Santa Fe (CM - 2007-12) :: Fuel Smell In Cabin If Fill The Tank To Full
Nov 8, 2011
I have a 2007 Santa Fe. If I fill the tank to full, or close to full I will have a fuel smell in the car until the tank runs under 3/4. If I keep it under 3/4 I usally do not get the smell in the car.
The dealer could not figure it out and I still have this issue. It seems the smell is more in the front of the cabin then the rear. It just could seem that way since the smell is very strong. I have to park the car with the windows open.
There are no fuel leaks, no fuel on the ground, no drips, and the no spillage when I filled the tank.
View 6 Replies
Advertisement
I have a 2007 Hyundai Santa Fe with 83k on it. For some months now, I have always been smelling strong fuel scent in the cabin. I took it to the workshop and was told it's my fuel canister so i handed money to the Mechanic to buy one to replace it. He called back to tell me he cannot get one to but can work on it by blocking the pipes or lines. I am not that convinced because i know the canister is there for a purpose so if he goes ahead to block the pipe or whatever, then it means something else can go wrong in the interim; but I'm in a quandary now and want that fuel scent to stop.
View 1 Replies
I have 2007 explorer 4.6 v8. The check engine light is on, and i can only fill the gas tank about 3/4 full, after moving the gas nozzle all around and taking about 15 minutes. I read a few different things while searching. Like vapor canister need to be replaced. or the vent hose needs to be replaced.
View 1 Replies
I have recently purchased a 2001 Accent GS which has the 1.6L DOHC engine and have done a big road trip in it which has created a problem. When I fill the fuel tank up it runs really rough, has no power, and stalls at idle unless I keep the revs up. I can also smell petrol very strongly in the car all the time, plus it's running really rich as I can smell fuel on the exhaust and the last symptom is the loss of power down low(due to running rich).
I was on my road trip so had no tools on me and got the local mechanic of a small town to do a few basic things (change spark plugs, leads, and fuel filter) but to no avail. It runs smoothly when it gets below the full line on the fuel level gauge so I just didn't fill it up completely to get the car home but it still runs really rich and doesn't have quite as much power.
View 4 Replies
2007 Pacifica with 4.0 will not fill unless you dribble the fuel into the tank. I have cleared the vent hose and know it is clean. Do I need to change the Carbon Filter and Solenoid/Evaporation Valve on the Front of the Carbon Filter?
View 7 Replies
Yesterday afternoon, after a 90 minutes stop and go commute, a strong gas smell developed in the cabin of my 2009 LS460. The factory call-back service was performed on the car few months ago.
During yesterday's long commute, the LS460 passenger side wheels run over some garbage on the high way at high speed, and after that I can hear some noise from passenger side, sounds like a flag's flopping sound.
Other than that, recent incidents that I can think of that might be related are:
1. All 8 control arms of front wheels replaced about 3 weeks ago
2. Have been using Sam's Club premium 93 gas for the past 4 weeks
View 5 Replies
The ole 5.4l hit a snag today. I was on my way to fill her up and she started sputtering and damn near died! i filled her up and it was like nothing ever happened. Took her to AutoZone and the diagnosis was a Fuel Tank Pressure Sensor.
I have a connection with Bumper-to-Bumper to get the part for cheap but I'm not sure if i want to dive into either moving the bed or dropping the tank. I'd prefer to move the bed.
View 3 Replies
I have a 2010 ford edge. The last two times I tried to fill the gas tank, the nozzle on the pump shuts off as if the tank is full. The tank has not reached it's capacity. I have to "dribble" the gas into the tank, and even then it seems to be backing up the pipe. A simple two-minute fill takes ten minutes.
View 3 Replies
Since purchase, I've had one gas fill up at 694 miles. That was four or five weeks ago and it's still full. My EV ratio is 65% (1100 miles) and will continue to increase. I realize I'm carrying a lot of dead weigh for weeks. For those with high EV mode use, what's your recommendation with gas fill ups? I'm thinking no more than fives gallons for daily commute and around town.
View 14 Replies
I just changed my fuel tank and now when I try to fill it up it keeps blowing back it never did this before.
View 2 Replies
Having problems with the fuel indicator not reading full after a fill up. I have slowly filled my 2012 Passat TDI SEL till I can see diesel in the filler neck and the gauge still only shows 7/8 full?
View 9 Replies
2003 Ford Explorer fuel gauge does not show full after fill up. The Ford service stated that it can take up to 17 minutes (of running time) for the fuel gauge to show full after fill up.
View 7 Replies
2008 hyundai santa fe. 106,000
Bought the car six months ago.Found out 2 weeks later we couldn't put gas in it. Dealership refused to fix it because we bought as is. So we managed to find one gas station in a 20 Mile radius that we could put gas in it.It takes around 10 minutes to put half a tank in. Shortly after that the gas gauge started to fluctuate from full to empty. And the check engine finally came on. Had the the check engine light checked.Fuel level sensor A was faulty. Took it to a local Goodyear in stead of the dealer ship. The sensors were 119.00 a piece and the labor was 145.00 to replace both. Had both replaced .Fuel gauge is working correctly now. But still having issue putting gas in car.
View 1 Replies
I have a 2007 Santa Fe Limited with 112000 miles on it, and its having some issues with the fuel gauge. It doesn't tell me the accurate gas level in tank.. it's either half-full or on empty. The check engine light is also on. What could be the problem? Is it an expensive fix?
View 1 Replies
I have an 04 Elantra GT. My gas gauge is showing full but the car is running out of gas. I try to fill the tank and I get the annoying click and after trying for a few, gas comes up the filler and overflow tube and makes a mess. At the same time, I was getting a P0449 code. I got an evap canister from the junkyard and that seems to have gone away.
Tried diagnosis but dropping the fuel tank to access the lines. When I jack the tank back up into position, you can hear gurgling sounds and as if the gas is coming up the fill tube. I also opened the access panel under the seat to see the pump assembly and when I removed the 8mm bolts, gas came pouring out. There was definitively gas in there. Checked the float on the pump assembly and it moved?
There is also something at the fuel neck at the top. Don't know what it is and if that could also be part of the problem.
View 10 Replies
My 2003 Expedition has started spraying fuel out of the fill tube whenever I fill the tank. It started 6-8 months ago. At first, I thought that maybe it was a fluke. It kept happening. I am so tired of getting fuel all over myself and my car. Not to mention the environmental impact of the fuel spill. This isn't just a little fuel dripping out of the tank and spilling on the ground. It's a full on projectile expulsion of fuel from the tank. What's happening and what I can do to fix the problem?
View 4 Replies
Well, finally! After wanting a code to troubleshoot this low gas mileage and fuel smell (outside the car, usually, but sometimes inside the car also) for 3 months, I FINALLY got a trouble code.
Bad news is: it's P0457.
2001 2.7L. Where would you check first? I've already replaced the cap and pump (the old cap was fine). Pulled the EVAP can off today, no holes or anything that I saw to cause a leak. Where is this "two-way valve" located? Think it might be the place to look?
View 2 Replies
Ok, 04 Passat, 1.8T AWM
CEL is on for po456 (very small evap leak) and every time I fill up on fuel, I can smell a STRONG fuel odor, from near the fuel neck, and inside the car. Stops after it hits around 3/4 area. No leaks, and the car runs fine. Gas cap, and N80 valve were just replaced, both parts are from the dealer. I'm going to bring it in for a smoke test soon. All recall notices have been done too, I just did the timing belt.
View 1 Replies
I am having an issue with by club wagon. This vehicle has dual tanks. The front tank doesn't work (and never has since I purchased it a couple of years ago....bad fuel pump I am guessing}.
A couple of months ago the fuel pump went out on the rear tank and I had it replaced. I now have a peculiar problem. Fuel is coming out of the front tank fill spout when the engine is running. There seems to be a tremendous amount of pressure building up in the front tank...even though I am not using it.
I would seem as though fuel is being pumped out of the rear tank and into the front tank to a certain pressure point, and then on to the engine. One solution would seem to be to remove the front tank completely from the system, but I don't know how to do that, or if it should be done. After driving and coming to a stop, fuel is pouring out through the gas cap on the front tank. I. Don't need to use the front tank as I am just using this as a work truck.
View 4 Replies
This has happened to me 4 times now in the 7 years I've owned my car. It happened so infrequently I thought the problem was the pump's sensor was not working properly. However now it's happened twice the last two times I've tried to fill up. On Friday my son was supposed to fill the car and could only get 1 gallon in and the fuel pump kept clicking off as if the car is full of gas. The bars never moved and I thought the problem was the pump. Then today, Sunday 2 days later, I decided to go ahead and fill it up. I have 250 miles to drive and want a full tank of gas. The tank shows 3 bars. I started fueling and it clicked off at 1 gallon. So I pulled the pump trigger again and tried to force more fuel in and it stopped and wouldn't add anymore than 1.7 gallons.
So now I have a long drive tomorrow and I can't figure out why the pump is clicking off as if the tank is full yet it can't be because I drove 250 miles since my son tried to put gas in and it's showing I have 3 bars.
View 3 Replies
I generally average north of 50mpg on a regular basis. Yet, my cruising range is always somewhere around 300~ miles for a full tank.
View 5 Replies
