S-10 :: 2002 / 2.2L - Temp Gauge Running Around 170 Degrees As It Gets Cooler Outside
Nov 6, 2012
2002 S-10 2.2L ... Started noticing my temp gauge running around 170 degrees as it gets cooler outside. I changed the thermostat and noticed that the connector to the temp sensor was cracked, changed that too. Had to warranty replace the temp sensor because the first one didn't register on my dashboard gauge. Still didn't get heat above 150 degrees.
Warranty replace the new thermostat and still not getting heat above 150 degrees. Radiator cap test bad at 15psi, replaced radiator cap and still not getting heat above 150 degrees. The engine is running cool and the cabin heat is not as hot as it has been for the last 5 yrs. There are no engine codes stored, anti-freeze leaks and level is correct.
I'm lost as to why all the sudden the truck starts running cold and won't build heat.
View 5 Replies
Advertisement
02 6.8 4x4 excursion. When I start the truck cold, the trans temp gauge immediately moves to "running" temp. Not really sure how this happens, I'd figure that if the xducer was trash it would ride all the way high or all the way low. What's happening here? I'd sure like a functional gauge...
View 6 Replies
So yesterday my truck decided to start giving me fits right after it finally got extra cold and snowy here! I noticed early on this fall that my water pump was leaking, so I replaced it. I also found that my truck only blew hot air while in motion, and cold air while it was stopped or at idle. At this point I replaced the thermostat and housing. I originally had the stock setup with the combined thermostat and housing. The new one is and updated GM version with the separate thermostat and housing assembly. Everything seemed to be ok until yesterday morning.
This is where my problem is now. Yesterday on my way to work, the message center said my coolant was too hot. The temp gauge showed the truck at about 250 degrees. My speed was only about 45mph and it was 6 degrees outside. I ended up parking the truck and looking at it after work. I found it was still doing the exact same thing. When I investigated further, I found that the upper radiator hose was hot, while the lower one coming out of the thermostat housing was cold.
At this point I figured that I had a bad thermostat, and bought a replacement. I tested the old one on my stove top in a pan of water and found that it did actually open at about 175 degrees, so I'm not so sure it was bad now. With the new thermostat installed, the engine is no longer overheating and the temp stays around 235 while driving. However, I am back to the heater blowing cold air at idle and while stopped, and warm air while driving. In addition, the rear heater now only blows cold air, it never warms up.
View 2 Replies
I have a 1992 Chevy 1500 5.7L V8 with 167,000 miles that is running hot. When I drive the vehicle the temperature quickly rises to just about 250 degrees and hovers just under the "red" zone. It never fully overheats, even on longer drives (50+ miles). It seem to run just fine otherwise. It is not leaking coolant and I have not had to fill the radiator. My first thought was that the thermostat was bad, but wouldn't that be an "all or nothing" issue? Where should I start looking for the problem? It has been going on for about 3 weeks, and I want to get it resolved quickly.
View 10 Replies
2006 camry temp gauge goes past H while car is running at any time. Fan still works anti freeze in radiator anti freeze in reservoir. When take the key out the ignition. Temp gauge drops to the middle(normal position) 15-20 later then gauge drops to C (normal position when key is out ignition). Car runs fine no steam no leaks no funny noises. Car has 68k / 4cycl.
View 1 Replies
I have a 2000 monte carlo ss. A few months ago the check engine light came on, the temp gauge stopped working, and after shutting the car off you can hear the fan running for about 10-15mins after i shut it off. I assumed it was the thermostat, so that was the first thing i changed. For the first few weeks everything seemed fine. No check engine light, temp gauge worked...then today suddenly it all started happening again. What could be causing it if the thermostat has already been changed? what should i try next?
View 2 Replies
I have a 2007 Camry with the 4 cylinder engine and about 90,000 miles. I just changed the oil and took it for a test drive only to notice about 1/4 mile down the road it was running very hot. My a/c began to get warmer and my temperature gauge was at the "H". I pulled over and it immediately cooled back to normal operating temperature (in the middle of the gauge). The car was left running this entire time and I began my way back to my destination. It never ran that hot again but when I would slow down to an idle I noticed at times it would go up in temperature, but not as hot as before, and go back to normal temperatures. Sometimes during a drive it would fluctuate a little bit, but nothing as much as it would on the very start of running this car cold.
So I opened my hood and looked at the reservoir and noticed I do not see any fluid in there. I guess I should add that I have never flushed or changed the antifreeze b/c I did not know I would need to change it until recently at the 5 year mark. I also notice a little but a pink crystals (about the size of a pencil head) on a bolt at the top left of the engine, right under were the oil cap is. But that is all I noticed. No leak in my driveway or other areas of the engine. I must note that I did the oil change myself and it was nice and black, so from my experience it does not appear to be a head gasket, b/c I would assume it would be milky in color if that was the case.
View 6 Replies
My sister has a 2004 gli 1.8t with 65k. The temperature gauge says its overheating, the cel is on, but the car appears to run fine, the fluid levels are appear to be fine, and you cant see any leaks. Her fiance thinks its water pump issues...
View 4 Replies
I am trouble shooting my temp gauge. I have a 1997 f350. I brought the truck a year ago and i have still not fix this problem. I install a new temp gauge and nothing changed. When ever the truck is running it reads cold and doesn't budge. Ive read that the gauge can be broken its self but during a few hot times over the summer. The gauge began to rise slower, never reaching normal temperature. A few times i messed with the heat and the gauge would shoot over the normal temp. The truck seems to run at a good temp sometimes hot though. The tube on top of the radiator is hotter than the bottom also.
View 3 Replies
My temp gauge (which very seldom deviated form its position) is showing above normal temps. Yeah its over 90 here but this is unusual for my car to run hotter. I put in a new thermostat about 3 years ago. I've also been adding water/anti-freeze because there was a small leak (that I finally found in the hose) that I corrected. Could it be that my mixture isn't a 50/50 mix or is it my thermostat again? They say they don't last long anymore???
View 1 Replies
I Have a 2003 Honda Civic EX that is running rough and the windows stopped working and the temp gauge doesn't rise. Would this be do to a bad/failing alternator or something else?
View 7 Replies
I have a 2002 Kia Sedona mini van and last night while driving home the light that for the gas gauge and temp gauge went out, the other dash lights are still working. How difficult is it to replace a dash board light and how do you find out how to get to this light bulb?
View 6 Replies
I have a 2002 Monte Carlo what recently had a new radiator, thermostat, intake manifold gaskets replaced. I was spewing coolant everywhere. Since the repairs with all new OEM parts, I still get the 'Hot Coolant Temp" warning on my dash. The temp gauge is pinned at 260 but minutes later drastically drop to under half way after which it seems to balance out at slightly under half way.
I also see the 'Low Coolant" as well even though I am full. All of this occurring while driving. I checked the oil and underneath the oil cap. No frothy or milkiness. Exhaust seems ok, no white smoke. The heat inside my car when i run it seems to go from warm to cold and back again. I'm praying it's not a cracked heard or blown head gaskets.
View 4 Replies
The truck I'm working on is a 2003 f550 with a 6.0, and 382000 kilometers. My service truck died on me couple days ago, while running. As I rolled to a stop, I noticed that my temp gauge on the dash dropped to cold. (Truck was hot). Tried starting, and I have a crank, no start situation.
After towing it to my shop at work, I hooked it up to my scanner, and found that the pcm will not communicate with the scanner (otc genisis). I have no injector buzz with key on, wait to start light comes on for an abnormally long time. I have 48.3 volts on the ficm,(4 screw), and haven't been able to find any chafed wires as of yet.
View 1 Replies
2002 ford sport trac.I have been having an ongoing issue that started with the engine cranking but would not turn over until an hour passed. After replacing multiple parts (cam shaft sensor, crankshaft sensor, ignition pack) I am now down to poor fuel economy as the last of the issues (roughly 12 in the city and 15 highway). I was told the issue may be the engine coolant temperature sensor going bad so I decided to replace it. I found this was very difficult due to it being a plug and locking pin design and in a very tight spot in the engine.
I tried to purchase a replacement and the parts store kept trying to insist on selling me a part with threading. I finally found someone that figured out the issue and found the part for the 2001 sport trac had the same plug style with clip that did fit but was shaped a little different on the sensor end which I assume was due to being aftermarket. I noticed that there were two plugs side by side and the one easiest to access was on the left and I was told the one on the right was the sensor that gave the temperature reading to the gauge.
After installing the engine coolant temperature sensor I found the temperature gauge on the dash now will not respond and is sitting below the cold end of the gauge completely off. Is it possible this is because the part was for a 2001? Is the sensor on the left (passenger side) the engine coolant sensor?I would hate to put the old sensor back in just to test if that's the issue due how difficult it was to put that locking pin back on. What to check that could resolve the gauge issue before pulling this sensor back out?
View 3 Replies
1994 Ford E150 5.0L. Will not start when the weather is above 70 Degrees F. No fire from coil...
View 19 Replies
I have a 2002 Chevy Impala with the 3.4L engine. The car has 180K+ miles on the original engine. The coolant temperature started fluctuating recently. Going from 200 degrees up to 240 sometimes 260 degrees.
I recently had the check engine light on with the P0420 code which indicates a bad catalytic converter, I had that replaced and I was hoping that maybe the lack of exhaust flow through the converter was causing the overheating. It is still fluctuating however after the converter replacement.
The coolant temperature seems to go up when the car is idling but when moving it starts to go back down to normal. I had the cooling fan assembly replaced last year after one of the fans failed. These are less than a year old and are both operating as expected.
A little history on the engine. It originally had that crappy DexCool in it that then ate away at the cheap plastic head gasket causing oil to leak into the coolant system. This caused the coolant to turn into 'mud' within the radiator and eventually the head gasket failed completely and I had to have that replaced along with putting in ethylene glycol to replace the DexCool. Now when the coolant system was flushed, I am not completely sure that all that 'mud' was flushed out of the radiator. So the radiator may not be operating at full capacity. In fact, driving through the mountains this summer going up inclines, the car would tend to start overheating.
So thoughts on what might be the issue, radiator, thermostat, sensor, water pump, something else? I'm pretty sure it's not the sensor because sensors don't fail in this manner (they fail either high or low). I'm leaning toward the radiator because once I get some air flow across it, the coolant temp gets back to normal.
Also, the A/C is sometimes working great and blowing really cold and other times it is just slightly cold.
View 11 Replies
My F-150 ac shuts down when air temp reaches above 80 degrees. The freon has been checked, the compressor clutch cycling switch & high pressure switch have been replaced with no effect.
View 9 Replies
I drive a 2002 Honda Civic EX with about 105,000 glorious miles on it. I decided to hit the road and made a weekend road trip to pick up a stranded family member. I live in Ohio and drove Lou Dobbs, my car, to Florida. It was about 950 miles one way. All was well until I got to Florida. I hit my first traffic jam and was sitting with the windows down enjoying the Florida air. Suddenly, the temperature gauge started to climb! It got pretty close to the red but traffic began to flow at that point. As soon as I reached 40-50MPH the temp began to fall again. I picked up my cargo and headed back. Each time I would hit traffic or a red light the temp would climb without hesitation. This is without the A/C running. After I got back to Ohio, i asked a friend who knows about cars. Over the phone, he had me remove the radiator cap and reservoir cap to take a look at the fluid levels. After this though, the car has never overheated! I don't understand. Can air get into the system and I let it out by removing the caps? I can sit in rush hour traffic for a half an hour with the AC running and the needle stays right in the middle. Should I still take it in to be looked at?
View 2 Replies
I have less than 7k miles on my new Silverado W/T. I haven't hauled anything heavy in it since I bought it, and have been using it just back and forth to work. Pretty light duty. I was parked the other night in a parking lot idling and listening to the radio when I noticed the transmission temp jumped up to 189 degrees! I also noticed the water gauge was a bit past it's mid-range temp. I immediately cranked up the heater core to try to cool things down and it worked for the main radiator water temp..but the tranny sender quickly went to 200 degrees so I shut the whole mess down.
Just before I did that, the transmission idiot light popped on. I left it there for several hours in 20 degree weather and came back to start the truck and head home..the tranny on start-up was still @ 70 degrees. I got up on the hiway and things came down to about 100 degrees at a legal speed on the hiway. Engine water temp was normal too. Drove for about 45 minutes that way. I tried sitting in my driveway a day or so later in park, and the tranny temp went from 120 degrees to 145 degrees in 35 degree weather fairly quickly.
View 14 Replies
My engine is very slow to warm up when the temp is below 30 degrees. Engine will reach about 170 after about 5 miles. What should I check first? Is it hard to change the thermostat or is there something else that controls the engine temp?
View 1 Replies
