Santa FE SM (2001-06) :: Power Steering - Pump Making Whine At Idle
Feb 21, 2014
I have a 01 santa fe 2.7 motor. I have read several threads in here regarding the famous pump whine. my pump is making a whine at idle, I have cleaned the bottle and made sure the screen has not restrictions, drained all the fluid, and have inspected the lines for leaks.
With a stethoscope have pin the noised to the pump, the noise travels in the reservoir when I race the engine the noise is more evident on the bottle. I am tempted to replace the pump, but the steering has no issues and operates fine, also no change in the whine noise when moving left to right.
View 7 Replies
Advertisement
I've got what seems to be a fairly common problem in that my power steering on my 2001 SF gives off a steady whine. I've read in several posts that removing the power steering reservoir and either replacing it or cleaning out the screen solves the problem. I'm ready to give that a shot, but can't seem to figure out how to remove the part. There is a "tab" type of thing on the back of it, but it doesn't seem to do the trick. I'm admittedly no mechanic, but this seems like it should be relatively easy. How to remove the reservoir?
View 6 Replies
I have a 2004 Santa Fe 3.5L with 85K miles. TB, WP and all belts changed at 75K. Have had this whine noise when I turn right, very high pitch noise. On top of this there is now Power Steering fluid leaking from the reservoir and base and brackets are full of fluid... Needless to say I assume it is the reservoir seals giving up but why the noise only when I turn right? No noise when I turn left.
What could it be? Also where can I find parts online that are cheaper than the stealership? I called them and they quoted me $72.00 for this piece of plastic!!
What else should I change? There is also some "oil/fluid" coming down a pressure hose but I believe this is due to the oil dripping from the reservoir...
Any manuals I could use to view this? I bought the Haynes manual and it's worthless!
View 1 Replies
My Santa Fe has a broken power steering pump pulley. Darn thing broke right around the spindle! I can not find a replacement anywhere. I've tried to find a one new, used and at the upull lots (only one Santa Fe in at Pick n Pull dang thing was stripped clean!). The pump is easy to find but this pulley is a ghost!
View 3 Replies
My power steering went out a few months ago. No warning, whining, or hiccups. Just stopped working. Installed a new pump today, and it worked great for about five minutes. Bled it out, put fluid in, etc. Took off on a test drive and a mile up the road I went to turn into a street and power steering was gone.
Fluid is still full, belt is still there, no visible leaks. 2004 3.5L V6.
View 6 Replies
I have a 04 santa fe , which slowly started whining which was diagnosed a power steering pump, when replaced the problem got worse and it became very hard to steer. Steering rack was the next diagnosis, replaced and another new pump. Now its so hard to steer and the whining has returned. Looking in the reservoir the fluid seems to be moving good with no bubbles??
View 3 Replies
So I have multiple issues that all seem to stem from a power steering leak. According to the dealership, the PS pump is leaking fluid onto the serpentine and timing belts causing them to swell. This in turn has something to do with the AC compressor not working but they wouldn't give me details. When I looked at the clutch wheels on the AC compressor, there seems to be a good amount of rust in between the two wheels. I can't say that I trust the dealership because the original owner was bought out by a larger group that is known to just say "replace everything". I usually do most of my own work on my 95 Tacoma, so I'm no stranger to import v6 motors.
View 4 Replies
i have an 04 f-150 with a 5.4 motor. about 2000 miles ago the power steering pump started to whine really loud. I sucked out the power steering fluid and started it up and the fluid that back into the tank looked like it was gritty and rusty. I replaced it out a few times and no change. I then did the job of replacing the power steering pump which was about a 5 hour job.
It was quiet for about 5 miles and the new one started whining. Every week I have been sucking out the old fluid and replacing it and it still seems to be gritty. What could I do to quiet it down? the steering works perfect btw. I am looking at selling this truck and buying an 09 or newer ford and want to quiet it down before selling it. The truck has 88,000 miles on it and i am the original owner.
View 3 Replies
I just noticed a whine in my steering when turning right and left on my 2010 SE. Sounds like I am out of power steering fluid but I checked the level and it looks fine. No signs of a leak.
View 7 Replies
My power steering pump was making a loud whining sound. No problem, changed the pump. Now after the truck is started I will have no power steering or brake assist, give the truck a little gas and you can hear the power steering pump "start". I have tried every way to get the air out, or is that not the problem. I even lifted the front of the truck off the ground with a forklift and with the truck off turned the wheel about six times stop to stop. Fluid level looks good and has since adding after the change.
View 4 Replies
My car is a 2002 Accent. So last weekend I replaced my timing belt and my 3 other belts. Before I did this the belts were not squeaking and I was not having any issues with my power steering. I started my car up and the power steering pump was making lots of noise, the power steering reservoir was still full. I was told it's probably the power steering pump and that I would need a new one. So I got a new one, put it on and still the same thing. I looked online and saw that it may be an air bubble in the line so I removed the cap on the reservoir and, with the car turned off and the front wheels off the ground, cranked the wheels lock to lock about 20 times. I started the car and it still makes noise. This morning the power steering felt like it was lagging as I was backing out of my driveway and the squeaking happens when I am idling and gets louder and worse up to about 2000 rpm then stops, which it has been doing since I replaced the belts. I am not sure what else to do, did I mess up the new pump by driving and not bleeding the air out?
View 2 Replies
I finally have a first 'major' problem with my Camry 2004 V6 XLE right at 75K ish.
The last two days I've been hearing my power steering pumping making that familiar 'whirrrrr' noise. I thought it was just the pump going out because it has always made some noise when it was cold. Lo and behold, I checked my fluid today and found it was completely dry. I knew it wasn't a good thing because when fluids are dry, they must go someplace. Either way, I got a gal of Dextron ATF in the trunk now.
I filled it up and all was good, so I started to look around for obvious leaks. I did find a hose going to a metal line that DID seem to be dripping, but I wanted to see if maybe others had the same problem and found it was to be a different thing leaking/running down or if this is a common issue.
Not sure if the hose is a dealer only thing. It does look like it's leaking from the end. I could get one of those screw tightening clamps to see if the clamps isn't putting enough 'squeeze' on it. I couldn't see a tear on the hole, but I'm assuming it's a high pressure hole, so it won't leak unless I'm doing a lock to lock turn.
View 9 Replies
I have a lexus rx 330. Pump started making noise and low on fluid. We replaced all the belts and new pump. After installing new pump it was leaking from fill cup cap when driving also making a lot of noise on cold start. Mechanic said new pump was bad so we put in another one. Car ran fine as soon as we put it in and bleed good. Following morning again a lot of noise on cold start and noise goes away about 10 minutes but again small amount of fluid leaking from cap on fill cup. I replaced the rubber ring on cap to get a tight seal but again nothing.
View 6 Replies
So I have a 2012 Elantra Limited. From what I understand the power steering is no hydraulics and is only electric assist. So I have a strange problem. I can remember in previous cars when a power steering pump was going bad it made a whining type noise that changed with engine speed. My Elantra is making the same type of noise. I'm trying to track this down. My car doesn't have any other symptoms aside from the noise. It's hard to really tell but it does appear to be coming from the belt side of the motor (passenger side).
View 14 Replies
When I started engine, I heard the high pitched squealing noise for 10~30 seconds. The noise was from the power steering pump. The noise changed by turning steering wheel. I did drain & refill 4 times with Preston dino base PSF & turkey baster. Next week cold day, the same noise was still there, so did drain & refill 5 times again with Preston PSF, but the same noise again.
A week ago, 3rd refill was with MaxLife Dex/Merc ATF that I had in my garage, more than 1 liter drained & refilled. Today at -15 C(=5 F), the noise came back for 5~10 seconds. I feel MaxLife(synthetic base) is better than Preston(dino base), but still several seconds noise make me worry about my power steering system.
Am I the only one hear the noise? Is this noise the start of the pump failure? Is this normal for the extreme cold winter?
View 5 Replies
2001 Santa Fe. 4 Cylinder
It has spark, it will run briefly with starting fluid.
The camshaft, crankshaft, fuel pump and TPS are all good.
All fuses are good.
The fuel pump relay is good.
The FP relay gets power to both the control side and the FP power in side.
If I jump the FP power side of the relay it will get 12v pump to the FP connector.
NO power to the FP cutout switch by the master cylinder.
So, how can the relay be good and the FP get power if I jump the relay but not have power when I put the relay back in? Is the ECU cutting it out as soon as it gets a signal from the relay?
View 4 Replies
Santa fe 2.7litre 2004 240000km... My santa fe won't start, after check we found no power at the fuel pump. we change pump, we found a bad contact at the remote starter connection. we decide to cut the wires of remote starter. after the car start and ride 1 day, stop with check engine, towing
We take off the remote starter and disconnect all wire of this remote starter. The car start and stop. After that bizarre problem, the park light stay open, and the window can be up and don't with no key in the ignition!!!!
We check fuse relay etc, all wire of the old remote starter and we take off battery and rebuilt the ground. We still have the same problem; when we tried to start at acc, everything seam normal but the wipers run at off position and when we turn the key for starting , wiper stop , radio close.
Like we have a ground problem. We change the ignition little baril now we think the computer is maybe dead. I double check all remote starter wire and every thing seem ok !!!!!
View 2 Replies
I noticed over the last week that there was a pretty loud whine associated with turning the steering wheel. I checked the fluid level and it didn't seem low. I added a touch just to make sure. Took it into the dealership today and they called back and told me there's a bunch of fluid on the bottom splash pan. They haven't said what the culprit is yet. 46k miles on the car.
View 6 Replies
I have a 2003 Santa Fe 3.5 liter. I have a bad power steering leak and the dealership says I need
pressure hose
return hose
cooler hose
I've tried all the local car part stores and Napa has the pressure hose but for about $180.
View 4 Replies
I am having a power steering problem with my 2006 santa fe, been going on for a couple weeks and I am stumped on what is wrong with it, what I noticed is turning to the left or right and very hard to turn and sometimes it will be fine and other times its the left or right.. What could be going on here? there is no leaks or noises noted, it has 242,000 kms on it. fluid is full but a little brown and smells a bit burnt. I know it will need a flush but would that be the solution or would it be something else?
View 15 Replies
I noticed that the power steering fluid is leaking bad from a weird spot under the car, it looks like it is coming directly under the drivers seat but I can see any lines. It's an 02 Santa fe ....
View 8 Replies
