Santa FE SM (2001-06) :: 2004 - Passenger Side Tie Rod Popped Off
Jun 29, 2015
A quick question for those with a manual. I was out with the kids yesterday and the passenger side tie rod end popped off. Luckily we were only backing up at the time, but the bad part was we were in the middle of no where and had to go home with my wife as we took both cars. But, I had to leave the car there. Anyway, what is the size of the castle nut that attaches the tie rod end? I want to be sure as the vehicle is about 40 miles from home.
View 5 Replies
Advertisement
I have the 3.5 LX AWD 2004 Santa Fe 102,000 miles purchased new. My power steering fluid reservoir was leaking from the top a lot. I read here that the screen in it could be clogged. I went to the garage the manager never heard of such a thing he said, and never heard of a PS reservoir having a screen (I gave him the TS. He said if I got the part and wanted it changed they would change it. I did that. It was done 2 weeks ago and now it all dry under there. But, now.. there is a low whine on the passenger side under the hood toward the back, but when I put the A/C on or the heater on defrost (Not when heater is on, only in defrost) there is a loud rumble/hum from the same area. Shut A/C or defroster it goes back to a low buzz/hum again.
I had the power steering pump replaced at the dealer about 2 years ago, its not old. The noise is NOT any louder when I crank the steering wheel all the way to either side. The fluid since replacing the Power steering fluid reservoir is staying at the same level, full, no leaking. When I put everything on, lights heat only (No defroster), radio, lights the noise doesn't get any louder either, I tested that. The other night after driving about a half hour to and from a place I went to u-turn in a parking lot and that whine was louder for a minute and while driving forward slowly out of the parking lot getting up to speed.
When I asked about the PS fluid reservoir, I had also, asked the repair shop manager his opinion, of that loud hum/rumble when I put the A/C on (At the time I thought it only happened with the A/C when the compress popped on). He listened said "That's the A/C compressor it's going and its going and cost more to replace it then its worth on your 2004." So, that's the background.
Questions: 1. Just wondering if you think it is the A/C compressor that is the loud noise when on, would the A/C compressor even go on when the defroster is on, the A/C is off, and the heat on and there for still make that loud rumble??? Or does that defroster fact kind of mean its not the A/C compressor??
2. What is your opinion of the low buzz/whine noise now (When heat/AC off)? I can't pin point it totally in park when listening, its very low (Except that one point where it was loud for a few minutes driving out of the parking lot.) (The motor sounds a bit louder in it in front too just side observation)
I almost worried if the low buzz was the Transmission as its fluid hasn't been changed in a few years (Because the mechanic said sometimes changing the fluid when its been a lot of miles between can actually cause problems to the transmission) It was done at the dealer around 45,000 miles and now my Santa Fe has 102,000 miles.
Could the power steering pump be going bad in only 2 years from what I've described? Or could the PS fluid reservoir having been spitting PS fluid from the top for a couple of weeks have caused damage to the PS pump now?
The fluid never got lower then full when it was coming out of the top and only when driving, I kept checking it. The mechanic who put the PS fluid reservoir in said he had no idea if it leaked from the top due to the screen as he felt the screen had only minor debris that was not blocking a lot of the screen since its a big screen (He didn't look too hard though), and it was possible even a small crack in the reservoir could cause that same fluid coming out at the top. He said it could be either he didn't notice a crack either.
Or are these two noises possibly not related even though possibly from the same area on the passenger side under hood.
View 4 Replies
I have a 2004 Hyundia Santa Fe. The passenger front window will not roll down from driver side switch but will from passenger switch but then will not go up on passenger side switch. I found a broken wire on driver side and repaired it. I put a test light on the wires on the passenger side and used the driver switch and the test light lights when using the up button and down button! I have already put a new master switch in and tested all switches they all work!
View 1 Replies
I have a 2005 Santa Fe with the 2.7l engine....during the last two summers I've had this code pop up only to disappear. Well, we're into the winter here in New York and the code popped up again and after a week its still on. What's causing this and are there any easy fixes? The wife loves the SUV, its got 120,000 miles on her, the engine is strong and the tranny was rebuilt this summer (that another story).
View 1 Replies
About a week after my yearly inspection the "Air Bag" light on the dash popped on and has been on for the last few days. Are these comon failures? and could you give me a good starting point. My car is a 2005 Santa Fe GLS FWD with 125,000 on her.
View 9 Replies
I have a 2003 3.5 liter, AWD and I'm attempting to remove and replace the drive axle on the passenger side. I have the one end out of the hub, but the transmission end will not come out. I removed the bolts holding the bearing plate, and have been trying to pry out the axle with no luck.
View 3 Replies
I drive a SantaFe 2005 2.7 engine....lately it has a gas smell coming out of the passenger side- front... how is this coming from?
View 1 Replies
I had a little run in with a curb a few months back, nothing major, just came up and bit me, and the passenger side plastic grill covering the foglight popped out. Since then it's come compltely out, onto the street, twice, when my car bottoms out. Both times it's happened I've been going no more that 5-10mph and I don't even realize it's missing 'till I'm back in the driveway.
The car in the picture isn't mine, just something to show what I'm talking about. My 2001 passat wagon (v6 4motion) bottoms way too much. It's not even lowered.
View 1 Replies
Chrome trim on passenger side near headlight popped out some of it broken (only the pieces on the inside) any way I could salvage this trim without having to buy a new 1?...
View 4 Replies
I have a 2004 Jeep Cherokee and the passenger window recently popped open. Something is wrong with the power windows (I can't shut it either automatically, or manually).
View 1 Replies
My wife and I recently purchased a '01 Santa Fe. We noticed that the gap between the passenger front door panel and dashboard is wider than the gap between the drivers door panel and dashboard. There is road noise that enters from the passenger side door. I believe the door latch is contacting the striker before it is fully closed.
What would be the best way to correct this? Move the striker or the latch? My wife will be spending about three hours a day everyday during the week in this vehicle and the road noise will annoy her until I get it fixed.
View 1 Replies
Yesterday my passenger front window popped out of it's track. Then when we tried to pop it back in and get it to go back up, it completely popped out and up about 3 inches from the frame of the door. Enough to be able to fit a had through no problem.
I am taking the car in tomorrow to have it looked at and get a quote to fix. From what I've read, it's a super pricey fix. So bummed because I just bought the car about 6 weeks ago (if that) ...
View 5 Replies
I'm driving a 2002 Hyundai Santa Fe with 83,000 miles on it.
Had it in the shop (dealer) a couple of weeks back for some work on the transmission. While there, I had the dealer perform the work for Recall 090 (corrosion of rear trailing arm). Since that time, there has been a clicking noise coming from what I believe to be the right rear wheel (it is definitely coming from the right [passenger] side). The noise sounds like metal rubbing up against metal, for lack of a better description. The noise is directly correlated to wheel rotation... the faster I drive the vehicle, the more frequently it occurs; the slower I drive, the less frequently it occurs.
The noise is very noticeable, and I am certain that it did not exist prior to my latest visit to the dealer. I am considering taking the vehicle to an independent mechanic this time, as the dealer repeatedly tells me that they aren't to blame, or I end up leaving the dealership with more problems than I arrived with.
View 5 Replies
We just replaced the #5 injector. Went to take for a test drive and the 4 glow plug caps on passenger side popped off and leaking oil while driving. Pushed them back on and they popped off again. They shouldn't be under pressure should they.
View 6 Replies
The driver's side coil spring broke, but here's the story.
When I found out there was a recall on my 2004, I called the dealership. They told me that they were not replacing the coils springs, they were only going to attach a brace or bracket in case the coil springs would fail.
Well, last night the coil broke and it was in the parking lot and not at 50mph on the road.
What about bracket fix? It was told to me that it would only prevent the coil from cutting into the tire, not fix it.
I am going to call Hyundai HQ this morning, but what should I expect? Is it unreasonable to expect to get a set of springs and have someone local do the work?
View 2 Replies
When I use the remote to lock/unlock the doors the drivers side door won't activate . . . .unless it's really cold outside. The other 3 doors work year round.
Sounds weird but as the weather gets colder the lock on the drivers door will start to work. As winter turns to summer here in Illinois it starts to act up again. When it does work, it seems that unlocking works more consistently than locking.
Asked the dealer to have a look at it. They said it was a "weak actuator motor" and suggested to replace it. Sounds bogus to me.
I've tried to have a look down there but I'm afraid to take it all apart for fear I won't be able to get it all back together. Are there adjustments that can be made to the linkage or are lubrication points that might get this thing back working again . . . . . . all year long?
I also noticed that manually working the passenger side lock will lock the rear doors but won't lock the drivers door so it's not the remote. I never paid attention to whether manually working the driver side lock would lock the other doors but I think not since the buttons are right there on the drivers door.
View 4 Replies
I have a 2008 Santa Fe Limited. Today I briefly turned the heat on since the outdoor temp was cool. Later in the day, I resumed the A/C AUTO setting at 72 for BOTH sides of upper vent outlets. I soon noticed that the driver's side blows warm air and the passenger side blows cold air as it should. No amount of adjusting the temp control either up or down had any effect on the driver's side except for constant warm air. Now I know the passenger side can be adjusted separately but both sides were set for the same temp. Never had this happen before. Always before, if I wanted warm air, the warm air would come through the floor outlets. What's causing warm air to come out the top driver's side vents when it should be cold? Could a diverter door be stuck?
View 2 Replies
I have a 2007 hyundai Santa Fe GLS. When the AC is on the drivers side blows hot air and the passenger side cold air. Both actuators are working driver side and passenger side. I watched them engage as I changed air flow and temp. What I should look at next? Also, the rear ac button light will not come on and it blows hot as well.
View 3 Replies
Never seen this problem before. Thought I had a leak in the system and had to have it serviced. The AC did not seam to be blowing cold. It would take forever to cool off. Was trying to get as much air on me as possible so I decided to point the passenger side vents towards the drivers side to cool off in the mean time. I noticed the passenger side was cold. Air is blowing out of the drivers side but not cold like the passenger side.
View 2 Replies
I was driving down the street when another car side swiped mine. There wasn't any noticeable damage, but the side mirror on my driver side popped out.
It doesn't look like anything is actually broken. The mirror just popped out. Can I pop it back in or will I need to get it looked at?
The reason I ask is I didn't notice any other parts of the mirror on the street, but can't seem to get it to pop back in.
View 2 Replies
A few weeks ago my passenger side low-beam failed to come on during a short road trip. After a failed attempt to find a replacement at 9PM I had no choice but to continue on my way, about an hour later, as I was driving along, it suddenly came back on with no trouble since. I haven't touched any wires or fuses.
View 3 Replies
