Prius (Gen 3) :: Blower Motor Making Noise
Jan 14, 2016
My prius that I got about 1 1/2 years ago (2013 model) was making some noise. After conducting a few experiments I came to the conclusion it was the heat that was causing it. I removed the glovebox and lower plastic panel as well to see if it was actually the blower that was making the noise. And it was the blower.
So now it's like 20 degrees outside and I haven't used the heat because I didn't want to blow something so gotta get this fixed ASAP.
Like I mentioned glovebox and lower panel are open I've removed 2 of the 3 screws necessary to remove the blower. So the problem lies with the 3rd screw. There is a plastic socket with wires that is preventing me from reaching the 3rd screw so I have to remove that socket. So I have a couple pictures and how I can remove this so I can access the blower motor.
Also isn't it strange that the car isn't even 3 years old and the blower is giving me problems?
View 13 Replies
Advertisement
I have a 2005 BMW X5 and the heater motor makes a shrill noise only when I am turning right.
View 1 Replies
My A/C has been making a loud noise for a couple months now ,only when I put the A/C on the highest setting. I was LONG overdue for a cabin air filter change so I bought a new one and while I was down there I looked inside the blower motor and here's what I saw... It is now blowing fine and not making a noise . Sprayed some Ozium New Car spray on the new cabin air filter and my car is smelling great now !
View 4 Replies
I have a 1993 E350 Econoline-based RV. The blower motor intermittently makes a horrible whirring/buzzing sound, usually if on position 3 or 4 (high). Doesn't stop until I turn the HVAC to Off. The blower motor vibrates quite a bit while making this noise (verified with my hand). The problem occurs even if the engine isn't running. This started a few years ago, and has simply gotten worse.
Since it runs OK at the lower speeds (until the problems start with the higher speeds), I think that means I can rule out something simple like debris? Also, when the engine is under load (climbing hills, etc.), the blower fan cuts out. Could that be a resistor problem, or something else?
View 13 Replies
Ok, I turned the A/C on High 65 degrees and drove about 2 miles home with four people in the car. When I turned the car off and got out I heard hissing and what can only be described as .. Well the old metal / Aluminum ice trays that we used to make ice cubes in the freazer? My kids said it sounded like the car was singing or playing music? I opened the hood but did not see any thing frozen. It took about 5 minutes to slowly fade out and stop making noise.
View 3 Replies
I noticed that I have an unusual "rumble" noise coming from the location of my ac blower motor when it kicks in full blast. When the air temp comes down a bit and the AC slows down or if I switch the ac off full blast under climate control, the noise goes away. I have never noticed this before and am wondering if it is my ac blower motor starting to fail.
View 3 Replies
I got a Prius c 2015 and when I got the car home (about 13 miles) the gas motor was making a noise when the car was turned off. It lasted about 3 or 4 minutes. Is that normal?
Also the brakes sound a little like a jet as I slow down. I think the brake noise is normal but the gas engine one is what concerned me.
View 10 Replies
My wife heard a humming noise on a 200 mile trip to Long Island last week. It was loud enough that she was concerned about it and took it into a Toyota dealership to have it checked out. Of course, the noise went away, and they assured her that the car was perfect!
When she came home, I drove the car and the noise came back. Radio was off and the frequency of the noise changed with the AC/heater blower speed. Turn blower (fan) off, and the noise completely disappears. Before I got home, noise disappeared again with the fan on. I believe it is a bad bearing in the blower motor.
View 1 Replies
I'm getting this weird chirping noise from what sounds like the A/C and Heat fan. When I turn it down it is noticeable and sounds like something needs oiled. Kind of like pieces of plastic hitting each other over and over again. When I turn the air up there's no noise but probably because the air rushing out is so loud. I'm thinking I may need to take something out and oil it up. Too cold here to do my own thorough investigation.
View 4 Replies
I have 2011 SE (2.4L) that has a VERY noisy squeak that increases with the climate control's blower speed. The noise stops completely if the fan speed is set to OFF. It has been rectified twice by the dealer, who said they just vacuumed it out or something, that there was leaves/trash somewhere causing this. I don't even park near trees or anything! Anyway, my car is now out of warranty, how can i do this myself?
View 5 Replies
How to replace blower motor in 01 Prius. There are no way to get from to it from under the glove box.
Blower motor was working fine. I decided to remove cabin filter. Filter had not been changed for very long time. There was a lot of dirt, pine straw and leaves on top of the filter. When I removed the filter a lot of dirt fell inside the motor. Ever since then motor is working on and off. Often have to hit under the glove box and it works again for a while. Tried to remove the blower but could not get to it.
View 14 Replies
Several weeks ago, the blower motor in my 2010 stopped blowing. It came on within a day or so, but failed again, so I replaced it with a new part from Rock Auto: TYC 700249.
The new fan just stopped again. I plugged the harness in and out several times and it did briefly come on a few times, but clearly something else is going on.
I don't know if it's relevant, but after I took out the OEM fan, I experimented by removing the plate from its back that has wires and capacitors (actually, I don't know what I'm talking about) and connected the main prongs directly to a 12V battery. It came on right away. I installed the new fan anyway, figuring it was the plate/wires assembly portion that was bad. The "resistor?"
View 7 Replies
My Prizm is making a noise that seems to be related to the blower but sounds like it is coming from behind the control panel/radio. Even changes volume and stops with bumps. I am going to check the blower motor motor, but sound doesn't appear to be coming from the dash area where I believe the blower motor is. What else it may be?
View 4 Replies
Recently my a/c in my 2007 prius has been on the fritz. Some days it chooses not to blow any air at all. Others it will blow upon start up with cool air. I just took a road trip and it didn't work for 2 hours then magically came on blowing cold air. I took it in to the local shop to see if they could figure out the issue. To my disappointment, all the "parts" appear to be in good working order. The technician said that the electrical system just wasn't getting to the blower motor and that I should take it in to Toyota.
View 4 Replies
So for a few months now, my car has been making a subtle clicking noise whenever I have the ac or heat on, kind of similar to the noise spokes on a bike would make when children put a card in them. The noise increases/decreases in speed as I adjust the ac/heater speed.
Recently though, it's gotten to a point where sometimes, the blower motor would completely stop working. I can still feel heat and cold coming through the vents when I turn the AC on, but the it doesn't always blow air. I've noticed that sometimes when I hit a bump in the road, it starts working again. It works at all settings and all temperatures perfectly (when it's working that is).
How should I proceed? I don't know much about cars, but from what I've seen on the internet, it doesn't seem too difficult to replace the blower motor. I just want to be sure that the blower motor is indeed the cause, because I don't want to install a new one to be disappointed when I turn it on and still have the same issue. And winter is just around the corner so I would love to get this taken care of.
View 4 Replies
2004 Prius, 135,000 miles.
About a month ago, the blower motor stopped coming on all the time. A quick whack under the glove box fixed it when it didn't start. Then about a week after that, I felt like the AC wasn't really warming when needed. This may have been true earlier, but it hasn't been that cold around here, so I wouldn't have noticed, perhaps.
About a week ago, I start hearing what I might describe as a rattling kind of noise I had never heard before sometimes under hard acceleration. Not always. Didn't hear the noise tonight, for example. Of course, then, tonight, on the interstate, the warning light pops up for just long enough for the temperature indicator to flash up. It quickly disappeared, but in the remaining two minutes I was driving, it flashed up briefly twice more.
Now, in digging around on this topic, I've read about issues with the inverter coolant pump, and that there was a recall. How could I find some information on this recall? I don't remember ever having it changed, so I'm just curious what I might need to say to get that swapped out under a recall if appropriate.
Also, based on what I've said, does it seem likely that the issue is with that pump? It sure seems to fit the bill, but who knows. I'll be bringing the car in ASAP but I'd naturally like to be armed with as much information as possible.
View 2 Replies
I am struggling with it, and need to get it done - by myself, as I can't afford a service job. I am handy, and comfortable doing it, But I am confused about how to get into the blower housing.
View 4 Replies
Started up the 2002 EXP today and thought the fuel pump was failing. Get a consistent thump every 1 second. Later today i looked and noted the noise is coming from drivers rear fender well (i think). I took off the small plastic cover of the rear blower motor and thought it was in that area. Disconnected the motor and still thumps. Disconnected the blower motor resistor block and still thumps. Looked at the overhead consol and the rear blower was on HI. Turned the blower down and as you reduce speed the noise volume is lower. Turned the switch off and i thought the noise was gone. Pulled the cup holder above the fender well looking for a relay or something in that area. I cant isolate the noise but seems to be real close to that area. Later i heard the noise, very faint, and the blower switch was off. Turned it to 1-2-3 and it gets much louder. Turned it off and very slight noise. What am i looking for? My hearing is not accurate enough to find it.
View 2 Replies
So the evaporator in my dads Prius had been leaking for a while so we finally decided to bite the bullet and change it. Everything came apart fine. Changed the evap and expansion valve. Put it pretty much back together except for glove box and a pillar trim pieces. Push power button twice to make sure all the flaps and blower motor works as it should. Well the blower motor doesn't come on. I hear the relay click when you turn the fan on in the mid. No power at the fan though. I checked just to be sure. I've looked all over for loose wires/plugs but have yet to find anything. I started the car up and everything works fine except the blower motor. What it could be?
View 13 Replies
blower motor was intermittent on my 08 prius, now only works when i spin it. Looking for a pdf or instructions on replacing it myself?
View 1 Replies
I have started to have very intermittent problem with the blower fan. When I turn the fan on or auto, no fan blows.
If I hit the dash, over top of the display screen it will engage and start blowing.
2007 with 115k miles. I assume this is the blower motor dying a slow death.
I also assume this is not a DIY and will be expensive to fix.
View 7 Replies
