Santa Fe (CM - 2007-12) :: Vibration Comes And Go While Cruising At A Constant Speed On Highway
Mar 31, 2015
Our FWD Santa Fe Limited had a very noticeable vibration that started around 60mph. Oddly, the vibration will sometimes come and go while cruising at a constant speed on the highway. We went about 30k miles before we had time to get it into the shop.
I asked them to rotate and balance the tires and the vibration was noticeably reduced...initially. Now it's back!
The car has ~65k miles. All 4 Kumho tires match and I believe are original from the factory. I have kept all tires inflated properly.
Our car has the optional 18" wheels. Is it common for these to bend? What else could be the cause here?
View 5 Replies
Advertisement
My 2001 Prelude (not SH) develops a vibration felt throughout the car and particularly the steering wheel after several minutes of constant highway (60 - 75 MPH) speed travel. Thought it might be a brake caliper sticking, but the car does not pull left or right. After 7 or 8 minutes of vibration, it stops and the ride is smooth as glass.
View 8 Replies
2002 Camry LE 4cyl. automatic. I bought this car with 7500 miles on it in 2010. It had been involved in a low speed parking lot collision and apparently the left front corner and front took the hit. It'd been repaired and looked like new when I bought it. It still had the factory tires on it, but they were 8 years old, so I put a set of new Kumho Solus' on it. This was a friend's mothers car, so I know the history of it.
The left front suspension has always felt odd to me. Nothing serious, but just "off." When backing up and turning it has a sort of wobbly feel on that corner at times. I've been assured by several mechanics that they can find no problems. It feels to me like maybe sometimes the strut piston sticks on that corner. Don't know if that ever happens or not, but that's the best description I can come up with!
It has always vibrated from 45 on up. It's not a hard shudder, but just a constant vibration at highway speed that you can feel in your feet and the steering wheel. I've had it balanced and re-balanced to no avail. Sometimes it gets a little better, sometimes worse, but it's never gone away. Recently it seems to be getting worse.
I put it up on jackstands and accelerated to 60, and it vibrates like the wheels are out of balance. Yesterday I replaced the Kumhos (they had bad road noise anyway) with Michelins. The Michelins cured the road noise problems and have a much better overall feel, but I've still got the balance problem.
Just put it up on jackstands again and spun it up, and I still have the same vibration!
What to look for? The car has just now turned over 35k miles. I'm wondering if the CV joint on that left side was damaged and is causing the vibration. I've got new wheels as well instead of the factory steel rims. Also, with the car up on stands, the wheels spin true. No bent hub, etc.
View 10 Replies
I bought a 2004 Hyundai Santa Fe 2.7L AWD about 5-6 months ago. It has close to 120,000 miles and has a terrible vibration at highway speeds. It starts around 55-60mph and gets increasingly worse as speed increases. The steering wheel originally vibrated quite violently, but after changing the "front axles" it resolved only the vibration in the steering wheel
I took it to a local shop we trust, they changed the "front axles", all spark plugs, ignition coils, timing belt, transmission fluid change, and a o2 sensor.
I changed out a serpentine belt, tensioner, and idler pulley (due to a squeak), another o2 sensor, and tried to change the transfer case + rear differentials fluid. I couldn't change them because the fill plug was very stuck... we used a propane torch and a large socket wrench.
Anyways, after the front axles were replaced, the steering wheel got significantly better, there is however some vibration through it. After they were replaced it did not fix the vibration shaking the whole car. I've noticed that when you let your foot off the accelerator all the way, the vibration stops. When you step on the accelerator again it starts shaking very bad, and then begins to get slightly better. The vibration has a rhythmic timing to it. It seems like it pulsates stronger, then softer every 1/2 second or so
Also I have had the wheels balanced 3 times. I doubt it's the tires, unless a tire is out of round. My rotors also do not seem to be warped. When I brake, there is no shaking/shimmying. I was wondering if it could be the engine mounts? This vibration is very annoying, since I have to drive long trips sometimes. Other than this problem I like this car and would love to see it fixed.
View 14 Replies
I recently bought an '09 Santa Fe Limited. I want to love the vehicle, but I've got a problem with how it drives. Basically, here are the symptoms:
1. Engine RMPs dance around about 200 RPMs at idle. (I was told this is normal. I don't think it should be.)
2. Under normal acceleration, it bogs down immediately after shifting into 2nd gear and after a couple of seconds there is a surge and acceleration seems "normal."
3. Occasionally, I feel subtle fluctuations or surges in the engine under both acceleration and/or cruising speed (any speed, really.) It's like I'm feathering the throttle when I know I'm not. This is most pronounced when under a load, such as taking off from a stop sign at the bottom of a hill and accelerating up the hill.
So, here's what the dealer has done to address the issue.
1. According to the Carfax report, the previous owner had the throttle position sensor replaced at 22,000 miles and again at 27,000 miles. I bought the vehicle with just over 30,000 miles (certified pre-owned).
2. On the day that I bought the vehicle, I noticed the issue and the service manager took it for a test drive with me. He told me it was wind buffeting that I was feeling. I thought that was bunk, but with it being a higher profile vehicle, it put some doubt in my mind. He went ahead and flashed something to reset the adaptive learning module that supposedly adjusts something in the engine based on how you drive. It seemed better after that, so I went ahead and bought it.
3. After a few weeks of driving it, it became clear to me that it was definitely not wind buffeting, so I scheduled a service appt. It was taken for an "extensive" test drive (according to the service record) with a diagnostic computer connected. Apparently, the service technician said they were only able to find one small blip with the mass airflow sensor, so they replaced it and called it fixed. I should also note that at no time, have any codes ever shown up when they check for error codes.
4. Although it seem slightly better, the problem still exists. Just for kicks, I dumped a bottle of Seafoam in the gas tank with my last fill up, but that doesn't seem to have made any difference.
View 14 Replies
I have a 2004 2.7L V6 GLS Hyundai Santa Fe AWD that I purchased about a year ago. The car has about 114,000 miles on it I believe. My problem is that I have an annoying vibration at idle and at highway speeds of 60-65 mph. The vibration decreases somewhat towards 70 mph. The vibration at idle is usually present, but sometimes vanishes for no apparent reason. The car is very smooth below 55 mph, but when around 60-65 mph becomes quite violent at times. The side view mirrors shake very badly and the vibration can become tiresome.
Originally the shop believed that the front axles were the culprit and replaced them – this mitigated some vibration felt through the steering wheel, but not much of the vibration throughout the cabin. The wheels have been balanced 3 times, alignment checked, and wheels do not seem to be bent/dented. (The tires were road force balanced)
In addition I have also had the following work done:
-2 oxygen sensors replaced (both post-catalytic converter)
- 2 Catalytic converters (replaced to pass emissions)
-Timing Belt Replaced
-Serpentine Belt Replaced
-Idler Pulley and Auto-Tensioner Replaced
-Ignition Coils Replaced
-Spark Plugs Replaced
-Transmission Fluid Change
-Oil Changes
-1 Tire Replaced (Sidewall Blew Out) (Michelin LTX M/S2 Tire)
-Air Filter Changed
-Crankshaft Position Sensor Replaced (It was Corroded Away)
Why the car is vibrating so that the mechanics can check it out. One idea I have could be the engine mounts – this would explain the vibration at idle (in park). I drive about 10 hours a week on the highway at the speeds that cause this vibration.
View 12 Replies
Since I got my car back from the dealership after changing the rear shock this summer, I can feel a vibration in the car at highway speed. After the shock were replaced the car steering wheel was out of balance and pulling one side. After they attempt to align the car about 5 times it got a little bit better. Then I found out that they had an accident with my car and tried to hide it: [URL] ....
I suspect the tie rod may have been damaged so that could explain the steering issue. It also seems to have gotten worse over time. I'm trying to figure out the possible cause, if directly related to the tie rod damage or indirectly as if the tie rod damage could have caused uneven tire wear and then causing the vibration over time. I've attached some pictures, the 2 first are from the front passenger side, the 2 last from the front driver side. My tire are the Michelin pilot and this thread seems to suggest those tire might be hard to align properly: [URL] ....
I'm due for my winter tire change soon and see if thing gets better, I'll get them balanced too. I'll check at the same time for control arms/shock damage. But still, I would like some feedback and see if those tread wear are normal and hopefully get to the root of the problem (the outer edge on the tire in the back are much less damaged).
View 1 Replies
My car santa fe 2009/ 4WD / 2,7 / around 70,000 kms. Around a week ago, I noticed some vibration, that I can feel it mainly on the gas pedal. I can assume that the vibration came from the front of the car and just at low speed, like below the 40km/h. Also I feel that when took my foot of the gas, the vibration gone.
View 7 Replies
Cruising down the highway, my 2001 Santa Fe engine suddenly cut out. Would crank, but not fire. Not hearing a sound from the back when I flipped on the key, suspected the fuel pump, which I replaced. No go.
I'd pressed the fuel pump reset switch under the hood - checked it again. Should the switch, when it's pressed, stay in a locked position, like when you do a reset on a GFCI electrical outlet? Or is it normal for it to have the up/down 'play' in it?
Also noticed a strange buzzing on the other side of the engine compartment -- was the unit (don't know what it's called) that the throttle cable feeds into - hooks onto a pulley. The buzzing was intermittent and inconsistent, but it was happening with just the power switch on.
Oh, and did replace the fuel pump fuse, too. While it's at 280.000 miles, not quite ready to give up on 'er yet!
View 1 Replies
Noticed my 2002 F150 had a very slight vibration in the seat / steering wheel when cruising down the highway at 60 MPH.. Very slight, but was not there 2 weeks ago.. It seem to get a little worst as the 2 weeks progressed. Got all 4 tires balanced and rotated... no luck...Took both rear wheels off-- no problems with tires -- checked bearing clearance-- pushed and twisted on driveshaft yolk to check pinion bearing... nothing found......... last resort was drop back end of driveshaft and check U-joint.. It was tight and dry. Put drive shaft in 12 ton press and pushed out the u-joint bearings. Very dry and joint pins were starting to spall....... I mention this because I had checked " clearance" and "slop" and had "no noise" before removal... Truck has 139K miles on original u-joints .......... Something to keep in mind. Eventually it would have worn to the point that it was obvious, but in the first stages of failure, you just get small symptoms.
View 7 Replies
My fathers truck starts, runs, idles fine but once on the highway at constant speed, the engine misfires or hesitates causing a small buck or jerk but continues on down the road. The SES light is on. He took it to O'Reilly and they put some kind of computer on it and (I think) it said misfire in a cylinder. He replaced one of four O2 sensors, pickup in the distributor (not sure what this is called), wires, and plugs with no cure. This problem is very strange as again, it only does it a constant speed; truck runs fine at idle, acceleration, deceleration, startup, etc. There may be a slight sulfur smell during idle and there is a decrease in gas mileage.
View 14 Replies
I had this item of concern as a response to another thread but I thought I'd open up a new thread and see if I could get any more attention.
I bought a used GLS and upon initial drives I have noticed a high speed vibration that seems to come from the rear (I don't feel any in the steering). In the colder weather recently I've noticed a pronounced vibration at a lower speed (just before shift points). between 2nd and 3rd. This seems to be worse with short drives or in morning.
Vibration seems to be worse just after a tighter right turns or even some left turns. I notice the most vibration right around 25mph. I also get it with moderate acceleration into a certain torque range. Like driving at 45 and accelerating up to 60. What is going on? It seems like it is linked to acceleration (torque) and possible pressure from turns. CV joint / axle? Wheel bearing? It seems like a tire would be worse as speed increased and more consistent.
View 4 Replies
I have an 04 Elantra GT and have been noticing a jerkiness when driving at a constant speed on the highway. I haven't noticed it around town or while accelerating. I also have noticed that when I disengage the clutch on the highway, the engine sometimes doesn't respond right away, or it even may surge. This has happened when exiting the highway when I disengage the clutch. The engine will slow, then speed up close to 3000 rpms.
I also had a check engine light come on and couple months ago. The code indicated that the upstream O2 sensor was bad. I took it out and cleaned it, but didn't replace it. Is this a likely culprit for this set of symptoms? If so, how can I test the sensor to be sure? I heard that I could disconnect it and run the car and see if the surging lessens, but wasn't sure if that was a good thing to do.
View 8 Replies
Been having a very light vibration when cruising at speed as well as on some lower speed shifts and finally crawled under the truck today to check for drivetrain play. Other than the amazingly soft and sloppy transmission mount I noticed a TON of play in the driveshaft transmission yolk. Didn't feel like the u-joint but actually the tailshaft yolk. Dealer said on the phone they have seen this on a few of the newer trucks and it *should* be covered under the power train warranty. I have the subercab with the 1 piece aluminum driveshaft.
View 4 Replies
I have been noticing some vibration from the rear of the car while cruising between 75-78 mph. I had the tires balanced at Lexus 2 weeks ago and the car feels better but not perfect. I called the service advisor and he said the read out on the balance sheet showed that the tires were balanced perfectly but they will look at it again.
My issue is that I am going to have a set of 22's installed on Monday and I want to make sure nothing is wrong with the car itself because once the aftermarket wheels go on the dealership basically washes their hands of the vibration issues. The tires on the stock wheels are brand new and maybe have 1000 miles on them.
View 12 Replies
My Prius v has 1300 miles. I didn't notice at first but now I notice a constant high frequency vibration in the car, especially at highway speeds. Took car to a tire shop and had tires dynamically balanced, same problem. I think it must be the toyo low profile tires or its in the drive train and just inherent to the hybrid system. Seems to be the same whether in eco mode or ev. Vibration is the same on smooth or rough roads. Dealer service manager says he is not aware of any problems. Suggests bring car in for a test drive and compare with another new one.
View 7 Replies
Ever since the day I bought the car, it has had a highway speed pulsing vibration. This vibration manifests once you cross about 90kph, and pulses like a sine wave.
Think of it like this - OOOOOOooooooOOOOOOooooooOOOOOOooooooOOOOOO - where big O's are vibration and little o's are absence of vibration.
I have had the wheels and tires rebalanced several times on various machines over the years in attempts to rid myself of it. The original owner had theorized that the car was so heavy and had sat on its aftermarket rims in one spot for so long that the wheels had bent, which does not appear to be the case. The dealer has experienced the symptoms but cannot find a cause...though I fear they are less knowledgeable about the car than I am. I note that several people on the forum have had vibration issues due to drive shaft bushing failures...but in skimming the relevant threads, none of those people characterized it as a pulsation OR a constant issue that I saw.
I wouldn't say the pulsing was fast...think 4-5 seconds of vibration and then 4-5 seconds of peace.
View 9 Replies
Trying TSB 05-13-1 on f150 ? Mine is a 2004 xlt 4x4 and it shakes and vib really bad from 55 to 60 mph ,had tires balanced 3 different times brakes replaced and rotors turned ...
View 14 Replies
This is on an 04 Excursion, 4x4, 6.0 SPD. I have started experiencing a vibration at highway speed, 60-70 mph. After 70 it smooths out a little but still noticeable. I've replaced both rear tires and still have the issue. When I put my foot on the accelerator I can feel it more but as soon as I let off it drops off dramatically. I am thinking u-joints, which will be replaced this evening...
View 4 Replies
Last week I posted about dropping my car off for service and the dealer finding that all four of my wheels were bent, causing vibration at highway speeds. So I spent a couple hundred dollars and had them fixed.
Car still vibrates at highway speeds...
I feel the vibration in my seat and throughout the car at about 60+mph. The faster I go, the more noticeable it is. I can even hear it.
Dropped off at the shop. Shop called me back stating that the vibrations are being caused by the two tires that need to be replaced.
View 20 Replies
I wanted to believe I had rid the car of the steering wheel vibration when I lowered the Psi in the tires from 46-50Psi to the 35Psi it should have. However, the car still has a vibration in the steering wheel when going highway speeds accelerating up gradual hills or when accelerating out of a sweeping turn at highway speeds. It is very noticeable, you can see the hands on the wheel shake. Passengers don't notice it. I had my brother in law drive it without mentioning to him and he noticed it as well.
View 9 Replies
