Prius (Gen 4) :: 2016 - Grille Shutter Inoperative Warning And Check Engine Light On
Jul 18, 2016
Relatively new 2016 Prius Four with all the boxes checked was working just fine this morning. At the end of the work day I got in the car to drive home and I got a warning - 'Grille Shutter Inoperative Visit Your Dealer' - accompanied by a check engine light.
Since I'm a little over 200 miles from a dealership I'm in a bit of a spot. They have a local shop that they contract with but they can't get me in until Thursday.
View 12 Replies
Advertisement
Recently there has been a series of problems popping up with the Prius. Its a 2003 model year.
- About four nights ago the warning icon and check engine light (picture below) popped up upon engine start-up and i noticed a weird idle. It seemed to idle rough. After about 20 seconds of idling the engine would shut off. After about 10 minutes and 6 or 7 attempts to restart the engine the warning lights disappeared and idle seemed to be restored.
- The afternoon after that the same warning icon and check engine light popped up along with the rough idle. After about 10 minutes and 6 or 7 attempts to restart the engine the warning lights disappeared and idle seemed to be restored.
- After this incident it seems like the vehicle is getting bad gas mileage. The picture below shows me getting an average of 25mpg. I was driving very conservatively. Driving the same way i usually do, i usually get 45-50mpg. The vehicle seems to be charging the battery more than usual.
View 19 Replies
My wife and I own a 2006 Toyota Prius that we bought used 2 years ago. a couple of days ago, the master warning light (red triangle exclamation point) and check engine light came on. I took it into the dealer and of course, our hybrid battery was dead - battery and a new ECU required.
Our car is at 99,000 and 32 days out of warranty. Went down the road to atlanta hybrid repair. they were incredibly nice, and said that my computer was fine, but the battery would need to be replaced.
View 20 Replies
I have a problem with my 2002 prius. I was driving home from work when all of a sudden my Hybrid Warning light came on with the check engine light on. On the screen, it gives me a (PS, Battery, and ! ) and the "!" was the one lighting up. The engine was roughing up sounds like it was gonna stop itself so I pulled over to the side and it turned off by itself without me doing anything except to put it on park. Then, i took out my keys and tried restarting it and all i heard was the "Ready" beep but not the engine and it won't move when i step on the pedal. After waiting for 10 mins., i tried restarting it and it worked i drove away and got home safely with all the warning lights i mentioned earlier still on. (Note: i was driving w/ the A/C on because it was hot outside..around 90s, also it was not overheating nor it was any battery problem because all the electrical were working properly.)
View 11 Replies
I have a 2007 prius. I was driving home all a sudden I get a big red triangle warning and the engine logo came on. On the display screen its show a logo of the car at the corner in red with exclamation mark. I use the car obdII scanner but no error code came up. I decide to check the engine oil. When I remove the cap, I notice inside the engine it look weird like a gold color and some blackish. The engine cap inside look like it have stains on it too. The hole where you pour the motor oil down I notice that piece inside don't go down for the funnel to stick in. I attach some pictures. I have no clue what's wrong with it and I don't wanna drive it to make it worse. The prius only have 90k miles on it.
View 19 Replies
I have been using it since last 10 months and was totally in love with this car.. But recently, an error showed up on MFD as well as the engine checklight came on. all this happened after a while, when i started the car one fine the morning..
car stats:
model: 2008
mileage: 123300Km
bought at 92000Km and was trouble free till now..
View 5 Replies
Possible hybrid battery failure in my 2004 Prius (96K miles).
Sunday before last, the check engine light, warning triangle, and hybrid warning light came on when I started my car at the grocery store.
Because I was close to home, I drove home and the car functioned completely normally. The next morning, when I started the car, the same warning lights appeared. However, when I tried starting my car with the headlights off (I always leave them on), no warning lights appeared.
I took my car to an independent mechanic. This is their written report:
"Found multiple check engine codes, P3000, sub code 123, V0100 sub code 211/330. These codes are set when high voltage control detects a malfunction in battery pack/ECU assembly. To check battery pack we took vehicle out on a test drive while monitoring the cells in the battery pack. Found that they are all weak and drop fast when battery is put under a load. Code C2318 is a low voltage error/power supply malfunction code with the auxiliary battery. The voltage spec for setting the code is 9.3 volts, this battery is less than 9.2 volts."
In conversation, the mechanic also told me there was significant voltage variation across the cells in the hybrid battery.
I then took my car to the dealer to try to confirm this analysis. They were unable to read any codes because the independent shop apparently cleared them. The dealer was unable/unwilling to do more than read the codes to diagnose the problem. (Indeed, they seemed surprised that the independent mechanic could monitor the cells in the pack.) All they did was to drive the car around some more to see if the check engine light would come on. It did not.
The car has been driven 80 miles since the warning lights last appeared and appears to be behaving normally. From your perspective, does the report from the independent mechanic make sense and is it believable? And is their test under load definitive of a hybrid battery problem? Could the results be affected by the low auxiliary battery? Also, if I do have a hybrid battery problem, what are the chances of being suddenly thrown into limp mode while driving it?
View 5 Replies
2006 Prius with 164,000 miles.
First in the morning, starts fine, 500 feet later I'm turning out of neighborhood and I get lit up with:
Red triangle master light
Yellow brake warning (went away after I did signal check)
Check engine
Maint required light
The maintenance light is on because I'm 5,000 miles out of an oil change. I checked the stick, it did appear low, so I added a half quart of mobil 1 5w-30.
The inverter pump was changed due to recall in 2012, and I do still see turbulences in the fluid.
I have 3 pips of gasoline in the tank.
The 12V is a newly replaced yellowtop from elearnaid. Replaced about 1 year ago.
View 15 Replies
I need to get my 2002 Toyota Prius inspected. The Warning/check engine light came on so I ran a diagnostic (OBDII) on it and came up with P3006 Fuel Air Metering Auxillary Emission controls. What does this mean? Previously codes indicating cylinder misfire came up but those cleared.
View 3 Replies
Stopped at ATM when heard a thump under seat and all the above appeared on control panel. Waiting on computer code reader to test vehicle. Any clues to what all this means. Vehicle 2006 with 101K. Recent service as scheduled with coolant and inverter coolant and belt replacement done. No other issues to date with vehicle.
View 13 Replies
2010 F-250. the tire pressure warning light is on and the cruise is not working. Verified all TPMS sensors are working and sending signal with the reprogramming tool. using my scan tool, I got several U codes saying there is no communication with the instrument panel control module. I have cleared the codes, they did not return immediately and the problem persists.
View 2 Replies
My 'check engine' warning light just came on after only 12,000 km on my 2011 GLS. What emission control part would be the first to fail? I ran my 06 Sonata 100,000 km+ and never saw any warning lights! And no, it's not a loose gas cap!
View 13 Replies
This morning, the tow/haul light came on, tranny temp gauge wouldn't read (stayed below zero), "check gauges" warning came up on the panel, and "check engine" light came on. Truck ran fine/shifted fine, always has.
2007 F-250, V-10, 5-r 110 tranny.
View 5 Replies
I have a 2006 Powerstroke F350. Recently, the "check air filter" light has been coming on. It comes on intermittently, and every time it comes on it makes a warning tone. Super annoying.
I reset the minder, and even tried unplugging it. No change. I think I must have a short in the sensor wiring, but I can't seem to find a wiring diagram that shows the air filter sensor.
Looking for a wiring diagram that shows how the minder is wired? Or What is the part number for the relevant wiring harness?
View 2 Replies
So I was driving for a couple of hours today in my recently acquired 2001 Prius, when the red warning triangle and the check engine lights came on. The car seemed to still drive fine (70 ish mph cruising). HV Battery? P3000 P3020 Error codes.....
View 17 Replies
I was driving last night and my car Triangle Warning Light and Check Engine Light Went on along with on the nav screen a car with a ! mark in it came on. On The info screen the battery level was changing fast from fully charged to just about empty. The car lost almost all power going about 42 miles an hour. I was able to pull to the side and i waited 10 minutes then tried to turn the car on again. I was able to drive home and the warning lights were still on but at least my car had power. What could possible be wrong?
View 19 Replies
I have a 10 month (15,000 mile) Prius and the " check hybrid system" warning light came on while driving on the interstate. 17 miles later the car quit running. I had it towed to the local dealer and after taking a looking at it I was told the error code pointed to the water pump (which they plan to replace). Does that make since? Has this been a problem for the Prius IV?
View 4 Replies
I have a annoying check coolant additive warning light that wont go away, is their another way to turn off the light other than the button on the steering wheel? I have searched the forum but have had no luck, my coolant level is at it's proper level.
View 3 Replies
As far as the owner can tell, the car is running fine. He hasn't driven it aside from getting home after the light came on. It seems to give a very informative error message. What it's saying?
View 4 Replies
My 2005 Prius with 116K on it has been having some uneven acceleration lately and today the Triangle warning light, the check engine light and the brake light came on at the same time. I had about 1/2 mile to go, so I proceeded slowly and called the dealership which had performed a routine oil chg two days ago. They said that if the lights weren't flashing then I could drive it. They recommended that I take it to AUTO ZONE and put it on the analyzer. This elicited these codes: P3019: no definition and P0A80: replace Hybrid Battery.
I have an appointment in 2 days and I'm wondering about a salvage HV battery since the car is 7 yrs old and over 116K miles.
View 4 Replies
This afternoon, after driving about 150 miles, I came home and shut off my 2001 Prius. It was sitting for about 20 minutes before I turned it back on to drive off. Almost immediately, the hybrid warning light came on on the MFD, the red exclamation mark light illuminated, as well as the check engine light, and the motor shut off. I popped the hood, and could hear a high pitched squeal coming from near the inverter. I called my dealer to ask the service department what I should do, and they just told me to bring it in and they will take a look at it. I live over an hour away, so I don't want to bring it there if I can avoid it. I then shut it off and let it sit for a few hours.
After reading about the possibility of the auxiliary battery being bad, I went and turned the Prius on, and then shut it off several times to reset the hybrid warning light (I had to do so in order to access the aux battery information through the MFD). It turned on without incident, and shut off fine, and after being reset the hybrid warning light shut off, as well as the red triangle light. Then, I went through the process of pulling up the battery voltage information through the MFD.
With the car off, and the lights and fans off, the battery voltage read about 10.0-10.5 V. With the lights and fan on, the voltage dropped to about 9.5 V. After getting those readings, I drove it down the road a little ways, just going about 20 mph. It seemed to work fine. The check engine light is still illuminated. With the motor running, the voltage reading was 13.2 V, and then when I got back from my test drive and shut it off, the voltage hovered at 10.6 V with the lights and fan on.
View 19 Replies
