Santa FE SM (2001-06) :: Rattling Noise At 3500 RPM
May 15, 2010
So, I recently got my car serviced with balance shaft belt, 2 idlers, crank sensor, timing belt, spark plugs, ignition wires, and ignition coils. And now when i drive my car and accelerate it to about 3400 to 3500 rpm i get this rattling noise from my engine then when the rpm surpass that range i dont get any noise anymore. I really don't want to take it back to the shop and have to be charge for a diagnose but I am thinking it could be serpentine belt or loose of the down pipe.
View 6 Replies
Advertisement
Codes currently on ecm: P0134, P2125, P1174, P0735 My 2003 Santa Fe 2wd 3.5l with 160,000 miles was driving fine, then all the sudden whenever I reach about 3500 rpms there's a grinding noise that sounds like its coming from near or in the automatic transmission. As for the codes: P0134- I just replaced the o2 sensor with an oem part from autozone, so not sure why that's popping up. The connections look fine. P2125 and P1174- I'm trying to figure out whether the accelerator position sensor or throttle position sensor needs to be replaced. I have a multimeter but don't know if that will be able to tell me which one is out. The P0735 gear 5 incorrect ratio and grinding noise at 3500 rpms is what I am mostly worried about though. Could a transmission flush work with that?
View 2 Replies
I have a 2004 3.5 V6 that is making a rattling noise when the car is in idle and/or about 1rpm. Sometimes, for awhile now , it kind of screams when I first start it...but not all the time. I know this is a loaded question but what do you think it might be? The screaming noises don't happen all the time, like I said, and very rarely happen together but the rattling is happening a lot!
View 1 Replies
2004 Santa Fe AC fan has started making a rattling noise. It gets louder when the fan is turned up. How can I check it? Noise seems to be under the glove box.
View 3 Replies
I have this problem with my 2001 Santa fe 2.7 Lt auto done 326,000 km no power on hills sometime want rev past 3500 revs and sometimes will rev past this, it seem to get worse when fitted new fuel filter in the tank? have put new filters and O rings in injections, have just fitted new coils and the cat has no restriction. Starts first time but did have trouble the auto would not start in park until pulled top cover and got it out of park and started it in neutral changed the trans fluid and seems to move through the selection better. Could it be the fuel pump??
View 4 Replies
I've got a couple of issues with a 2002, 2.7ltr v6 santa fe first off when taking off steady the car runs fine but taking off quickly it seems to lack power until it hits around 3000-3500rpm est then it takes off fine and all threw the upper rev range the auto seams sluggish but I'm not shore as I haven't driven another 2.7ltr as a benchmark. No error codes are present.
The second issue I brought a new keyless remote for the car and looked up a thread on how to program this they had reference to a set switch behind the fuse box behind the lower dash panel I went looking and found what I think is the remote receiver it has what is like a antenna cable plugged into it but no set-off switch at all is there any way to get this new remote programed or will it have to be done threw dealer or is there something I would be missing?
View 9 Replies
Usually happens after car is warmed up. Rattles only while stopped and transmission still in drive. If I shift into Neutral or Park, rattling stops.
Last time I had a problem similar to this, dealer said it was a heat shield making the noise and they said they removed the heat shield (didn't specify what the heat shield was for.
Now I'm wondering if the heat shield was removed, what else this could be now...planning on taking it in in a few days.
View 2 Replies
My 2003 Sante Fe has developed a rattling sound in the engine. The oil level has been good. I took it to a dealer for diagnoses and they told me that the engine was gunked up and the timing "chain" tensioner couldn't move to keep it tight and it was rattling. They put some engine cleaner in and changed the oil and wanted me back in 500 to clean it again. I did that again, but the rattle is still there. It gets a little quieter after I have driven it for a while.
My question is doesn't the Sante Fe have a timing belt? If that is the case what do you think the rattle is?
View 6 Replies
My mother has a '04 Santa Fe 3.5. Her automobile makes a rattling/grinding sound when around 1000rpms/idle. However, the sound disappears when accelerating and drives like a charm. The sound returns once again around 1000rmps at idle or stop. I have changed the oil pan, replaced oil and filter and even put in a new battery. I'm not an aficionado when it comes to Hyundais (Subaru driver here).Car also has 180k miles.
View 6 Replies
I bought a 2002 santa fe last week. it was a non runner. the previous owner said he took it to the garage for a crank oil seal leak. when he went to collect the car they had removed the head saying oil was leaking from the gasket. he towed it away and i bought it. i have refitted the head. the engine runs smooth at idle. when i first start up in the morning there is a loud rattle for a second or so. it sounds like a diesel starting up. when i am driving it hesitates and seems to lose power. also at a certain position on the accelerator pedal this rattle is there. it goes away when i accelerate more.
View 12 Replies
Santa fe developed a noise underneath that rattles up to the gear shift. It happens mostly when you take your foot off the gas but can happen if your just cruising. Engine does not make any noise while revving it or under load in drive with foot on brake. Definitely sounds rotational but all looks ok underneath.
View 2 Replies
Over the past month, I've started to notice a rattling noise/ticking coming from the front passenger door/"B" pillar area of the SFS. More so on bumpier roads... so I'm sure something has come loose somehow....
View 42 Replies
I purchased a brand new 2014 SFS 2.4L Luxury just a week ago. I have noticed rattling/ticking noise coming from the driver side door. If I press againt the door with my elbow, the noise stops.
And here is the weird thing, I can hear the noise in the morning when the car is cooled overnight (parked in underground garage). But it does not happen when the car has been parked under the sun for a long period of time (in 25C/77F). So basically, I hear it on my way to work and it disappears on my way home.
View 22 Replies
My 2001 SL2 is making a lot of rattling noise. I think I have isolated it to the A/C compressor. I noticed that on the back side of the A/C clutch the plate where the signal wire connects into is very loose when the A/C is not on. The noise seems to be loudest when the A/C is not on. But when I turn on the A/C, that plate tightens up. But the noise continues. Could it just be the A/C clutch or a bearing or something? Or is the noise coming from somewhere not even related to the A/C? The A/C still works really well. I just notice the noise.
View 2 Replies
When i accelerate there is a loud rattling noise from under the car it seems. It sounds like pots and pans banging together. I does not do it at idle only when u accelerate hard.
It does it in all gears even neutral. if you rev the car in park or neutral with your foot on the pedal steady it does not make the noise. only if you push the peddle quick and let go.
What could this be? It started after i brought my car in to DUNN TIRE for a rotation.
I called them and asked for them to check the noise and the guy denied me and said they don't do that kind of work. only tires and brakes!!!!.
View 2 Replies
I have an older 2001 Honda accord I4 about 160k miles on it. I recently noticed that there's a rattling sound when the car in in idle (800RPM) but it disappear when I rev it up to higher RPM or while driving. The noise can't be heard inside the cabin and can only heard outside. The noise also only appears when it is warmed (engine running for about 3 - 5 minutes after cold start). I read from other board about a loose or worn out heat shield so I went under the car and try to look for a loose of broken parts but I cant find any. I removed the cat heat shield but the problem still exist. I don't know what else to check. Car seems run normal, I don't notice any change in performance and no check engine or what so ever. I just wan't to make sure it is not something on the engine, transmission, or something that will snowball to a bigger issues. I don't know how long its been rattling but I just noticed it the other day.
View 11 Replies
At the above speeds my truck has a rattle/ticking. I think its the cats but I'm not sure. I checked all the obvious like the heat shields and stuff. The truck has 118000 miles on it and has been in So. Cal. its whole life.
View 6 Replies
Recently I have noticed a rattling noise from the left front strut. Looking up parts online I can see the strut, as well as an upper strut mount, either of which might be the culprit.
View 2 Replies
I have a 2001 Cavalier 5-speed manual 2.2. I have owned it for every day and every mile (204K) since I bought it new in April of 2001. I have had many mechanical disasters and problems mostly starting a couple of years ago - and a lot of them I have worked on or fixed and/or replaced the part myself.
The transmission fluid in this car has never been changed, looked-at, drained, added, etc....because I was told that it didn't need it. The manual says the same thing. For as long as I've had this car, it has had a intermittent rattle noise that I figured was just the "Getrag rattle" - so I didn't pay much attention to it. But over the past year - especially the last 6 months - this rattle has just gotten totally insane and out of control. It is now a constant loud rattle whenever the car is in gear - especially starting out in 1st or 2nd. I mentioned this to someone and they asked when the last time the fluid was changed and said that would fix the problem - and couldn't believe that the fluid had never been changed after 15 years and 200K miles.
This model has no dipstick. There is a big red vent cap and I think I found a HEX plug close to it, but before I go out and buy the wrong size hex key - what size these are and if they are even what I am looking for to fill/check/drain it? So frustrated. Also - since I can't find DEXRON 3 anywhere am I supposed to use this DEX/Mercon stuff?
View 19 Replies
I have a 2011 GTI, with an apr chip and apr intake stage 1. Car is brand new 4000 miles
When hitting boost in 3rd-6th gear i hear a fluttering sound between 3500rpm and 5000rpm after 5000rpm the sound either dissipates or is drowned out by the motor.
I've done a lot of research around this sound and i havent been able to find a certain answer, it could be compression surge (i wouldn't see why), a leaky DV ( also cant see why because the 2011 has the new revision D piston actuated DV), A fluttering wastegate.
Sage 1 apr chip and stage 1 apr intake...
View 8 Replies
So I am new to the VW TDI, and I am hearing some noises I am not used to...
First noise, when the transmission is in neutral, clutch pedal not depressed, I hear a noise from the clutch (makes the TDI sound louder than it really is), if I put the car in gear, the noise goes away (even if I put it in neutral and keep the pedal pressed in), sounds like the pressure plate or clutch could be making that noise, is this normal or not ?
Second noise, when accelerating (especially accelerating hard) above 3500 rpm or so the engine makes a weird muted sound, I can't really describe it, maybe like bubbles of air in water would do, but muted ... it's a weird sound !
View 3 Replies
