Santa FE SM (2001-06) :: Leaking Antifreeze - Hole On Cylinder 5 Side Of The Block
Jun 11, 2014
We now have a new problem. Motor is leaking antifreeze out of what i will call a weeping hole in the on the #5 cylinder side of the block. The hole, which is manufactured in the block. Is where the antifreeze is seeping from. The hole is located above the bottom bolt an just below the top bolt for the transmission. the hole is on the block. I think that there might be a freeze out plug on the back of the motor block where the leak is coming from. The block was not leaking before we removed the heads for valve job.
View 3 Replies
Advertisement
Son has a 1987 ford ranger 2.9 engine 5 speed 4x4 truck. See anti freeze leaking @ the rear of the engine where the intake attaches to the block. How long to re & re the intake, ect. Is it just gaskets or what? Is it a big job?
View 9 Replies
My car was shaking badly during idle and the Engine and VSC Off lights came on simultaneously. I took it to a local garage (not dealership) and they said that there is anti-freeze leaking into a cylinder. They said the only way to clean it out/fix it is to first remove the entire engine from the car so it could be worked on. It will cost a total of $2,700. My engine has 141,000 miles on it so they said this may be risky since it is so used. They said for $3,500 they could swap it with an engine that only has 31,000 miles on it (and a 6 month guarantee.) By numbers this sounds like a no brainer (I am assuming?) but I am curious if swapping the engines would be worth it seeing as the rest of the car has still traveled 141,000 miles. I have kept it in good condition and such though. I am also curious if the engine really does need to be removed to fix this sort of problem or it it could be done cheaper.
View 4 Replies
Not my Elantra, but an '05 Santa Fe 2.7 ... I have a fuel leak from the driver's side of the tank. It has continued leaking while the vehicle has been parked with about a quarter tank of gas, even after 8 hours. I can see where it is leaking from - a quarter size depression in the tank - but I think this is some sort of plastic pan, not the tank itself.
Is there is a plastic pan under the tank?
If so, does it cover just the bottom half?
If it is a plastic pan, is the tank itself plastic or metal?
If it is plastic I don't see how it could develop a leak, so is it possible for the leak to be at the top of the tank due to a fuel line problem (maybe some mysterious syphon condition)?
I searched the forum and leaking fuel tanks don't seem to be a common problem. My usual parts store doesn't even have a listing for a replacement fuel tank.
View 4 Replies
My father put my f150 into reverse he says he didn't gas it. It was 2-3 feet in between the cars and the hitch went into the bottom grill below the front license plate. Coolant is leaking from the left side between the radiator and the block. Now the trucks hitch didn't go far enough to hit the radiator, or anything else I can see. I have cleaned the coolant and am in the waiting process try to identify the location. I believe that it is oozing from the water pump ( most of the coolant is underneath it), on the other hand there is coolant also by the radiator just not as much. I have the ability to fix this just not the tools. My family is going to take it to the dealer ship I just do not want them to get finagled around.
View 3 Replies
I have an 08 Explorer with the 4.6v8. I've noticed the clutch fan on at start up the last few days. Check anti freeze and I was empty in the reserve. While filling the reserve there is a steady drip from the passenger side but I can not see it. It's trickling down the radiator but can't see from where. Is there a common hose, sensor or crack in reserve tank I should be looking for? Car hasn't overheated as of yet. It leaks with no pressure in radiator as well as with.
View 1 Replies
Went to start my truck to leave work yesterday and blew the coil on #2. It's happened before and I can fix that. The other weird thing that happened was that the radiator leaked out some antifreeze. Not a lot, but a good 2 foot puddle. The reserve was still full and it leaked from the passenger side at the bottom (below the upper hose). Upper and lower hose show no sign of leakage. I suppose the drain is on the lower end of the passenger side of the radiator and it leaked from there. Would the compression from the engine cause that to happen? Or is it something more, dare I say, like the head gasket blew?
View 7 Replies
I was sitting in my car on lunch break. I noticed the temp gauge was higher than normal. Then I noticed a little steam coming out from under the hood. When I checked, there was antifreeze leaking out from where the tube connects to the overflow tank. It didn't look like there was a hole in the tube, it was squirting out right where the tube connects to the tank. I turned it off, and had to go back to work. I'm not mechanically inclined. When I got off work, I put a bottle or Bars stop leak in and filled it back up with antifreeze. Started it up, didn't seem to be leaking. Drove it home. Any time I am idling or cruising, the temp gauge will go up to the 3/4 mark , when accelerating it will drop to between 1/4 and 1/2, which is where it normally was.
View 2 Replies
I looked under my truck and noticed a Antifreeze Leak I looked under the truck and noticed the antifreeze leaking around the crank shaft. I have never seen a leak from that area. I haven't pulled anything just want a good direction before I start pulling parts off.
I looked up top didn't see any hoses leaking. looked all around the block. the only place I can see it coming from is behind the crank shaft pulley somewhere.
2001 F150 XLT 4X4 ....
View 6 Replies
2002 My friend's 2.7L sante fe crankshaft position sensor went bad and I went to replace it. Removed bolt, it was stuck fast, tried to pry out and it broke off leaving the last 1/2 inch stuck in block. Tried drilling a hole in it and using a screw to get it out but no luck. Afraid to keep drilling that I might damage something behind it. How to get it out?
View 9 Replies
99 f150 4.6 4x4 ... auto.. so, driving on the interstate I had to accelerate hard to avoid hitting a crazy driver... after that I smell antifreeze... get home can't find a leak.. wait a bit and I see antifreeze leaking passengers side coming down the firewall outside... if you are laying behind the passengers front tire with your feet to the back tire.. looking up you see the catalytic converter.. behind that on the firewall a stream of antifreeze... follow the stream up and there is a piece of plastic just about were the firewall starts to go straight up from the floorboard bend.. putting my hands in that it goes inside..and its wet inside..
I can't tell what that's for really but. Am I guessing evap coils access? any rate. I don't feel any dampness inside yet.. but I do smell it in the cab stronger now. I haven't ripped up the carpet either. Im suspecting my heater core sprung a leak?? there is a good amount of fluid coming out and down the firewall outside I would say I have about a 6-foot puddle now. course I parked on a hill too. no fluid that I can tell is at all leaking off the heater core hoses.. they felt dry. Im guessing there is a drain port in that black box inside and that is where this is coming out?? no noticeable leak from the motor side.. it's all dry.. its actually going down the firewall and hitting a metal plate that carries out to a cross member on the transmission and then leaking down.. motor area is dry.
View 1 Replies
I have a Hyundai Elantra 2001 that I just bought off someone. I've had the car maybe 2 weeks, I changed the radiator because it overheated last week. Then, I found out the valve cover was cracked in four places, I replaced those too... I bought and installed a new thermostat, and I thought that would be the end of overheating... I was wrong, last night I felt like I smelled antifreeze strongly, so I parked it and this morning before heading home from work, I checked the radiator, it was empty. I filled it with antifreeze, and headed home, 20 minutes later, I parked on my drive and see that I have a huge leak... and it's antifreeze.
So, seems like I had left the cap open somehow, I didn't close it all the way. That was understandable, so I put some more coolant in it, and took off in the afternoon - 20 minutes into my drive, it starts slowly overheating, I see the gauge going up so I pull over, as soon as I do the car shuts off. I took the keys off the ignition and opened the hood. Now, there's smoke coming off the engine (smoke came from under the valve covers). I gave it 20 minutes rest at least, then added water in the radiator. Turned it on and it worked ok for about 5 minutes, I drove 2 hours to get it home at this rate, stopping every so often. Then, got it home and parked it.
View 1 Replies
Working on a 2000 F150 with the 5.4 and as near as I can determine its leaking antifreeze externally at the front of the passenger side head gasket. Seems a little odd. The coolant is a nasty dirty orange color. With the truck running on the hoist it was dripping very steady off of the very front exhaust manifold bolt.
View 3 Replies
Went to change plugs on my '01 F250 5.4. When I pulled the coils, there was antifreeze in the tubes. Intake manifold gasket? How big a job, both in driveway or at shop.
View 1 Replies
2002 Santa Fe with 140K. Superbly well maintained.
I notice . Looked all around....then on the radiator toward the top where the metal meets the plastic. I noticed wetness across the entire radiator. Thought it may be coming from the upper hose and spreading across....Replaced the upper hose....Not the problem.
Still has anti freeze seeping across the radiator / plastic area. Does the mean the entire radiator needs replacing? I have searched the forums and seems like no one had replaced a radiator on the Santa.
Is the radiator breaking down. Oh, it's NOT the water pump.
View 2 Replies
I have a 2004 Hyundai Santa Fe with a 3.5L engine and 92,000 miles.
For the past week or so, I have noticed a very slight smell of antifreeze/radiator fluid every once in a while. I assumed that it is a radiator hose leak or possibly a leak in the heater core. But, the vehicle does not overheat, there is no steam or fog inside that would indicate a possible heater core leak, and the radiator fluid level seemed full or almost full (although the radiator overflow container was empty). I added a little water to the radiator and filled the overflow container to make sure there was plenty of radiator fluid in the system.
I haven't seen any radiator fluid on the ground around the vehicle at anytime. When I open the hood, I don't see any leaking hoses. I took off the engine cover to see better, and I don't see any leak around the water pump, or dripping from the pump, or dripping from any hoses, etc. But, BELOW the water pump is something made of cast metal that I am guessing is the automatic transmission(?) -- I really don't know what it is. And, sitting in some valleys or crevices in that part are small pools of green fluid that clearly looks and smells like radiator fluid with antifreeze.
I ran the vehicle for a long time while watching to see if I could create or see the leak or anything dripping etc. But I don't see anything other than
those pools of green liquid just sitting there. I tried moving or wiggling the hoses, and nothing changed. I also tried keeping it running with the heat on high, then later with the AC on high -- still no change. Then I tried using paper towels and sopping up what I could that was in these valleys/crevices, then I drove it again (but only for about 4 miles so far) and I don't see any new fluid in the crevices or anywhere else.
Here are 5 photos that I took with the engine cover off while the green fluid was still there. The photos go from a wider angle overall view down to a view of the green puddles from a slight angle and then down to a top view of the green puddles.
[URL] ....
Where you may see dark areas on the water hoses near the water pump, they are just shadows created by the flash or the sun or whatever. The hoses themselves are all one color and are not wet etc.
My questions:
Am I correct that where the small green puddles are is the automatic transmission?
Is it possible that there is some connection between that (the automatic transmission(?)) and the radiator cooling system?
Is it possible that the cooling system somehow also cools the automatic transmission (or whatever that is)?
If so, could the leak be right there -- maybe where that bolt or the other wire/connection piece is -- and the radiator fluid is coming UP from there? What this may be or where the leak is coming from?
View 6 Replies
I am trying to fix my friend's 03 Santa Fe 2.7L with 325K miles on it. Pulled the codes and he has misfire in #3, 6 and a random one. It doesn't do it all the time, and when it does do it he can sometimes shut it off and restart it and it will be fine.
What is the likely culprit causing the misfires and how to test it? He can't just throw parts at it.
View 5 Replies
2002 Hyundai Santa Fe 2wd 2.7L 175,000 miles
Having misfire in #1 &4, new plugs, new wires, new coils, new cam and crank sensors, cleaned and tested fuel injectors, checked injector signal, checked timing belt.
Swapped around plugs, wires and injectors(keeping same firing order) and the # 1 & 4 will not fire. There is spark to the wires and plugs and gas thru injectors but no detonation.
With plenum and exhaust manifold removed (front only) visually checked valves. Installed new oxygen sensors while exhaust was out. Tested ecu fuses in black relay box in engine compartment.
Engine stars first time ,every time but only runs on 4 cylinders. Check engine light code reads no 4 cylinder misfire.
View 8 Replies
Where cylinder 1 is located on my 3.5l v6 santa fe. I am replacing the heads and need to know.
View 2 Replies
I have a 2001 Hyundai Sante Fe that died on me while driving down my street. The engine sounded like it was loading up for about 1-2 seconds, then it died. It turns over but does not fire.
After a little troubleshooting, I have no spark in cylinders 1 and 4. I swapped the two coils thinking that I had a bad coil, but then the suspected bad coil created spark on the 2-3 cylinder side. So both coils work.
I towed the car to the shop and the mechanic after about 2 hours of billed labor, he is leaning toward a bad ecu. He said there also is no fuel metering from two of the fuel injectors. He checked the resistance on the injectors and said they are fine. He is thinking it is a control/command issue. The car has many other unrelated problems and I am not sure I want to spend too much more money on it.
I am skeptical about a bad ecu. Or sensors that may be causing my two cylinder no spark and alleged fuel problem?
View 14 Replies
I can't see where it's coming from but it's leaking onto my TIP. it's not a lot though.
View 4 Replies
