After driving about 60kms yesterday for the first time and driving pretty cautiously to break the car in i noticed a pretty strong burning plastic like smell in our garage.
This is only my 3rd brand new car and i don't remember the other 2 having this smell..
does hyundai coat their new cars with Cosmoline? or another protective coating that burns off and takes a bit to go away?
Today I noticed a strong burning rubber or plastic smell coming out of the right rear wheel well. All other wheel wells did not have this odour.
We had a bout of freezing temp's here recently and some snow, I'm wondering if the brake on that wheel may have seized slightly through the all wheel drives tourque vectoring or through parking brake use.
I'm going to drive it to the dealership tomorrow without making an appointment in hopes they will look at it right away as making an appointment this time of year is probably going to take forever.
Something I might be missing or can do?
We have a 2015 Santa Fe Sport AWD (without turbo). It has about 4,200 miles on it. Recently my wife complained about a burning smell that she hadn't noticed previously.
I drove it and noticed the smell. Pulled into our garage and left the engine running and noticed a minor, but noticeable amount of smoke coming out from the hood on the passenger side. When I opened the hood it appeared the smoke was coming from the lower, back side of the engine.
I later went out and started the car and let it idle for a bit. Didn't notice any burning smell or smoke. Later drove it again and noticed the smell and a little smoke. So it seems like it occurs when the car has been driven rather than simply started and not driven.
I was driving around running errands when my AC stopped blowing cool air, a funny kind of "metallic" burning smell was coming from the engine, and there was a slight knocking noise that was apparently coming from the engine and would go faster as I accelerated.
My car is still under warranty so I know stuff will be covered. My question is : what the heck is going on with my Santa Fe? I need to know whether I should call into work or drive it anyways.
Can a piece inside the HID be replaced. I noticed that my bulb was coming loose because every now and then the light would stop working.
I'd open the hood tighten it and all would be good for weeks sometimes months. Today it stopped and I opened it and this time it had a burning plastic smell.
Can this piece be replaced?
My car smells like some plastic part is burning inside. The heat works just fine but for some reason i am getting this horrible smell. How to get to air filter of the fan.
View 5 RepliesI have a 2007 Sonata V6 with 198,000km (123,000 miles) and when I was driving yesterday I smelt a burning smell like burning rubber or plastic. The smell seemed to go away after a while and I was wondering what could have caused it?
View 2 Replies1991 Buick Regal. I'm driving at night a few days ago and all of a sudden the lights on the instrument panel go out. The headlights are still on and the radio is still playing.
So I click the headlights on and off and the instrument panel lights come back on. The next night this happens again. This time I just give the headlight switch a little jiggle and they come back on. Tonight they go out again, jiggle the switch and they come back on. They go right back out. Jiggle the switch again and they're on.
I drive for another five minutes and now I smell plastic burning; it's the typical electrical/wire short smell. I turned the interior lights on and there was no visible smoke.
I'm going to try and pull the dash tomorrow and see what's going on in there, but they want $400 for an OEM replacement switch! I found some used ones online, but I'd have to get them mailed from a junk yard for about $50 bucks.
So I'm wondering, is there a easy/cheap way to rig a headlight switch in the interim so I don't have a fire in this thing? I don't understand why a headlight switch has so many prongs on the connector.
The only caveat is that the guy who had this car before me rigged the ignition through the headlights (I was told as some kind of security feature?) so that the car will not crank unless the headlights are on. Maybe/hopefully some shoddy wiring on that is just causing an arc.
Where do I start. I have a 2001 Nissan Sentra. 128,000 miles. In Aug. of last year, the engine detonated, so I had it replaced along with other parts. Shortly after that, I noticed a burning plastic smell coming from the car after driving it for a while. I confirmed that that the smell wasn't coming from a plastic bag. Fast forward to Dec 2011, my check engine light comes on. I go to Autozone, have the code read; it's the dreaded 420 code. I go to have it checked out, was told my cat went bad and probably because of the old engine and that the smell is probably coming from that.
The check engine light went off on Christmas day. Fast forward to last month, the light comes on again and I pony up the cash to have the cat replaced since inspection is coming up in June. Now, I had an engine diagnostic run right before I got the cat replaced and it came up fine. The cat was replaced on 4/20. Everything seemed fine. The burning plastic smell went a way, but lo and behold, it came back this week. I don't know what to do. I did a little search on the net and it seems that burning plastic smell indicates there is something going on with engine and possible misfire.
The first time I noticed the sulphur smell I figured it was another car. Since then it has happened several more times, typically when outside temps are a bit on the high side.
I saw some members noticed a fishy smell with a/c but I would say mine is more toward the rotten egg smell. Once I am parked the smell is gone with no residual under the hood.
Also, one time I noticed with temps in the high 90s and shutting down the engine there was a pretty dramatic spooling down noise of some sort after the engine was off. Has not happened before our since.
After battling the general nitwit public earlier. I was on my way home and as I neared my house, a party bus was blocking the road. Well, I got angry, shifted to reverse, revved the engine while letting out the clutch to back up and take a different route. Then this horrible burning electric/plastic smell inundated the inside of my R. I knew I rode that clutch while backing up. My question is did I do noticeable damage my clutch, or is it one of those: it'll be fine just don't do it again thing?
View 4 RepliesLast night I was driving in my 2003 jetta on the intersate at 65mph with the cruise control on. As I came into a turn I had to tap the brakes. As soon as I did the check engine light came on. The car was doing fine so I drove home from school. Today I drove the car to work which is a five minute drive, and back with no problem. I later went to grab lunch and bring it home and then I noticed the check engine light started flashing. I then felt the engine start to stutter, as if it was misfiring. We had the windshield defrost when we started to smell a rotten egg smell. Luckily we were pulling into our drive when we smelled the odor. I immediately turned off the car and got out. I couldn't smell the rotten egg smell, but I did smell burning plastic. I didn't see any smoke and could not pinpoint the cause of the smell.
View 4 RepliesRecently purchased a CPO 2009 F250SD 6.4L. Happy with the truck overall but this AM I noticed a slight burning plastic smell so I opened the hood and looked around closely. Didn't really find the culprit(I don't think) but noticed that the engine compartment heat shield/barrier appears to be falling down above and behind the turbos (pictures linked below). How big a deal is this? Would it be covered under the CPO warranty? It almost seems like a safety issue. I also wonder if the insulation material, now exposed without the metal reflector material, is what is causing the smell....
View 14 Replies2013 Elantra GT ... It is winter on the east coast and we turned on the heater and the car began to smell like an electric wire is burning. It literally is making us sick. The A/C did not produce this smell. The dealer says it is normal.
View 9 RepliesResurrecting this 2001 2.7l, I noticed the horrible gas mileage.
I'm thinking o2 sensor, but it doesn't throw a code... Anywhere else I should look? I've changed Crank Position Sensor, Fuel Pressure Regulator, plugs, and brakes.
One note, when the a/c is turned on, I can smell a burning kinda smell. Maybe the clutch on the compressor is going out, causing some parasitic type of power loss? idk. Car seems pretty peppy now that it has a new CPS.
I have a new 2013 Hyundai Accent (automatic, 4 cylinder) with less than 1500 miles on it. The day I drove it off the lot and up until today, it randomly smells like burning rubber. It happens whether it is hot or cold, driven two miles or thirty miles. The smell is coming from under the hood but I know very little about engines, so I'm not sure what it is. I have told the dealership and they don't seem to care. I may not know much about cars but I know that that smell is not normal, especially in a new car. What could be causing this...
View 7 Replies2002 Santa Fe V6
Ran the AC yesterday for the first time after a long cold winter. Seemed fine for about 15 miles but then I came to a stop and all of the sudden smelled burning plastic/electrical... white smoke started blowing out of the vents. Pulled over, popped the hood. The smoke appeared to be coming from the passenger/rear side of the engine.
Drove it another 15 miles home (had to) but with no AC or even fan on... made it and noticed the smell and smoke but only very little.
This morning I started it up .. got under the hood and clearly can smell it coming from the same area. That is the alternator at the back of the engine passenger side right? Voltages read fine... seems to be charging ok as well.
The only indicator that it is going bad is of course the smell and smoke... I can feel it is getting very hot.. too hot to touch after only a few minutes running. Spun bearings in it maybe? Just thought I'd put that out there before I start tearing it apart.
Vehicle:
01 Santa Fe LX 2.7 AWD w/112k miles
Symptoms:
- Slow Start (when cranking takes 2 full seconds before it will turn over and you can hear the engine cranking slower, use to turn over right away)
- Very Strong Burning Rubber Smell
History:
Last January it got down to -20 here in Albuquerque and I would have to go to work at that time. About a week later (when it was still getting down to about 0) I was driving home from work when I smelled a slight smell of burning rubber. I thought it was the car in front of me. The next day I had the same thing. It continued for about a month till the temps rose a bit and then went away. I could never find the cause. I then went all spring, summer, and fall without any problems on my Santa Fe.
As the temps begun to drop over the past 6 weeks we started to smell the burning rubber again, at first only when I would start the car till it warmed up. About 2 weeks ago the car started cranking slower and would take longer to turn over and within the past week I can smell the burning rubber smell even when I had the engine at temp. There's not any idiot lights on. The car is running fine except for what was mentioned, gets up to temp and stays there (a little below the middle on the gauge like normal). I pop the hood and looked at the belt, looked good (no cracks). Checked all the fluids and the only thing that's low is the coolant.
Well, I have the dreaded transfer case leak on my 112000 mile 03 2.7 santa fe. I have just returned from a 12,000 mile trip through Canada, Alaska and then back to Colorado. During that trip I was smelling a burning oil smell and after I came back I traced it to the transfer case. I think it is leaking both from where it mates to the drive train and a one inch seam along the transfer case plate.
It has leaked there for some time(and I had been diligent about filling it up), but this extended trip it has has been more bothersome. I called the local Hyundai shop and they want $1100 and won't guarantee a fix. Is there some product I could use on that one inch seam externally to stop the leak (I know that wouldn't seal the circular seam around the drive shaft)? I kept very accurate gas records and averaged 25.6 MPG for the whole 12k trip running from 55 to 65 MPH.
I have a burning smell coming from the grill? noticed it yesterday while driving. 110,000 miles + volvo s60. no engine lights, no smoke, temp. gauge is not high.
View 8 RepliesHaving burning oil smell coming from the V6. Took it to the dealership and they tole me it has an oil leak on the the header then it burns off. It seems to get much worse when the RPM's are some what high. Only 70,000 miles too. Guess its getting to stay that way for a while.
View 9 Replies