I have a 2004 prius that will not start. First let me tell you what we have replaced so far (within a week) inverter pump, thermostat, water pump, battery 12V(brand new from toyota) and the inverter and it seems to be stuck in drive, but we cannot get it started to figure that one out.Code was reading p0A78 and even after changing inverter it still is reading that code is there.
View 7 RepliesAfter the car shut down and had to be towed to the dealer,the inverter was replaced (fortunately we were just under the 80k mile hybrid warranty). The problem now is that the headlights and parking lights are not working. We took the car back to the dealer who said it was no doubt burnt out headlight bulbs. I told them that the parking lights were also not working and they insisted it is the headlight bulbs.
View 3 RepliesI have a 2010 Prius, currently at around 69,000 miles. Back in Feb 2015 (when it was just under 60,000) I was driving on a city street and hit the accelerator once a stoplight turned green - immediately as I took off (at a normal rate of acceleration) my 2010 Prius made a loud noise and I got the red triangle of death, with a "Check Hybrid System" message. The car quickly shifted into "limp home" mode and I was able to make it back home as I was only about a mile away.
Got towed to the nearest dealer the next morning and after tons of testing and going back and forth, they replaced the transmission and inverter (was able to get it covered under powertrain warranty), and I was on my merry way. No issues until last night.
Yesterday evening, I am on a city street and get a warning beep. I look at my dashboard and this time I have a yellow exclamation mark with the "Check Hybrid System" message yet AGAIN. Towed the car to the nearest dealer and am now waiting on next steps. Only update I've gotten so far is that they are still trying to diagnose the issue, and are getting 4 error codes in this process, 2 of which are new. I am waiting on the technician to tell me what the actual codes are - hopefully should get them tomorrow.
I would hope if it's another issue with transmission or inverter, it's covered under warranty given I replaced both less than a year ago. However I'm not sure and am worried that it's going to be $$$ in case it's something else that failed. Plus I'm getting serious doubts as to the safety of my car - what if I had been moving at a high speed on the highway during either of these situations?
I just bought a 2006 prius. It had 2 bad cells in the battery pack. I replaced the cells and all seems to be well, they all read the same voltage and the car appears to be driving, charging, working.
I still have the red exclamation mark and check engine light. The only code I get says to replace hybrid battery pack.
There are no other specific codes or issues and it runs perfect. Basically I guess what I am asking is how to clear the light or figure out why the light is still on!
I bought an 01 Prius with 148k miles. It had code P3125 which mean bad inverter. I replaced the inverter with one from a junk yard with 81k miles. As soon as I was done the car started right up, and I didnt get electrocuted!
Right after the car started I got codes P3115 P3001 and P 3191. I cleared them out and turned off the car for a min.
When I started the car again I got codes P3030 and P3001.
This car has an extensive service history, It has a new Cat and exhaust, a new accessory and HV traction battery that are less than 8 months old. Crank position sensor is new. fuel tank is new.
What could be causing the P3030 and the P3001?
While driving home last night the Red Triangle, CEL and the Hybrid Warning lamp, (on the MFD) all lit up. The cruise control also shut down. We stopped and checked the manual to identify what the symbols meant. We were approximately 90 miles from home, drizzling rain and it was about 60 degrees.
View 18 RepliesI am a technician and my boss owns a couple of prius taxis.
One of them had the code to replace hybrid battery pack. After checking all the cells and they were all in spec the code came back every single day so he bought a new hybrid battery pack. After installing the new battery pack The car won't go into ready mode with the message check hybrid system.
The code that comes up is P0A0D about the service safety plug. It is plugged in properly pushed all the way to the right and so on. The 120 amp fuse inside of it is good I have tried everything I can think of.We had another 2010 in the shop I tried changing the service safety plug, engine ecu, hv ecu, all to no avail with the same problem.
2002 Prius with 94K gave me today P3130, after I tested the Inverter Water Pump I found out that it bad but until I go to the dealer in order to buy the part $147 he was closed. the question is can I drive with the car like this bac home (65 miles) and if I turn on the A/C the Engine will work all the time right? And also after replacing the Inverter Water Pump how can i tell if the problem solved?
View 14 RepliesMy 2005 died in the middle of the road a few days go. Was just rolling along fine then suddenly out of a stop light, the car stalled and would no longer go back into P, D, or R while the battery still seemed to be working. So had it towed to the dealership to be checked.
View 5 RepliesI just bought a used 2008 Prius. I had my Prius inspected after buying it, and the error code C1378 appeared, which I have discerned refers to the Skid Control ECU.
There is apparently a recall for this part in 2010-2014 models, however as a 2008 I don't think I apply.
I have a 2007 Prius, and bought it used about 4 months ago. I have not had any issues with it until last night. Last night I was driving home and the red triangle with the “ ! “ in the middle and check engine light came on. The car seems to be running fine, but it scared me to see the lights come on...so this morning I called my local Toyota dealership.
NOTE: I recently went to them for an oil change and they informed me that I had three recalls on my vehicle that needed replacing, but I did not get them replaced because I was told it would take 5-6 hrs (which I didn’t have at the time).
Anyway, they told me that it would cost $70 to have the codes read...and that did not include parts that may need replaced... I thought that sounded a little high for just having the codes read so I went to my local Autozone and they gave me this code:
P0A93 - Inverter Cooling System Performance
I own a 2006 JDM prius with 323,000 km. The inverter coolant pump failed recently (got P0A93 code and no agitation in coolant reservoir). I ordered a replacement on eBay and am awaiting arrival. I may need to do some light driving in the in the interim and am thinking about installing a 10 inch fan in the space between the inverter/transmission and radiator to keep things cool. Is this wise or should I just let the car sit until the new pump gets here?
Also, I am burning oil...I usually have to top up 1 to 2 quarts in between changes. Is there anything I can do without tearing down the engine? A friend of mine suggested using Lucas oil stabilizer the next time I change oil...could this have any negative implications?
Pulling into parking lot and the triangle and exclamation light appear on dash. Drive about an additional hundred feet with what felt like lower power and no noises.
- Check 12V after about an hour and it reads 12.4 volts.
- Read codes and get P3125 sub code 325.
- Temperatures and HV battery numbers all looked good.
- Clear codes and immediately code comes back with no start, nothing. Did this many times.
This code and sub code lead to the inverter failing. Being that there was no noise as a MG2 stator failure this also leads to an inverter failure right as the MG1 motor starts the engine? Inverter pump still running good as it was recently replaced along with ATX fluid. Within the last two weeks two HV modules have been replaced.
I have a 2001 Toyota Prius. The inverter cooling pump was dead and I had the P3130 fault code. I replaced the pump and the refilled the fluid. After more than 4 or 5 times bleeding the system, now the pump sounds funny. It sounds like a water fall and look like it has too much air!!!! I can’t see any turbulence in the reservoir tank either.
There are 2 bleeding valves on the front side of the Inverter. Which one should be used to for bleeding the system? Both?
Does the system have any thermostat that could cause problem? Does it use the same radiator as the main one? What could cause having NO turbulence? I think the new pump will be dead too if it can’t make the turbulence.
2004 Prius, 149,000 miles. Driving on a highway when suddenly it felt like a headwind was bearing down on me, and a minute later, the red triangle of death and all the other lights came on. Did not totally lose power. Pulled to the shoulder and while waiting for the tow truck, started and turned the car off several times.
After the first few times, the red triangle did not light up, but the check engine icon remained on. The tow truck driver had a very difficult time getting the car into neutral to pull onto the flatbed, and then when he took the car off the truck to park it at the dealership, he said it shifted "hard" into drive.
I don't have a code since I don't own a reader. What this might be? I really, really hope it's not the traction battery needing replacement. I have no training to replace single cells.
I actually just bought a used 2004 Prius with 207,011 miles on it from out of state. I had a car shipped to me by a flatbed trailer. I just got the car the last weekend. However, It has a yellow engine light and a big red triangle with an exclamation mark (!) on a dashboard, and a red car with ! on top left of a display screen.
I drove it to a DMV to get it registered and took it to Pep Boys near my place since I have to get it an emission inspection within 10 days of registration anyways.
They ran a diagnostic test and found 2 current error codes (C2310-open/short in battery circuit & C2318-low voltage error) and 1 history code (P0A80-hybrid battery pack needs replaced), so they didn’t perform the inspection; otherwise, it would have a failed record). They told me that the car has had problems before and the problems are about a hybrid transaxle and a hybrid battery pack. They also told me that I need to visit a Toyota dealer to get them fixed in order to pass the inspection, and they warned me that is going to cost me a large four digit probably . So, they suggested me to just trade it in because it is not worth repairing. They also told me that a dealer who sold me the car probably would have done something to the car, that’s why it didn’t illuminate any warning lights before.
I tried to gather as much information as I could, so I asked the shipper if he noticed any warning lights but he didn’t think so; one thing he noticed was the hybrid battery isn’t charged because the engine started every time he moved the car.
I plan to take a car to another auto shop near my place as well in order to have them double check the issues and give me a repair estimate before taking a long trip to Toyota dealer.
Bunch of warning lights appeared and the dealer said it's code P0a80 and they recommend replacing the battery. I'd like to try to fix this myself and would like to hear your thoughts...
Plan is to check the traction battery for corrosion and use a voltmeter to test the cells and replace if needed. Prius 2004, 158,000.
I used an ELM327 to read codes with my BMW so when the check engine light came on my 2009 Prius I wanted to see what may be going on. It came back as a P0441. Going back to my BMW, it had a similar issue and changing the gas cap removed the code. So now I have a new cap on but the code remains.
I have a PCV on hand and plan on replacing that in the coming week.
I do not see where the PCV valve or spark plugs for that matter have been changed up to this point.
What I should be looking at with the P0441 code?
Have replaced dead cells on wife's HV battery over a month ago. Threw this P0a80 code today and will barely move. She idles into dealership and they say it's the battery, really!
View 2 RepliesOn my 05 Prius (65K miles) I recently had my local Toyota dealer replace both the inverter water pump (for free per recall) and main engine water pump (~$500 based on their recommendation because of some coolant leakage). 1 week later, I got the P1121 code coming off and on intermittently.
My dealer says that the work they did is not related to P1121.
I have 2005 Prius with 300k miles. I started throwing P0A80 code. I removed the battery and checked all the modules and found 2 of low voltage, ordered them from Ebay and replaced them. I placed the battery back in the car and started the car but got P0A80 code again. I purchased the grid charger from Hybrid Automotive and connected it according to their instructions for 24 hours. I drove a car but got the red triangle again and P0A80 code again. I removed the battery again and tested the voltage of all the modules and these are the readings:
View 4 Replies