Santa FE SM (2001-06) :: Strong Smell Of Fuel From Under Car But No Visible Leak
Oct 22, 2011
I have an Oct 2001 2.7 GLS which apart from the odd ABS Tone Wheel and speed sensor issues has been uber reliable and a real pleasure to own (I've had it from new).
We had a problem about a year ago when the wife didn't get the fuel cut-off when filling up and over filled the car resulting in fuel pouring out of the tank vent and down the fuel tank under the car but after a long drive that cleared up and has not happened again. Interestingly we didn't get any engine CEL's or have any codes turn up at all when checked by my mechanic.
Over the past couple of weeks we have noticed a very strong smell of fuel under the car around the fuel tank. I can't see any indication that there is a fuel leak but have noticed when filling up that the smell is very strong and as the car runs the fuel down the smell reduces to almost nothing.
Today I removed the rear seats and the fuel pump access panels to see if there was any seeping around the pump gaskets but couldn't see anything and the top of the tank around the both pumps was a dry as a bone. Using a torch I did however notice that there was a darkening of the fuel tank surface in the centre which I guess is close to the vent valve, part 311990b:
Or maybe is where the fuel vent pipe runs to?
View 2 Replies
Advertisement
I have a 2007 Hyundai Santa Fe with 83k on it. For some months now, I have always been smelling strong fuel scent in the cabin. I took it to the workshop and was told it's my fuel canister so i handed money to the Mechanic to buy one to replace it. He called back to tell me he cannot get one to but can work on it by blocking the pipes or lines. I am not that convinced because i know the canister is there for a purpose so if he goes ahead to block the pipe or whatever, then it means something else can go wrong in the interim; but I'm in a quandary now and want that fuel scent to stop.
View 1 Replies
I bought a 2004 Santa fe with the 2.4 engine not running. It will not get spark, it is getting fuel I can smell it strong after cranking...It has a new crank position sensor, I took the timing cover off to verify. Whoever put the sensor on cut the wires and soldered/ heat shrink them back together obviously because they didn't want to remove the timing belt. It Also it has a new ignition failure sensor, all fuses are good, there was a spare computer in the vehicle which I tried still no luck. I took loom off and looked at the harness and can't find anything.
View 8 Replies
Well, I have the dreaded transfer case leak on my 112000 mile 03 2.7 santa fe. I have just returned from a 12,000 mile trip through Canada, Alaska and then back to Colorado. During that trip I was smelling a burning oil smell and after I came back I traced it to the transfer case. I think it is leaking both from where it mates to the drive train and a one inch seam along the transfer case plate.
It has leaked there for some time(and I had been diligent about filling it up), but this extended trip it has has been more bothersome. I called the local Hyundai shop and they want $1100 and won't guarantee a fix. Is there some product I could use on that one inch seam externally to stop the leak (I know that wouldn't seal the circular seam around the drive shaft)? I kept very accurate gas records and averaged 25.6 MPG for the whole 12k trip running from 55 to 65 MPH.
View 20 Replies
The last 2 times I have filled up at the pump and started driving from the station there is the strong smell of raw fuel in the cabin while driving and on the highway as well even with the windows down. It slowly dissipates after driving 5 miles or so and does not occur again until the next time I fill up. What it can be?
View 1 Replies
Today while leaving work my car was giving off a strong fuel smell. Wife noticed the garage stunk of gasoline when she got home.
I removed the engine cover just now, and ran the car and checked for any leaks around the fuel rail area, but didn't notice anything.
View 14 Replies
So I had my sikky headers installed about 3 weeks ago by JE import. Since then they have been a constant hassle by installing a faulty O2 simulator which made me have to get in the car yet again drive to them an hour an a half away.
After another week I got CEL for a second time. After they fixed the faulty O2 sim....
Recently I have noticed a very strong fuel smell while driving. I understand you might get a fuel smell while at a light and the windows are down but I am experience one at cruising speed. I have gotten my car lifted three times in the past week to tighten the flanges connecting to the joeZ as well as checked for leaks (none were found) and there still is this strong smell
I do not want to install high flow cats.
View 12 Replies
I'm getting a strong fuel smell inside my car typically after i fill the tank regardless of how much i fuel i put in. What could be causing this?
View 4 Replies
My wife was driving to work today and she called me when she was almost to work and said that when she was at the red-light and said when she started from the red-light the car was fine and she hit a certain rpm and the rpm's dropped and there was a strong smell of fuel. The car was still running and would idle fine but was running almost like it was flooded or had a miss like a coil pack or spark plug. There was no check engine so I am not sure I haven't got to look at the car yet.
I forgot to mention a few months back she had a check engine for the intake manifold runner flap called the dealer and set up an appointment to take it in. Took it up and by the time we got there the check engine was off and car was running fine no issues. They said no sense in bringing it in now just set another appointment if it comes back on which it never has and still isn't on but I am wondering if this problem is related to that? I know for sure that the car is still covered under the enhanced warranty for the injectors and intake manifold.
View 6 Replies
Ok, 04 Passat, 1.8T AWM
CEL is on for po456 (very small evap leak) and every time I fill up on fuel, I can smell a STRONG fuel odor, from near the fuel neck, and inside the car. Stops after it hits around 3/4 area. No leaks, and the car runs fine. Gas cap, and N80 valve were just replaced, both parts are from the dealer. I'm going to bring it in for a smoke test soon. All recall notices have been done too, I just did the timing belt.
View 1 Replies
My dad's Camry (which I also drive), has been having a problem since a couple of months now. Whenever I floor the vehicle, you can feel the power kick in but after a couple seconds you can feel a slightly lack of power. Its not like the car doesn't accelerates, but it does feels like if you release the pedal a bit.
The car also has the following issues:
-Shifting problems: The car has been having shifting problems due to the automatic transmission fluid temperature sensor (don't know if this may cause the ecu to go in some sort of "emergency mode" and reduce the power a bit)
-Strong fuel smell after driving: After some driving, you can smell fuel mainly at the back of the car.
I'm thinking in about changing the sparkplugs as we have never done it to the car. Car has 80.000km (50.000 miles) Car is a Toyota Camry 2007 V6 3.5 2GR-FE
View 8 Replies
I have a 2002 Oldsmobile Silhouette which has been a great car, but due to its age has had some issues in the past year. The most recent is that it does not start well. When I turn the key, it chugs but I have to push the gas to get it to start and then there is a very strong fuel smell. We had it "tuned up" recently, but that did not work ( in fact the starting has gotten worse).
View 1 Replies
On a recent long drive home through some very hot weather, I noticed a strong smell of gas at the back of the truck. Now, I've caught a whiff of gas before the trip but it was always faint. Figured it was some gas that dripped on fill up.
At a rest area, I go and look around see no leaks and finally check the fuel cap. Lots of pressure trapped. I ended up leaving the cap off the rest of the run home. Can't find a cause.
View 5 Replies
03 Baja, 4cyl, automatic. 195,000+Every now and again I get a fuel smell. Full tank, empty tank, half a tank... doesn't seem to matter. Usually switching up the gas I put in clears the issue. This time, not so much. Really strong and causing me to banish the car for the garage due to it stinking up the house.The odor MAY be coming from the left/drivers side of the car. (I only say this as if it is outside in the parking lot, I notice it more on that side.
View 4 Replies
I have been smelling fuel on and off for the last few weeks. I thought it was the fuel bowl drain valve so I ordered the kit for the whole fuel bowl from diesel o-rings. I did the rebuild this morning and I don't see any visual leaks. Still smell a strong odor of diesel though. The lower engine cradle is all wet and the valley is still a little wet too. Could I still have a leak and if so where to look? Could it be just wet still from draining the fuel bowl and needs time to go away?
View 14 Replies
2001 LS v8 .... What would cause the car to give off a strong smell after changing the plugs?
View 5 Replies
I let my sister borrow my 1995 4 banger Ford Ranger for about a week. To make a long story short, when I drove it home I could smell a really strong gas odor so I pulled into a gas station and noticed gas pouring out of from what looked like the fuel filter area right under the driver's side.
Anyway, it took another 5 gallons to get home and I later crawled under and took a look. It looks like someone grabbed the fuel line and tried to unsuccessfully pull it out of the fuel filter by hand. I could literally see the imprint of the person's hand where they grabbed the line. They had pulled the line so hard that it crimped and split which is why gas was leaking like a water hose.
I picked up a Ranger specific Dorman fuel-line repair kit from Advance and had my brother install it for me as I'm no mechanic. It was fine for a few days and then I started to smell gas again so I crawled under and took a look. There's just barely a small leak coming from the connector barb/union on the kit. Anyway, I didn't know what else to do so I dropped the Ranger off at a local shop this evening. With that said, this is fixable, right?
View 2 Replies
Every time I start this car there is a strong smell of gasoline. I've already checked for leaks and didn't find any. Could this be caused by the fuel canister in the rear of the vehicle this has gone bad?
View 2 Replies
I have no problems pumping gas in, but the entire car cabin smells very strongly of gas after filling up. It seems to come from the area of the charcoal canister. No dripping of gas, no puddles... Did a smoke test, no leaks showed up anywhere (according to the mechanic). I do not want to start throwing parts at this to fix it - where should I start, and in what order should I throw parts? 2003 elantra GT sedan, 70k ....
View 1 Replies
OK so I have a 2010 6.4 fully deleted. I have noticed that after driving my truck and parking it there is a strong coolant odor but no steam or visible leaks. the truck runs as good as ever and I can't seem to find the source.
View 5 Replies
My wife has a '13 Santa Fe 2.0T, and every now and then it smells of raw fuel. It's happened enough that I really think its her car and not some other one that close. 6k on it.
View 21 Replies
