92 gmc with a standard transmission that is backfiring and sputtering after it has been running for a while. I have noticed that on longer trips, 30+ miles, the truck backfires when i go to accelerate on the highway. Also, after it has been running a while, I will stop at a light, When I go to accelerate, It backfires and tries to stall but wont. I have to turn the key off and wait for the truck to shut off.
Once it shuts off, I will restart it and then it runs normal till the next light.. I have replaced the plugs recently, thinking that it was a misfire problem. All the plugs looked normal. None were dirtier than the rest. It only does this after it has been running for a long distance. If it is cold, it does not have a problem. I have also tried seafoam in the tank and direct into the carb. I am at a loss? the temp gauge never gets hot?
View 2 Replies
My brothers 2002 F150 4.6l has a starting problem of when he shuts it off it will be hard to start sometimes. If he lets it sit for a while it will start right up. I did a search a looks like the fuel pump modules are subject in these trucks. The search also have them mounted on a cross member by the spare tire, this truck does not. My question is where is the fuel module located on the truck?
View 1 Replies
Several years ago I had to replace the fuel pump - truck had about 100,000 miles. Within the last 4 - 5 months I have replaced the fuel pump twice and just today (about two months since the last replacement), the fuel pump has failed again. That has been the pattern now for the last several months. I have had the work done by one of the reputable car repair shops in town - they have also done work on my 2004 Impala with no issues with the repair. There must be something else going on besides just the fuel pump going bad. What would cause so many fuel pump failures.
View 16 Replies
How do you test the fuel pump regulator, the truck wont start. I tested the schrader valve and it does have pressure but didn't seem like much. (need a gauge) I replaced fuel pump a few years ago so was wondering about the regulator. Is there a test procedure?
View 7 Replies
I have a 92 and the transmission has started acting up. When I put it in gear it sits for about 5 to 10 seconds before engaging mainly Drive and overdrive sometimes reverse. it shifts fine when I am driving. A shop told me the front pump is going out. Would it be worth it to flush and put some Lucas fluid in it. I am trying to advoid spending hundreds having the tranny rebuilt or replaced.
View 1 Replies
I have a 2001 Ford F250 truck -- it was stalling out (which was diagnosed as a faulty fuel pump), so I had the dang thing replaced. But nearly 6 months later, it's randomly stalling out again when I put it in reverse or stop at a light.
View 1 Replies
I have a 1987 ford 350 when i go up a steep hill the truck starts to skip and break down to a point where I have to pull over i just put in new fuel pump in tank, what could be the problem only happens on hills.
View 11 Replies
I have a 1998 Ford F150 with 4.2.. Started off a intermittent problem of not starting acct no fuel. Now will not start at all. Checked all fuses and relays.. Am not getting voltage at fuel pump. Changed ECM thinking that was the problem.. Have checked all multi wire connectors for corrosion and tightness. Am at a lost what to try next.
Also, not sure if its related or not. The turn signals and hazard flashers do not work. When I turn on the hazard flashers, nothing happens. If I leave the flashers switch on, the turn signal work. Checked all fuses and relays and they appear good.
View 2 Replies
First it was the whole spark plug debacle. Now it's the "fuel pump module". Story starts a several months back. On a moist day I was headed out and the truck ran very rough, "clunky", like it wasn't getting gas. After 15 miles and a stop truck ran fine. Didn't think much of it and truck ran fine for month or so. I was then away for a couple days and came home to find my truck wouldn't run (started briefly then died). Local mechanic thought it might be a fuel pump issue but then got truck running thinking it might have been a delayed inertia switch in front panel (I had hit a deer a week or 2 prior). Again, not thinking much of it continued to drive truck with no issues for awhile. Then one rainy morning on my way to work the truck was running very rough and "clunky" again. It died several times and finally for good.
After getting it towed to the mechanics, he figured the fuel pump was finally shot. The end to my long story is it was the fuel pump module (luckily a lot cheaper fix than the fuel pump) - half of the housing was gone (corroded away) adn moisture was shorting the pump electronics. Why, if this module is half encased in plastic do the engineers feel the need to encase the other half in metal (appeared to be cast aluminum)??!!????!! Of course it makes sense to have an electrical unit that is mounted underneath the truck where it can collect all the moisture, snow, salt from the road encased in a corrodable metal housing. No no, don't put it all in plastic, just half of the unit. MAKES PERFECT SENSE!! I thought to be and engineer took some sort of brains and common sense. Must be not at Ford. I can't be the only one with this issue and wondering WHY!!! - it must be widespread??
View 4 Replies
Sometimes the check engine light comes on and truck will not start,the fuel pump runs non-stop.. when check engine light goes off,the fuel pump runs for a few seconds and stops,truck will start.... driving down the road check engine light will come on and truck runs bad....
View 2 Replies
I was driving my truck then all sudden truck started losing power then slowly died. I restarted it, it was a lil shacky then died again. Iunscrewed the fuel filter and looked in the housing and there was lil fuel in bowl i turned the key to on position and bowl did not fill with fuel looked as if it were shooting some bubbles up(air) could it be outta of fuel???
View 10 Replies
I have a 4l60e transmission that was rebuilt less than 500 miles ago, I was driving on the highway when all gears were lost. There is clicking in the front part of transmission. Can I just replace pump? Fluid is clean no pieces in pan, are cluthes still good?
View 6 Replies
