Santa FE SM (2001-06) :: Loss Of Power And Black Smoke Out Of Exhaust
Feb 24, 2016
Initially I used to get cutting out of the engine randomly whilst driving which everyone believes is linked to an ECU issue i believe...I added some reddex fuel cleaner and that seemed to clear the problem up for myself which is a diesel 2.2 ...
However I was beginning to have starting issues where i would need to pump the gas to get the car started...I changed the battery and the glow plugs and yet i was still having issues. I had the air intake and filter looked a diagnostic test run both showing no issues and then one day I was driving and suddenly i got a huge loss of power and black smoke out of the exhaust....Seriously i had no grunt and i was a hazard to cars behind me....!!!! It was weird how first thing in the morning it seemed fine but later in the day i was getting this problem over and over again and eventually the car wouldnt start without a jump from another vehicle..
Any how i took it to various garages but in the end i took it to Rockar Hyundai at Dartford (i cannot recommend enough) but simply all they did was look at the fuel filter and saw that one of the injectors were faulty...After changing this the problem still occurred but again only when the car was warm...They then looked at the pipes leading to the injector that was faulty and then found that there was a crack/split in it and obviously when cold it was sealed but when warm was opening and i believe letting in air.... Anyhow they have changed that and the car feels great and no issues...
View 1 Replies
Advertisement
I have a Santa fe 2002 crd 2.0 4x4 and recently had a lot of black smoke and a loss of power when driving, it starts fine but when revving it blows black smoke from exhaust and has no power to pull away, been told its possible turbo problem or fuel problem.
View 1 Replies
I have a serious issue with my 2004 F250 6.0. Pulling a trailer something under the hood sounded like an explosion and lost power and boost. The truck started blowing black smoke from the tail pipe. I could see no psychical damage to anything under the hood. There was absolutely no power but managed to cripple home. What happen.
View 14 Replies
I have a 2001 F450 7.3 chassis cab with just over 100k. I have a new problem... So far on two different occasions the service engine came on followed by a loss of power under a load and white smoke from the exhaust. Took it to the shop the first time, they determined it to be a dirty air filter, which seemed odd since it just happened all of a sudden. They changed air & fuel filter, problem gone- for two weeks..
View 8 Replies
Vehicle details : PASSAT 2.0 TDI 170 BHP DSG - 2007 ... 160KM
Problem:-
>>RPM doesn't climb as it should and esp in the run up to 3 gear and the DSG up shifts too quickly 4th and 5th
>>Loss of power. Pressing the gas pedal during all this leads to lots of black smoke and jerking but eventually the car picks up rpm and speed. Am I stuck in limp-home mode here?
>> No CEL light (yet)
The problem becomes very prominent when the engine warms up fully. Its drivable before that. Driving it in Sports mode is the only saving grace. Note that the car it is nothing like how it should be in sports mode, but feels better. I can hear the turbo whistle only when the engine is cold.
Initially, the Engine mounts were thought to be the culprit (for jerking and then ECU reducing power) and then later the EGR value unit (jerking/pinking and power loss).
Work done so far :
1. Original VW Timing Belk Kit (incl water pump) - September 2012
2. Engine Mounts changed - - September 2012
3. Has been plugged into VAG Diagnostic software and an intermittent error was detected for EGR.So, EGR valve control unit was changed - late December 2012
4. Engine Oil (5W-30, fully Synth) and filter changed three time in space of last 10K KMs after I bought the car in September 2012. This is something I wanted to get done anyway to flush the engine
5. Used injector cleaning additives couple of times -December 2012
6. ECU (error-code) reset procedure, just a couple of days ago. This actually seemed to remove some of the jerking and loss of power, but it appears to be coming back now.
7. Transmission reset - yesterday . Did this anyway although the DSG seems to be fine, no problems with the gear shifts
View 1 Replies
Truck has been running like a champ the entire time I had it. Took it in yesterday for an oil change. They also changed the fuel and air filters.
Drove off the lot and noticed some loss of power. This morning truck still feels sluggish but it is also blowing out black smoke pretty much every time I touch the gas pedal. I am even being super gentle with it. Starting from a stop, I hit 1500rpm and it's blowing thick black smoke as if I was flooring it. Same thing while rolling to get a bit more speed to pass.
View 13 Replies
Today I was riding along and all of a sudden I noticed a loss of power. I look in the rear view mirror and get into the pedal and a lot of black smoke. When I get to where I'm going and stop I noticed the idol was a little loopy. I never saw a check engine light. I have the Edge insight. I had two codes. P1000 OBD System readiness test not complete. P2290 ICP TO LOW.
When I would reset the codes the P1000 came back instantly every time. I parked the truck for about an hour. When I started it back up everything was normal. The power was back and no smoke. This happened two more times throughout the day. I have heard people describe a sticking EGR Valve causing these symptoms. Is that where I should start looking or is the ICP the culprit or something else?
View 7 Replies
So my 1987 Econoline Van was running fine until recently we noticed loss of power going up the slightest of hills and it will only hit 55 max with gas to the floor. Its shooting out black smoke and also dying when we stop. We are getting very poor fuel economy as well.
We got a tuneup, oil change, new air filter, etc. We also had a few electrical issues due to a short we thought we had fixed completely... So I'm wondering if it could be the timing? Cause it'll idle low, then high, then bog down and lose power...
Also was thinking maybe bad fuel pressure regulator or fuel pump....but how would I check this? And since we did experience a short, could we have blown a sensor too?
View 1 Replies
2007 F-350 6.0L, Wife phoned and said that the truck backfired a couple of times and there was black smoke from exhaust. When she stopped at idle there is now alot of white smoke but coolant level looks fine. She has about 200 km's to go before she is home pulling a 20 foot horse trailer with 1 horse.
View 14 Replies
I have a 06 6.0 Powerstroke 6 Speed every time I get on it or even try to get going I have no power and I have pure black smoke blowing out the exhaust somebody told me to change the fuel filters which I did which they were pretty nasty then after I did that I seem to still have the same problem so then they told me to check the EGR valve put injector cleaner in it to clean the injectors which I have not done a gr or injector cleaner yet just wanted to know, what it could be or what I can do to prevent the black smoke I have no power either...
View 1 Replies
I have a 2003 Superduty with 193k miles that is bone stock. I sold the truck to a friend and when he decided to not pay the remaining balance on the truck, I took back ownership. The truck was having heating issues and it set at a mechanic shop for nearly 2 years waiting for a diagnosis on the heating issue. Fast forward to the present and I now have the truck at my home. Heating issue was the radiator but this is no longer a concern. When I went to pick up the truck from the mechanic, the truck started fine. Every other day for the last 4-5 weeks I would start the truck with no problems.
I get the truck tagged and start driving it on a daily basis. I've put several hundred miles on it but the more I drive it, the less it wants to start. Now it's to a point where it only cranks but won't start. I can take a gas rag and hold it in the intake and eventually it will start. Once it's running, it runs great and has no issues starting. But once it sets for 3-4 hours, it won't start without some sort of assistance.
While trying to find the issue, I've found and repaired 2 fuel leaks and in the process I replaced fuel filter, air filter, replaced glow plug relay, replaced batteries, replaced CPS. Fuel pump is working fine. I've tried the ICP test and doesn't make a difference.
The glow plug light or WTS light works so don't think its the GP. The CES light was on. Had it scanned and it was the air bag sensor so no support from the CES.
While I was working on it yesterday and after cranking on it for 5-10 minutes, it would act like it was going to start and black smoke would be coming out from the exhaust. I let it set to cool the starter it fired up like it had no issues.
View 14 Replies
I have 04 santa fe with the 3.5 l engine that just started blowing white smoke out the exhaust. I didn't see any smoke when I test drove it and all. but previous owner said that a/c compressor blown which i replaced etc (but found out it was the connector that was needing to be replaced so still have old comp when doing the a/c compressor i saw it has been leaking from valve cover gasket (front can't really see the rear).
I changed oil on it about a week after i got it looked good then. about 3 weeks after that it needed some oil about a qt low, then just last month i noticed a little bit of smoke nothing big and there was barely any oil in it. (oil light came on)... did another oil change and put 4 quarts of oil in it.. now it is smoking more and more smells like burning oil and something else (oil was real low again put 2 qts in to take it just over half). when i check the oil off the dip stick it does not appear to have any color change (not milky or anything).
I am thinking it could have a bad head gasket too (besides the valve cover). BTW it runs good except for the gas mileage kinda dropping a little bit. very strong doesn't not appear to have any pressure drop in cylinders or miss firing. NO codes showing up. So i am at a loss on what it is. (figure head gasket would case pressure loss). I did notice it was low on coolant but has not over heated (put in about 2 quarts of 50/50 coolant). What it is and why it appears to be going thru so much oil.
View 17 Replies
My dad was driving behind me and said that black smoke was coming out of the exhaust, is this normal???
View 7 Replies
While I was pulling off and boost started to build up I heard a loud "pop' ( sounds like when you disconnected the hose from an air compressor ). After this happen the car doesn't wanna idle or rev up past 2k rpm'ish. I was getting a ton of black smoke from the exhaust and had a very heavy scent of gas. Does this sound like a blown turbo symptoms?
View 6 Replies
I have always seen other trucks blow black smoke with towing up a hill but mine for the most part has not. I pulled my 5er to CO this summer and notice my truck starting to blow black smoke. I consider myself a very conservative driver. I always stay around 65 MPH while towing and never push my truck up the hills. I always try to keep the RPM around 2000 and let the MPH fall where they may until I reach the summit. With the black smoke I'm starting to see what is my truck trying to tell me? It's not bad but would like to fix now before it becomes something more.
2001 F250, 4X4 crew cab, 7.3 with 205,000 miles.....
View 10 Replies
1993 3.0 .... My son's van. He complained of fluctuating and mostly high idle, black smoke from exhaust and stalling at stoplights. He has other wheels so I've had it for several months until I could check it.
I started it every few weeks, it started easily. Have not seen smoke but it did idle high and rough. Yesterday I started it to warm it up to finally pull codes. Temp needle barely moved and upper radiator hose did not get very warm but I pulled codes with engine off anyway and got 116, 10, 111.
Today i got a little smarter and noted that the upper hose began to get warm right after startup. Suspecting a bad thermostat I blocked the radiator as well as I could and it warmed up much more, though still not near the middle of the temp gauge. Shut engine off and pulled codes again and this time got 111,10, 111.
With engine running, got 6, only-- and there's no code 6 in the code reader book. Jabbing gas pedal in neutral it nearly dies, jabbing gas in D and it dies and will not restart until cooled down.
Finally, checked again with engine off and got 111, 10, 110, 10. I think the ETC is OK since I didn't get 116 again but it still idles fast, speeds up and down erratically, and dies. Where do I go from here?
View 14 Replies
I have a 1994 chev Blazer S 10. that has thesy troubles. when it warms up it runs high and hot exhaust and ruff idle. with a hot cat. Replaced EGR carbon build up at times.replaced fuel pump, and all the senors under the hood. Still runs the same.
View 3 Replies
I have recently been getting black smoke out my tailpipes on my 1995 F350 with 7.5L at certain idles and my check engine lights comes on and off, could this be caused from my O2 sensors going bad because of my gutted cats? It seems to be running rich and my idle is way low and at the point to shutting off, prob cuz of overload of fuel...
View 4 Replies
2002 Ford Ranger edge 3.0 flex ... Truck was running fine and giving me no issues. I woke for work the other day and went to get coffee and truck wouldnt start. I could hear fuel pump running and knew it wasnt that, it was acting flooded. So today I pulled fuse from fuel pump relay, and got it to start. Put the fuse back in and ran to gas station. On the way to the gas station it started running really rough, very low and rough idle, trying to stall out. I noticed it had black smoke coming from exhaust. I got it home, and got it to start barely, and it has the same very low and rough idle, but my oil gauge was going crazy, flickering back and forth all crazy, and the idol is terribly rough and eventually stalls out. Earlier today I did put new spark plugs in it, but not sure that has anything to do with the issue. I also hooked it up to a computer and it isnt throwing any codes.
View 13 Replies
I just bought a 2002 v10 crew cab, everything great form the first 3 months, but then my coolant sensor stopped working, changed it, and the same thing! Only works a couple of times, and the truck started to rough idle a little, and now I have black smoke coming out of the exhaust!
View 3 Replies
2001 SD F-250 SuperCrew 4WD, 7.3L (completely stock), 114K miles, automatic
We took Dad's SD for a 600-mile trip yesterday and today. The oil had 2000 miles on it, and we checked it before we left. The oil level was half-way down the hatch-mark, so we had added a little over a quart of oil to top it off, and I think that we may have added a little too much. Last night, when we got to the hotel and got out of the truck while it idled, a lot of white smoke that smelled like burning oil (like when you spill oil on an exhaust manifold) was fogging out of the exhaust.
It did this for a minute or two, then cleared up. All day today, on the way home (300 miles), about every time that I let off of the throttle either going down the interstate or stopping at a red light or stop sign, white smoke would pour out of the exhaust briefly, then stop when accelerating or in the throttle going down the road. What is causing this? Would too much oil (a little over a quart too full) make it smoke like this? The truck runs strong, starts and idles good, and no 'check engine' lights came on the dash.
View 14 Replies
