Santa FE SM (2001-06) :: Slow Start And Burning Rubber Smell
Nov 18, 2011
Vehicle:
01 Santa Fe LX 2.7 AWD w/112k miles
Symptoms:
- Slow Start (when cranking takes 2 full seconds before it will turn over and you can hear the engine cranking slower, use to turn over right away)
- Very Strong Burning Rubber Smell
History:
Last January it got down to -20 here in Albuquerque and I would have to go to work at that time. About a week later (when it was still getting down to about 0) I was driving home from work when I smelled a slight smell of burning rubber. I thought it was the car in front of me. The next day I had the same thing. It continued for about a month till the temps rose a bit and then went away. I could never find the cause. I then went all spring, summer, and fall without any problems on my Santa Fe.
As the temps begun to drop over the past 6 weeks we started to smell the burning rubber again, at first only when I would start the car till it warmed up. About 2 weeks ago the car started cranking slower and would take longer to turn over and within the past week I can smell the burning rubber smell even when I had the engine at temp. There's not any idiot lights on. The car is running fine except for what was mentioned, gets up to temp and stays there (a little below the middle on the gauge like normal). I pop the hood and looked at the belt, looked good (no cracks). Checked all the fluids and the only thing that's low is the coolant.
View 4 Replies
Advertisement
Today I noticed a strong burning rubber or plastic smell coming out of the right rear wheel well. All other wheel wells did not have this odour.
We had a bout of freezing temp's here recently and some snow, I'm wondering if the brake on that wheel may have seized slightly through the all wheel drives tourque vectoring or through parking brake use.
I'm going to drive it to the dealership tomorrow without making an appointment in hopes they will look at it right away as making an appointment this time of year is probably going to take forever.
Something I might be missing or can do?
View 55 Replies
VW Passat Wagon - When I drive, every once in a while, I get a smell like burning rubber that last for about 2 minutes and goes away....what's the symptom? Is my exhaust system starting to go?
View 1 Replies
After my Camry XLE V6 warms up to temp it starts to smell like burning rubber - my wife states that it smells like burnt popcorn. I bought the car and I believe it had been driven for quite some time with a bad upstream rear O2 sensor - when I hooked up my scan tool to it, it showed as a bad o2 and miss on #3 and #6 cylinders - I replaced the coil pack feeding #3 and #6 and runs smooth - put a Denso OEM o2 sensor on the rear and still has a miss code but not an emissions code - still smells like burning rubber - I figured the smell was coming from the bad o2 and it running bad AF mixtures.
I figure that if the catalytic converter was plugged or needed replaced that I would get a code for it. I noticed a bit of oil around the valve cover gaskets so I gave them about a 10th of a turn down to see if it would stop the leak and steam cleaned the oil off the motor - still smells of burning rubber - car has never had the timing changed or drive belts for that matter. Drive belts look good, I will have them changed the next time serviced but I'm not sure about the timing belt...car has 218,000 miles but looks great - serviced regularly - bought from my dad and his cars last forever - what this could be?
View 5 Replies
Resurrecting this 2001 2.7l, I noticed the horrible gas mileage.
I'm thinking o2 sensor, but it doesn't throw a code... Anywhere else I should look? I've changed Crank Position Sensor, Fuel Pressure Regulator, plugs, and brakes.
One note, when the a/c is turned on, I can smell a burning kinda smell. Maybe the clutch on the compressor is going out, causing some parasitic type of power loss? idk. Car seems pretty peppy now that it has a new CPS.
View 9 Replies
My car has a vibration that translates up through the steering wheel. It occurs intermittently at varying speeds, from 1-3 minutes, and then goes away for awhile. The tires, CV joints, struts, and mounts were all checked and OK-ed by a car mechanic. There is also a burning rubber smell that I will notice after several minutes of driving. In addition, when I engage the car into drive their is an audible deep clicking sound as if something is engaging or breaking free from a stuck position. This also sometimes occurs when moving forward from a stopped position. The car has 160K miles on it but its been well maintained.
View 4 Replies
2002 Santa Fe V6
Ran the AC yesterday for the first time after a long cold winter. Seemed fine for about 15 miles but then I came to a stop and all of the sudden smelled burning plastic/electrical... white smoke started blowing out of the vents. Pulled over, popped the hood. The smoke appeared to be coming from the passenger/rear side of the engine.
Drove it another 15 miles home (had to) but with no AC or even fan on... made it and noticed the smell and smoke but only very little.
This morning I started it up .. got under the hood and clearly can smell it coming from the same area. That is the alternator at the back of the engine passenger side right? Voltages read fine... seems to be charging ok as well.
The only indicator that it is going bad is of course the smell and smoke... I can feel it is getting very hot.. too hot to touch after only a few minutes running. Spun bearings in it maybe? Just thought I'd put that out there before I start tearing it apart.
View 9 Replies
I was driving around running errands when my AC stopped blowing cool air, a funny kind of "metallic" burning smell was coming from the engine, and there was a slight knocking noise that was apparently coming from the engine and would go faster as I accelerated.
My car is still under warranty so I know stuff will be covered. My question is : what the heck is going on with my Santa Fe? I need to know whether I should call into work or drive it anyways.
View 1 Replies
Well, I have the dreaded transfer case leak on my 112000 mile 03 2.7 santa fe. I have just returned from a 12,000 mile trip through Canada, Alaska and then back to Colorado. During that trip I was smelling a burning oil smell and after I came back I traced it to the transfer case. I think it is leaking both from where it mates to the drive train and a one inch seam along the transfer case plate.
It has leaked there for some time(and I had been diligent about filling it up), but this extended trip it has has been more bothersome. I called the local Hyundai shop and they want $1100 and won't guarantee a fix. Is there some product I could use on that one inch seam externally to stop the leak (I know that wouldn't seal the circular seam around the drive shaft)? I kept very accurate gas records and averaged 25.6 MPG for the whole 12k trip running from 55 to 65 MPH.
View 20 Replies
I am experiencing a strange rubber burning smell coming through their vents.
View 5 Replies
I have a 2001 Toyota Avalon with 139,000 miles and runs excellent. I recently just got an oil change and it smells like something is burning. More of like a burning rubber smell. I know my car does not have an oil leak but what else could it be. I plan to take it out of town very soon. Should I not take it anymore? Also, when my A/C is on and I'm sitting idle it sounds like my car wants to turn off every time the the a/c kicks on but it doesn't. My RPM'S are fine. (600-700).
View 18 Replies
Having rubber-like burning smell from the rear-right of 2009 Sonata?
View 4 Replies
I was driving my car today and it started driving like the brakes were on. It started to smell like rubber was burning. Before that I stopped at a traffic light and the car pulled to the left. Is the little car dying. 1999 ford escort zx2...
View 15 Replies
So I had been smelling an electrical/rubber burning smell on the Ex about a month ago. After a week or so I popped the hood and poked around. This is what I found!
Now I had a no start in May. The shop that I had it towed to checked the wiring harness, replaced the cam sensor, scratched the truck up and ran through 2 tanks of fuel.
I repaired the harness and all is good. What the 3 wires run/go to.
One was solid Gray with a white stripe.
One was solid Black with a yellow stripe.
One was Tan with a green strip.
View 10 Replies
Had this problem yesterday and drove my car home about 3 miles running very rough and very sluggish! I could smell something like burnt oil or rubber when I stop but not too bad_no smoke. We are at a ski resort and will have to drive our vehicle about 70 miles to nearest vw repair shop. Is it ok to drive my passat with this rough condition? I am guessing ignition coil or spark plugs.
View 4 Replies
Took the car on the hwy earlier today. A/C was on and wss going about 60 mph when all of a sudden I got this horrible burning rubber smell inside the cabin.
I exited the freeway and the smell eventually subsided. I'll try again tomorrow to see if the smells comes back.
View 14 Replies
I have a 2007 Sonata V6 with 198,000km (123,000 miles) and when I was driving yesterday I smelt a burning smell like burning rubber or plastic. The smell seemed to go away after a while and I was wondering what could have caused it?
View 2 Replies
Over the past 6 years, searching for this problem--burning rubber smell coming from the heater in y 2003 Baja. Not so bad if the re-circulation is on, not so bad outside the car, can be smelled beneath the hood, but unbearable inside. It isn't plastic, oil, fluid, gaskets, wiring, it's rubber, like burning tires. Was barely noticeable when I bought the car 6 years ago, making me think it was just the tires, but it has gotten worse and worse and worse. Sometimes it takes 50 miles to happen, sometimes two, but when it does, I have to open the windows or shut off the blower.
View 10 Replies
While driving my Montero sport last week, I began smelling a burning rubber smell from the air vents. At the same time I noticed, on the dashboard, that both the brake, and, battery indicators had lit up. There was no smoke, mist, or off sounds, coming from the engine, and, the engine seemed to be running no differently than before this occurred. I drove home, parked the car for 5 days, and, yesterday visually inspected what I could see, which was almost nothing unusual. I started the engine and let it run for about 10 minutes in park.
The engine ran normal, no noticeable knocks or pings, no shaking of the engine, the belts ran smooth, no noticeable leaks of any kind. I checked all fluids and they were at normal levels, only the power steering showed a slightly lower than mid level of fluid, not anywhere near low.line. But, as soon as I started the engine, the dashboard indicators lit up and stayed on. There was only a very faint smell of rubber at the end of the 10 minute running of the engine, barely noticeable. The only thing that I did different recently was about 2 weeks ago I added a quart Pennzoil high mileage motor oil 5-30 instead of the usual GTX high mileage motor oil 5-30 that I usually put in the engine, as there was none available at the store. The auto has ran very well for the past year.
View 4 Replies
Noticed a smell like rubber burning about 40 minutes into driving my car today. When I turned off the heater it went away. What this may be? Possibly the last legs of my heater melting away?
View 6 Replies
I have a new 2013 Hyundai Accent (automatic, 4 cylinder) with less than 1500 miles on it. The day I drove it off the lot and up until today, it randomly smells like burning rubber. It happens whether it is hot or cold, driven two miles or thirty miles. The smell is coming from under the hood but I know very little about engines, so I'm not sure what it is. I have told the dealership and they don't seem to care. I may not know much about cars but I know that that smell is not normal, especially in a new car. What could be causing this...
View 7 Replies
