Santa Fe (CM - 2007-12) :: 2009 - Severe Clunk In Front End When Driving Over Rough Surfaces
Jul 2, 2015
I own a 2009 Santa Fe Limited AWD with 56,000 miles on it. I purchased it new in July of 2009. I have started to hear a severe clunk in the front end when driving over rough surfaces/potholes. Not when turning the steering wheel. I have read about issues with front stabilizer link bushing. The Santa Fe is at the dealers and they said it is the front control arm bushings. $1000 to repair!
View 41 Replies
Advertisement
When I go over bumps or rough surfaces I hear a rattle in the rear suspension. It sounds similar to the noise bad ball joints make. I recently had the car aligned and the shop said they couldn't find anything wrong. I'm going to take a look myself but was wondering if this might be a common problem. If maybe there are certain bushing that are known to wear out.
View 2 Replies
I have a 2011 SF 2.4L FWD GLS with 79k miles. I replaced the OE struts and shocks 3 weeks ago with Monroe OE Spectrum struts and shocks. This improved the ride tremendously especially on the front passenger side where the strut was leaking.
After driving it for 3 weeks I still feel a little rattle or clunk when driving over ruff roads at slow speeds. I did check the ball joint and wheel bearings while I was in there, and I am certain they are not the source of the noise. I also checked the strut mount when I transferred it to the new strut, and while it appeared and felt ok I think it is the most likely cause of the remaining rattle and clunk.
Any aftermarket strut mounts for this particular model year? I have looked at RockAuto and they have a Moog Part # HYSB9816. This part claims it is for the European builds. Is there really a difference for this particular part?
View 4 Replies
I have less than 1000km on my new 2014 XTR SC. I had an AS 2.5/1.5" kit installed and a wheel alignment. There is a dull clunk in the rear when driving slowly over rough terrain(dirt roads n potholes). It happens occasionally when taking turns at lower speeds too. A friend who is a mechanic installed the kit and its the 4th kit he has installed for me. Never an issue.
The truck had to go to the dealer to have the remote start installed and they investigated the clunk and tightened up some nuts and bolts and its still there. They blamed the leveling kit and said its normal sometimes. This is definitely not normal! I've searched and can't find anything.
View 14 Replies
I am after a annoying dash noise that I get when driving over any rough surfaces. I have removed all centre console and glove box and everything else around that area and I still have the noise, its like the dash is loose some where else, I have looked around for a complete dash removal instruction thread, but can not find anything??
It looks like I will have to remove the whole dash but really could do with some instructions on how to do this as I don't want to break anything!
View 4 Replies
My 2007 Santa Fe with 48K km developed a clunk in the front end that was most noticeable when traveling under 30 km/h. I made an appointment with West Edmonton Hyundai. This was not the dealer I purchased the vehicle from as I moved to Edmonton after I purchased the vehicle. The dealer had it fixed up within 3 hours....both sway bar end links were worn out. Just wanted to point out the good service I got. The entire bill was covered under the standard vehicle warranty.
View 19 Replies
Got a 2007 Santa Fe CM (Europe) with 160k km. I'm currently trying to figure out how to fix the clunk noise in the front of the vehicle. I am aware about the TSB 12-DS-002 where they recommend changing the drive shaft washer, but since that's a lot of work I want to make sure that this is really the problem.
The noise is not always there. Sometimes you can hear the clunk when decelerating, but not always. You can also sometimes hear a clunk when going from D to R. It sounds like a driveshaft has some play, and a change in the direction of the force causes it to slam into the other side. However, you can't feel it, so there is definitely not a lot of force behind it. You can only hear it.
However, I asked some guys to shift between R and D while I'm outside so that I can figure out where the sound comes from. However, murphy's law, it didn't made any clunk. And after shifting between R and D for like 20 times I felt bad for my transmission and stopped it.
The clunk is not always there, just sometimes. It doesn't really make sense to me, if its really play in a driveshaft it should be always there? Also the clunk started at about 155k km, now I got 160k.
Is there any further diagnostics I could do?
View 5 Replies
I got a few clunk noise from front left tire area. I think it happens when I turn my steering wheel to left almost max.
And then, turning back to straight(to right). then, "Clunk"!
Today I got the clunk when I made U-turn on a street. A month ago, I heard it when I parked with fully turned front tires.
View 6 Replies
I have an RX 450H and noticed that there is a squeaking sound coming from the dashboard. I looked at other posts where people were experiencing similar issues and noticed one post where someone had a GS 450H and fixed this issue by adding felt between the dashboard and the windscreen.
I would like to know whether this method works 100% and whether I can apply this method to the RX 450H. The noise becomes worse when it is cold and especially when the car is being driven over rough road surfaces and speed bumps.
View 5 Replies
I have a 2007 2.7-liter Santa Fe with 71,000 miles. I experience intermittent rough idle and rough low speed driving. It seems that in town driving will trigger these conditions. And when it's warmer outside that oppose to colder temperatures.
In most cases I can turn the car off, and after 2-5 minutes, start it right back up and the problem with go away.
The OBD codes are P0276 and P0306.
I have replaced the coil and injector on #6 cylinder.
The #6 spark plug is dry when the problem occurs.
I had the dealer update the ECM software
View 5 Replies
Just had control arms all replaced under warranty and it's still making chattering noises in the front suspension on broken rippled surfaces same as before ?? Front shocks were also replaced 6 months ago ...
View 14 Replies
I am happy to own a Hyundai Santa Fe (2009) 2.7l which originally originated in the US. It is a really nice car, however, it recently over time developed the problem, which causes some pain - firstly it started with rough idle (pulsating), now it began to stall from time to time when decelerating.
[URL].....
I tried to plug a OBD reader and here's what I get (well, that's a "pending" fault, but still might be useful).
I tried to browse around the internet. I believe it is unlikely that 2 oxygen sensors fail at the same time. It could possibly be caused by vacuum leaks or faulty MAF. Is it a common fault among Santa Fe?
View 10 Replies
I have a 2009 SantaFe Diesel and am having a few issues.
Firstly, of late it has been running rough when I back off the accelerator but hold the current speed. Almost like a mis-firing feeling. AT about 1500 RPM
Secondly, I was driving down the freeway recently, the car started to labour going up a long hill, so I tried to kick it back a gear using the accelerator but it wouldn't do it. It stayed in top gear and struggled. I had to manually do it with the gearshift.
About 12 months ago, I was having problems with the car completely losing power on a quick takeoff from standing still (say at a roundabout) but that seemed to fix itself.
View 6 Replies
I have a 2012 Santa fe SE that with 22k miles on it. I have developed an annoying rattle in the back driver side door. I have gone around all of the doors with a screwdriver and tightened up everything but this rattle persists when driving on moderately rough roads. As odd as it seems I believe it also occurs more frequently on smooth roads when going around a left curve.
View 10 Replies
The car started rough idling and a few weeks ago while driving "lost power" momentarily. I went to take a look at it and even just idling it will randomly drop 1000 rpm, or when the gas is one in P it does the same thing. also the dash lights dim at the same time.
I pulled these codes (below). I cleared the codes and tried to replicate with no luck. The car had been sitting in a parking lot outside for a few days and it has been -15C. I asked if it seemed to only happen when it was warm (the week before it was +10C) and they said yes. It has been another week (still cold) and the codes have not returned.
Quick google of these codes suggests maybe a throttle position sensor and/or loose battery connection.
View 8 Replies
My 2009 santa fe (about 30k miles on it). I am hearing an intermittent screeching noise from the front right wheel area when driving at normal speeds. It seems like it might be brake-related because the screech stops when I apply the brakes.
I think worn pads should squeal when braking not driving. What causes a metallic screeching when the brake is not applied?
View 10 Replies
Front wipers stopped working while driving. trying to trouble shoot problem. wondering what fuses to check?
View 2 Replies
I took my 2009 Santa Fe Limited to my dealer this morning to have them take a look at a click / pop sound that I was occasionally hearing from the front. They inspected everything and did not find any issue and could not replicate. No problem...they did not charge me for the inspection. Great.
So I'm driving home and while making a left turn, all of a sudden my Santa Fe stalls without any warning in the middle of the turn! No audible warning what so ever...just a dead pedal, stiff steering wheel and little braking power. The electrical seemed to be fully working, as my radio and instrument panel was working.
When I had drifted to a stop, I checked my instrument panel and I saw the following indicators:
Immobilizer warning light
Check engine malfunction indicator light
Low oil pressure warning light
Charging system warning light
So I immediately call back my dealership and they ask if I'm able to start the car back up and drive back to the dealership. I start the car back up without issue and drive back.
They bring the car into the bay and hook it up to run diagnostics. The results show no errors??? No codes were thrown??? I have a copy of the report. I don't understand how nothing was captured?
CM series 2009 Santa Fe? 108,000 kilometers. I'm really concerned that this happened without any warning and no digital record or log from the diagnostic. What if I did get into an accident because of this stall and had no way to prove that it was not my fault?.
View 8 Replies
Turns out the brains of the transmission are not working. Valve body to be replaced under warranty. We were getting severe Clunk between 4and 5 gear and 5/6. It was more pronounced going up hill and when towing. Actually scared me a few times with severity of the noise and shudder of the vehicle. Will take a week for parts and warranty work to be done. I assume it is a very expensive undertaking.
View 2 Replies
I bought a 2011 Hyundai Santa Fe with 30k miles about 3 weeks ago. It is the 2.4 Cyl, non AWD version.
I noticed this noise while driving from ~0-20 MPH. A light whining, strained noise from the front end.
I brought it to my Hyundai dealership and they took a ride with me, and acknowledged they noticed a noise too. They changed power steering fluid once. Still heard the noise, so brought it back for 2nd time, they changed power steering reservoir, still heard the noise and brought it back for a 3rd time.
They now say there is nothing wrong with the car. Between 2nd and 3rd time, when pre heating my car on a couple of cold days, I noticed there's an even worse noise while parked in the drive way. I told them about this. Is this noise normal?
Here is a video : IMG 0662 - YouTube
View 15 Replies
I had a eureka moment the other day when braking over a rough surface and I think I've worked out why the Prius (and other hybrids) feels like it skips more than other cars when braking on a rough surface. It only occurs on light braking, i.e. when on regen, it's because the rear brakes are not engaged. A normal car would have all 4 wheels braking so if the fronts let go momentarily the rears hold the car steady.
View 19 Replies
