Prius (Gen 2) :: Suspension Noise Keeps Coming
Oct 9, 2010
Well, even a supposed Toyota specialist shop couldn't figure it out.
Replaced:
Shocks
Strut Mounts
Inner Tie Rods
Outer Tie Rods
End Links
Engine mount
The ball joints keep passing tests, two different shops swear they're ok.
The road by my house is being repaved, as such, it's really chewed up, and when driving over it, it truly feels like the whole front end of the Prius is going to fall off. It's like the loud, dull, clanging of metal bars.
View 3 Replies
Advertisement
Since new my Prius V has had a metallic clattering sound that comes from underneath the car. This can be replicated when driving over lane divider dots on a quiet street with the windows down. To investigate, I put the car on ramps and looked around; I was almost certain the sound was coming from a thin aluminum heat shield that is just behind the engine. Tapping this shield made a similar sound to what I heard coming from under the car while driving over bumps and such. The shield is poorly attached with those "fun" push pin fasteners that seem to be liberally deployed all over the undercarriage. I decided to re-attach the shield with a judicious circular application of silicone under each of the holes in the shield and let it dry. The clattering sound I heard previously when tapping the shield was gone. Out for a test drive and still there!
I just had the first service done, and of course the tech couldn't hear it on his test drive. Unfortunately I was pressed for time, so I wasn't able to take a test drive with the tech. I will drive the tech around next time and demonstrate it.
View 19 Replies
Parked Prius making awful sound from brakes. Could it be Suspension? However, I am not sure how to describe this one.
View 10 Replies
I just upgraded from my old 92 camry with 350k to a 04 camry SE.
When I bought it it had a noise in the right rear suspension of the car. I just assumed this would be something minor so I bought it anyway. Shortly after I had the car I noticed there's a clunk in the steering and it turns out my intermediate steering shaft is shot. Turns out this is a common problem.
Its mostly one one side (passenger). Its more of a thumping sound then a rattle and happens on just about every bump or hole in the road. I've replaced the swaybar bushings, the links are fine. Just to be absolutely sure I disconnected the links and drove the car with no sway bar and it had no effect on the noise.
I've replaced the strut mount, and while I had it out I checked the shock. Shock is fine. No leaks, dead spots or any play in the shaft. I've taken everything out of the car, spare tire, jack everything in the truck to eliminate any of that stuff bouncing around. All the control arm bushings seem tight, but I haven't spent much time checking this, need to give the bushings another look.
Are these something that commonly goes? I've checked all the exhaust hangers, rocked the exhaust back and forth, doesnt seem to be hitting anything.
View 14 Replies
There is a noise I'm trying to locate and diagnose, comes from under this 2004 Accord DX, 5 spd. i can't locate 'where' precisely. it occurs intermittently, seems correlated with suspension parts' responding to load and forces (for instance, turning into a parking lot, where there's a slight dip at the paved curb skirt entering the lot, or when there's a modest bounce as car travels along the highway--when the stable momentum of travel is interrupted, making for a "bounce" or some force transferred into suspension, e.g.). ---The sound is low in register, not loud, and best i can do is 'imagine' what assembly (assemblage, or rigging, or set-up, or contraption) could produce such a sound.
The sound--to my experience and auditory senses is like, of a torsion bar, maybe a 3/4-inch steel rod, as might be fitted transverse somewhere at rear axle area, that would serve to stabilize the sway of the vehicle, under turning conditions; (I'm only guessing here, cause my pod-nur says, or 'hears', the sound's coming from front suspension area, like when load is taken at front strut, going over the slight dip when turning from road to parking lot). so what i hear, I imagine to be a point on the rod coming sudden contact with another metal part enough that the strike produces a tuned "spring" sound, the kind of sound i imagine a spring-tensioned rod would make, or like a staccato bass note, as piano bass string could make.
M bad on the metaphor here--yet, the approximate pitch of this pernicious occasional noise is near the A or the B, in the octave below middle C--i just now tested those notes, trying to be sure I'm 'in the ball park' in reporting and elaborating symptoms, all of which have to do with 'sounds' thus far. There doesn't seem to be any other evidence of frailty, or deterioration of handling, or efficiency of the vehicle. But my concern is that maybe some rubber grommet, or shock-absorbing hard rubber part, is allowing a loss of tolerances that will develop into some dangerous driving performance--a line of concern that one would take if one heard the clicking of a CV joint, tho my case had nothing to do with that realm i believe.
View 6 Replies
I'm new to vw and I have a passat 3.6 sel premium and I have been hearing a noise coming from my rear suspension when I have a full car or going over speed bumps and such. It took it to the dealer and they said that they couldn't replicate the problem, could it be the control arms or it's bushings? The car is only 6 months old smh.
View 8 Replies
Suspension noise I am getting from my 2011 MD.
This noise occurs only over small shock type bumps IE, train tracks that are not smooth, those reflectors in the road, and the metal plates over construction projects. Any bump that forces the suspension over a small vertical or near vertical drop or rise of about one inch.
In my driveway I have a storm grate about an inch lower than the surrounding pavement and it rattles over this every day. Now the fun part.
The noise is ONLY when I hit such a bump with the right side of the car. The left side rolls over the same bumps smoothly and quietly.
This noise is also only present over the small type bumps discussed earlier. My dealer has a rough road that they use to test suspension noises and the car rolls down it silently. The problem also doesn't manifest itself over speed bumps.
The noise is still present while applying the brakes on which makes me doubt its a caliper float issue.
The strut brace and lower control arm/bushings on the right side have been replaced by the dealer under warranty but they can not seem to get to the root of this problem as both these replacements have had no effect.
From inside the car it is very difficult to pinpoint where the noise is coming from but it almost seems like the center of from suspension.
View 4 Replies
I have 2007 hyundai elantra se with hankook optimo h426 tires. I like the car, everything is very nice except, the tires. I'm driving a lot in the streets and when i hit a bump or pothole, the car making a lot of noises(rattling noise) coming from the suspension (all 4 wheels). The dealer check suspension and said that evrery thing is good.I also think that suspension working properly, because a can not believe that all four shocks not gonna work properly at the same time. Can be this from the low quality of the tires and if i change the tires ,this gonna solve the problem?
View 31 Replies
I have weird noise and from just a quick inspection of the car, I don't even know where to start to inspect...
Current setup:
30,000 km
stock clutch
stage 1+ Unitronic @ 5000km (1 track day)
stage 2 w/ hpfp Unitronic @ 27000km (1 recent track day, drove it hard but not prolonged, perhaps 20-25km on a 1km course over 2 hours at max)
VW v2 (~15000km)
drivetrain taken out to install DP @ 25000km.
H&R Rear Sway (setting: stiff)
I feel a weird 'clink' as I turn, and via multiple observations here are the only times I've found it semi-repeatable.
- heavy hard turns (only had a few instances where i could try this out and not 100% repeatable)
- slowly pulling out of a parking spot (turn radius on the steering wheel is more than 50% of a turn) - usually turning left (repeated a couple of times now)
- turning into a driveway (mini bump) @ less than 20km/h
- usually right turn more often then left does this appear
Also, its the noise is coming from the driver side wheel and sometimes right above the drivetrain. this can also be felt if my clutch is semi-engaged (or when i have my foot on the pedal). I have hoisted up my car to do a quick visual inspection (sadly didn't pay attention to the drive train /shaft). but found nothing suspicious (keep in mind it was relatively quick as the shop was closing). one thing i found that was loose and thought was the culprit was a plastic arm with a metallic tube that came off on the driver's side rear control arm .
View 16 Replies
2001 vr6 manual... I have a popping noise that comes from my suspension. it is in the front, and it has gradually gotten worse over the last month or so. It used to happen when i back out of my drive way only, but now it happens when accelerating from a stop, quickly braking or turning at low speeds. Recently its getting worse and i can start to feel it in my steering wheel sometimes. It doesn't feel like a wheel bearing. Is it bushings? Tie rod? CV Joints? Strut Mount?
View 2 Replies
So I started hearing these random squeaking noises coming from the front suspension its what it sounds like. This only happens thou when i drive up into a drive way that is slanted. Or any kind of slow making slanted turns (~5-10mph)
I'm not 100% positive but it sounds like the suspension because it only makes noise when the car moves a little when ever i go up a drive way.
View 19 Replies
Every time I am on the road I get this flat noise coming from the front like if the strut was out of air or something like that. It is a very annoying sound and only on certain bumps of the road.
View 6 Replies
Since Ive got my 2010 Tiguan 2.0 TSI, I hear a creaking noise coming from the front right suspension when riding over uneven pavement. The dealer said it is a common known problem from many Tiguans caused by the engine mount and that VW recommends the change of that part.
The new engine mount is slightly different from the one that is installed in my car. I am still waiting for the part to arrive and to be changed. Meanwhile, I spoke with another 2010 Tiguan owner, here in Brazil, whose car has already received the new part.
He said that the creaking noise has gone but now he feels more vibration coming from the engine and a kind of "diesel-engine-sound" when accelerating... Location of the engine mount: [URL] ....
The "old" engine mount bears the code:
5N0 199 262 G
5AY CN
M086
09/03/27
[URL] ....
The "new" engine mount bears the code:
5N0 199 262 E
5AY CN
M082
09/03/10
[URL] ....
I assume that the first number is the part number, the last is the manufacturing date and the others are either car model or manufacturer code or anything else. Note that the part number is the same, except by the letter suffix: "G" in the "old" one and "E" in the "new" part. Well, the suffix designation does not make sense for an evolutionary design...
My questions are:
1) Is it a new design or is it a roll back to an older part that does not cause that problem although it was probably modified due to another issue?
2) Is this part number specific for 2.0 TSI engine or is it the same for other engines (petrol/diesel)?
3) Which engine mount have you got on your cars?
View 12 Replies
I have a 06' Ranger 2WD with General Grabber tires that have about 30,000 miles on them and still show significant tread remaining.
Within the last 2 months, I have experienced excessive tire noise - like I am driving a Humvee or something. Also, when I turned right or left the tires would make even MORE noise - it seemed to be coming from the right front tire mostly. 2 weeks ago I had the tires rotated and the sound seems to have reduced while turning but I still have the howling Humvee noise while driving down the road. There is no vibration coming from the wheel, so I don't think it's a balancing issue. Could it be the bearings?
I also checked the PSI all around and one tire does have a slow leak but I try to keep to topped off.
View 1 Replies
Took my car in for 10k mile service and let them know there has been some clicking noise coming from the front suspension when making a left/right turn...
I dropped off my car on September 21st and they have yet to complete my car... I've called them every single day since but, I don't get a good explanation from the dealer...
View 10 Replies
2011 GLS 2.4L auto, 40K, out of warranty
There is a loud groaning/creaking noise coming from the front suspension area. At low speeds, this noise dominates all other noises and is directly related to hitting the gas or pressing the brakes, which produces a forward or backward force on the front suspension and chassis. I can sometimes hear it briefly just by pushing against the parked car.
My hope is that I can just tighten up some bolts and make this go away, but other posts suggest it may be struts, stabilizer links or other non-obvious sources.
View 4 Replies
I just purchased my first VW, a 2012 Tiguan SE in Night Blue Metallic. The level of fit and finish, handling, and general feel are miles ahead of my old '04 Jeep Liberty.
Anyway, I've had the car for about 250 miles and have noticed a clunking/rattling noise coming from what sounds like the front passenger side suspension arm. The noise is fairly quiet but seems to consistently happen when turning left over uneven pavement.
I plan on taking it to the dealer this weekend and it is only a minor annoyance, but a shame since the rest of the vehicle is so quiet and refined.
View 3 Replies
2012 truck, started making a noise today. I cannot tell what it is, but seems to be coming from the passenger front suspension, its a crunching/light clunking sound, happens when going over bumps, when the truck pitches one way or the other turning, and coming to a stop....
Truck has 6k miles, I did a quick visual inspection this afternoon, didn't notice much, but the sway bar endlink looked a bit odd though, not sure if normal, its gota little bend too it and seems to just contact the vac line mounted behind it, seemed unusual...
Maybe its its just one of the crappy rancho branded shocks is junk?
View 6 Replies
So on my 2003 F250 SCLB 4x4, I I was driving 70 or 80 miles to Huron in Ohio, to pick up a boat for a buddy with my truck. On the way up I heard a new clattering noise coming from the suspension or drive train, and we couldn't figure out what it was. After picking up the boat and coming back home without a problem, I looked under the truck and couldn't see any U-joints loose, But I saw that my right rear backing plate was disintegrated and gone. I took the truck to the shop and they said that the noise I'm hearing is the guts of the emergency brake pads and pins bouncing around in there when I drive and that my rear wheel could lock up at any time.
View 14 Replies
2002 F-250 7.3 4x4 ...
I have a rattling noise coming from the front suspension (both sides) when going over small bumps. Most people point to ball joints, but I find my case odd because I just replaced
Upper/Lower ball joints
Track bar
Tie rod ends
Shocks
Front U joints
Drag link
I did not touch the leaf springs or the sway bar, except to grease the links, which otherwise looked good.
View 3 Replies
Since I got my Prius V, i have this noise form the suspension... when i go over a bump, or a hole... It sounds like the exhaust is hitting on something. It could be the brakes too. It does not sound like something is broken, but more like a tin sound hitting on something...
If windows are closed the ride is smooth, but when I open i keep hearing this sounds, and its driving me crazy... Is that normal for Prius V because of the different tiers?
My Accord does not have any similar sounds driving on the same road every day... actually ride with Accord is way better... Is that normal, should I go back to dealer? Car is 3000 miles only...
View 6 Replies
