Santa FE SM (2001-06) :: 2004 GLS Power Steering Fluid Leaked Out The Top Of Reservoir
May 24, 2010
I have an issue with my 2004 GLS 3.5 L w/ 68000 miles. After the SUV warms up for a few minutes I can hear a whine or rattle on the passenger side. I noticed a little power steering fluid leaked out the top of the reservoir (a few little bubbles in the oil). Then reading on the HMA website it says the filter in the reservoir can get clogged and restrict the flow. I took the reservoir off and flushed it out then replaced with new oil.
Unfortunately this did not fix the issue the noise is still there. It's most prevalent when you turn but the noise also picks up a little when you hit the gas. I have checked for hose leaks but cannot find one. My next step is to have the steering pump changed out. While the mechanics in there I am going to have him check the hoses/pulleys really close and look around for another leaks anywhere. Noise is annoying but the steering works fine.
View 7 Replies
Advertisement
2.7 Power Steering Fluid boiling/foaming leaking out a reservoir cap!
1) Recently had Timing Belt/Water Pump and spark plugs/wires replaced.
2) Issue started immediately after.
3) Removed most of old PS fluid, cleaned out reservoir w/brake cleaner. NOTE: nothing appeared to be clogging reservoir. Refilled with new PS fluid. Repeated these steps a second time. This appeared to immediately resolve the issues for several weeks.
4) Now the power steering is getting rough and noisy again. Also, the PS reservoir is leaking out of the cap worse than before. It looks like the fluid may be "boiling", but it is definitely foaming up pretty badly.
What my issue(s) may be?
View 4 Replies
I have a 2004 Santa Fe 3.5L with 85K miles. TB, WP and all belts changed at 75K. Have had this whine noise when I turn right, very high pitch noise. On top of this there is now Power Steering fluid leaking from the reservoir and base and brackets are full of fluid... Needless to say I assume it is the reservoir seals giving up but why the noise only when I turn right? No noise when I turn left.
What could it be? Also where can I find parts online that are cheaper than the stealership? I called them and they quoted me $72.00 for this piece of plastic!!
What else should I change? There is also some "oil/fluid" coming down a pressure hose but I believe this is due to the oil dripping from the reservoir...
Any manuals I could use to view this? I bought the Haynes manual and it's worthless!
View 1 Replies
2005 Santa Fe (88K, 2.7 V6).
For a month or two, after the car got warmed up, I'd hear a whine/hum noise when I slowed to turn or reduced speed. The noise was much more noticeable when the car had been running at least 15-20 minutes, but I did occasionally hear it when the car was somewhat cool still. Never had a problem steering during this time, even with the noise... but I eventually figured out that slowing down and/or turning brought it on. So I took it to a mechanic.
They showed me bubbles coming from the power steering reservoir, and said I needed a new PS pump and pressure hose, along with a flush/new fluid. I paid for all of that.
Next day: The car would become hard to turn when I made a tight turn into a parking spot... again, not a constant thing, but only when turning to park and going slow. The noise APPEARED to be gone, but this new issue worried me so I took it back. They put a different pump on (no charge), thinking the other may have been defective.
Next Day: I hear the whine again on my way home from work. When I get home, I park, leave it running, and pop the hood. There's a fast drip bubbling from beneath the reservoir cap and running down to the pavement. First thing the next morning I return to mechanic. He says the first two pumps were the same brand and both "remanufactured" so he switches to a different brand -- this one brand new, not "remanufactured" -- and installs that one.
A half hour later, I get home. Hearing that same whine/hum, I lift the hood. Fluid is pouring out from beneath the cap in a steady, unbroken stream (not a drip, but a stream). So I took it back to the mechanic (who to his credit, has charged me nothing since the initial new pump installation). What could cause the power steering fluid to gush out from the reservoir cap when the car gets hot? I have a brand new pump and pressure hose. What could cause this condition..
View 12 Replies
A few days ago, my car developed a loud squeeling noise coming from the belts. I opened the hood to find both caked on and still wet PS fluid all over the left side of the engine compartment and the belts/pulleys. Most of the mess was concentrated near the PS fluid reservoir and the two hoses attached to it (picture of hoses and reservoir below from Google). This leads me to believe there is a leak in one, or both of these suction hoses. I will replace the hoses but my question is how should I clean up the fluid on the belts and pulleys? Should I use a soft brush and a rag with soapy warm water, brake cleaner and/or engine degreaser to get all the gunk off? I would really loathe having to have to put in new belts, seeing as that I just had all the belts changed 6 months ago. This squeeling noise makes my car sound like some old junky clunker and I hate it.
View 2 Replies
I have a leak coming from the top of my reservoir from the under the cap for some reason. I bought a new cap and it seem to stop for a day and now it leaking out from under the cap again. What is the reason it would be coming out of there. Am I going to have to replace the reservoir??
View 1 Replies
I am trying to remove the engine cover on the passenger side of the engine bay so that I can access the power steering fluid reservoir. What is the procedure for removing the plastic clips, rivets or whatever they are and also how do you reinstall them? This is a hair brained design if I ever saw one!
View 14 Replies
My truck had a slight vibration at idle today and what i noticed the most was i was looking at the top of the motor and i noticed that the fluid in the power steering reservoir was shaking back and forth like i was shaking the container. Is this from the vibration or is the power steering system vibrating. I have had this truck for two weeks and it has 135k on it. It is the 5.4 motor...
View 1 Replies
I noticed that the power steering fluid is leaking bad from a weird spot under the car, it looks like it is coming directly under the drivers seat but I can see any lines. It's an 02 Santa fe ....
View 8 Replies
I have very good question. My 2001 Santa Fe has 200k miles, I think the car is great. Regular maintenance, and the car drives still drives strong and comfortable.
Here is my problem: The power steering fluid is disappearing. There is no puddle under the car, I got under the car and everything is dry. However about once a week (+/- 200 miles) I have to add power steering fluid. I have cleaned the reservoir twice and confirmed that the top of the reservoir is also dry ( so is not bubbling off the top of the reservoir).
I have put newspapers under the car while parked overnight to see if there is a leak and the news paper is dry in the morning without a stain.
Fluids do not disappear. Could it be leaking while driving (high pressure hose) and its leaking from a location that I cannot see? Where is the "banjo connector" that I have heard referred to ?
View 3 Replies
2004 XG350 with the Sigma engine, 133,xxx miles.
In the picture I attached, the large silver bolt is leaking. Its a slow leak: yesterday morning I wiped it off, and then we I got home from work there was a bead of power steering fluid, but not enough to drip.
What is the best way to fix this? Is it as simple as tightening it?
View 3 Replies
The steering fluid pump reservoir has a leak ive been told by my trusted mechanic. The first bout of cold below freezing weather, the steering fluid drains out and I have to refill it. After refilling, I'll have to fill it again in a few days sometimes lasts a few weeks. Might not have the car for much longer. How to cope with this rather than get a (expensive I was told) new steering pump.
View 2 Replies
So I've been noticing my power steering in the reservoir has been going down for quite some time. Now its more noticeable than ever. Just about a month ago I topped off the tank to the "max" line and now its at the "min" line. I also notice the fluid on the garage floor. I've always had a lot of grease (I assume the fluid) all around the body and under the reservoir under the hood. It seems to be leaking from the hose where it connects to the actual reservoir. Maybe the clamp is bad or something.
View 14 Replies
My power steering fluid reservoir is a little low. Which type or brand of power steering fluid should I fill it up with?
I know that I should use Dextron III, but does the brand matter? Or can I mix the OEM fluid with an aftermarket fluid.
View 3 Replies
I have a 94 Celica 2.2. I'm having issues with power steering fluid leaking from reservoir cap. I replaced the cap due to the old ones seal had dry rotted and dip stick was broke off, also replaced the 2 small short hoses and new clamps. The return hose is working right and the high pressure hose seems to be working right. None of the hoses are leaking but pressure is building up and pushing fluid out the reservoir cap. What else could be the problem to cause this??
View 14 Replies
I've a problem with my 2000 Nissan Maxima GLE. Recently I started hearing noise from Passenger side of the car, and I noticed that the Power Steering Fluid Reservoir is almost empty. Looking more closely, I see some kind of leak. Could this problem indicate something wrong with the Rack and Pinion or the Pump itself.
I went to autozone today, and bought a Power Steering Fluid with Stop Leak. I added the liquid, and turned Steering Wheel to the right and the left. After doing this, I checked the reservoir again, and I saw the reservoir level was very low again. I repeated the above steps until I reached the point where the reservoir level was to the high point.
I would drive for couple of days and see if the reservoir level goes down again which point to leak still existing. While waiting on this test, thinking what could have gone wrong here that is causing the Power Steering fluid to leak. I've also attached the picture which point to suspected point of leak.
View 4 Replies
I own a 2009 Corolla. Cannot locate where the power steering fluid reservoir is. I googled and also looked under the hood, no luck.
View 6 Replies
2000 Honda Accord. Power steering fluid is coming up and out of the reservoir when the car is shut off. I recently had to take the hose off and move it out of the way just to make it easier to replace the belt. Lost some fluid and put more back in. And now this. Also is whining when you turn the steering wheel. What do I do?
View 7 Replies
So I have multiple issues that all seem to stem from a power steering leak. According to the dealership, the PS pump is leaking fluid onto the serpentine and timing belts causing them to swell. This in turn has something to do with the AC compressor not working but they wouldn't give me details. When I looked at the clutch wheels on the AC compressor, there seems to be a good amount of rust in between the two wheels. I can't say that I trust the dealership because the original owner was bought out by a larger group that is known to just say "replace everything". I usually do most of my own work on my 95 Tacoma, so I'm no stranger to import v6 motors.
View 4 Replies
Just checked out at 2003 V6 LE with 120k miles for $5500. Car seems to be in excellent mechanical condition but I did notice quite a significant power steering fluid leak, seems to be coming from the reservoir. I see that there are two hoses for about $80 each listed on Partsgeek.
Is this a common problem, can the clamps just be tightened, Could it be the reservoir it's self or even the pump too high a pressure?
Seems to be quite a lot of fluid running down the side of the car but after taking it for a test drive I didn't see any signs of it squirting out so perhaps it's a slow leak and been leaking for a while.
View 6 Replies
I have a 2010 F150 4.6 3V... The power steering reservoir is constantly losing fluid. I've purchased the truck,used, a few months ago, bought a warranty. The dealership has had it multiple times now and can't find the leak. They just keep replacing hoses and the problem keeps occurring. Also worth noting, the truck has 6" lift with 35s. I've have also pulled the radiator cap and found a decent amount of what looks to be sludge/oil inside. Dealership says it's probably just bad coolant.
View 1 Replies
