Prius (2010-12) :: Replaced Transaxle And Inverter - Check Hybrid System Message
Jan 12, 2016
I have a 2010 Prius, currently at around 69,000 miles. Back in Feb 2015 (when it was just under 60,000) I was driving on a city street and hit the accelerator once a stoplight turned green - immediately as I took off (at a normal rate of acceleration) my 2010 Prius made a loud noise and I got the red triangle of death, with a "Check Hybrid System" message. The car quickly shifted into "limp home" mode and I was able to make it back home as I was only about a mile away.
Got towed to the nearest dealer the next morning and after tons of testing and going back and forth, they replaced the transmission and inverter (was able to get it covered under powertrain warranty), and I was on my merry way. No issues until last night.
Yesterday evening, I am on a city street and get a warning beep. I look at my dashboard and this time I have a yellow exclamation mark with the "Check Hybrid System" message yet AGAIN. Towed the car to the nearest dealer and am now waiting on next steps. Only update I've gotten so far is that they are still trying to diagnose the issue, and are getting 4 error codes in this process, 2 of which are new. I am waiting on the technician to tell me what the actual codes are - hopefully should get them tomorrow.
I would hope if it's another issue with transmission or inverter, it's covered under warranty given I replaced both less than a year ago. However I'm not sure and am worried that it's going to be $$$ in case it's something else that failed. Plus I'm getting serious doubts as to the safety of my car - what if I had been moving at a high speed on the highway during either of these situations?
View 9 Replies
Advertisement
The "Check Hybrid System" message came up on my dashboard. I took it to the dealer, and they said the temperature sensor on the transaxle was giving erratic readings. Unfortunately, they said that the only way to fix it is to replace the entire transaxle. They said I could keep driving it and that it would probably go into disabled mode before it caused any more damage. What I should do? It's a rebuilt 2012 Prius with 25k miles.
View 19 Replies
2010 Toyota Prius III with just under 60,000 miles. The car has been serviced at Toyota from day one (by us and by the previous owners) and runs like a champ. Well, did.
Last week while driving home from running errands the Check Hybrid System light came on for my wife. The car was still running so she drove it home for me to look at. I hopped in and noticed the gasoline engine wasn't turning on. I took it for a spin and even when I floored the car the gas engine wouldn't turn on. Since the nearest dealership is 15 highway miles away I knew we weren't going to make it there on electric power so I had it towed.
The Toyota dealership called me the next day saying when they started the car the light was gone and the car ran fine. They did some troubleshooting and found nothing wrong. They said it might have been a glitch and to come get the car. Not even 3 hours later the light turns on again. Again the gasoline engine goes silent, but this time I didn't even make it a mile and the electric power shuts off as well! We coasted to a stop and had to have the car towed again. This happened out of nowhere and could have been a very serious safety situation had it not happened on the road we were on.
This time the Toyota dealership had a little more to say. They said that their diagnosis has determined that the inverter is shot and they will have to order a new one. They said this failure is extremely rare (the service guy I spoke with had never seen this issue).
View 19 Replies
Searched for threads about this error message, didn't find much substantive except 'check your gas cap'.
View 7 Replies
I cleaned out hybrid battery cooling fan today, not too bad after 160K . However, as I test drove prius the Triangle of death and "Check Hybrid System" message pops up.
Drove 13 miles back home, battery charged good. No power consumption data given on hud. Rechecked fan connection and looked over area. All looked good. I dont think ICE was running during drive home. Tested 12 volt=good. Disconnected 12 volt and orange plug. Reconnected. System reboots and seems Ice goes through warm up. Even put in power mode and it roars. Scratching head on this. Coincedence or maybe I should have disconnected 12volt before disconnecting cooling fan?
View 19 Replies
I am having a gen 3 prius and yesterday when I am driving on a humpy road.(village side road) i got this message on the prius hybrid indicator screen, with orange color engine light and orange color triangle warning light. But still i can drive the vehicle and it charge the hybrid battery and everything going OK. I got really got fuel economy too after getting the warning message. Only thing is the message is appearing every time at the screen, What should i do now.
View 5 Replies
I Opened my 2011 Prius trunk to get the tire wrench to take my snow tires off, and install my main tires and rims. When I went to start up the car after it was done, I have a "Check Hybrid System" Message on the MFD. I wondered if I'd hit one of the 2 orange items on the Electric drive battery, that was exposed in the trunk, and I can't get rid of the message. The car is not drivable, the system doesn't read "READY" and the engine doesn't start.
View 8 Replies
I was driving down the road and suddenly the car stopped. The check hybrid system light came on, and it wouldn't go forward or backward. I had to have it towed. What has happened? Is it included in extended warranty?
View 8 Replies
My new-to-me (bought in May this year) 2010 Prius last night suffered. Nearing home on my usual 21-mi commute from work and on a secondary road, I was stopped at a red light. As I normally do when at a red light when a rather spirited start isn't needed (no or few cars behind me, not uphill, etc) I pushed the "EV" button to take advantage of electric acceleration up to 25 mph. All seemed normal as the light turned green and I started off. I don't know if I reached 25 or not - must've been close - when all of a sudden the acceleration stopped as if I'd taken my foot off the pedal when indeed I'd not. Simultaneously, a circus of lights lit up on the dash along with the fairly ominous message of "Check Hybrid System."
As with all things electronic these days, I figured a good ol' fashioned reboot was in order. Turned it off and back on and...same thing of course. Being near an intersection and a very bad place to be stopped - and not knowing if the car would actually move - I pressed the accelerator anyway, despite the warning lights, and indeed the car started to move. It seemed to cap the speed at 12-13 mph, which immediately seemed like some kind of self-protective safe mode. Luckily, I was within spitting distance from home, so I limped the last 1/4 mile in this state - and at 12 mph.
There are probably 5-6 warning lights on in addition to the big "Check Hybrid System" message. Let's see, first and foremost, the yellow triangle of death, followed by what I think is the Slip indicator (car icon with wavy lines), the CEL, the encircled exclamation point which I think is the braking system, and I forget, a couple of more. I should've snapped a pic but I was in a hurry to troubleshoot.
So I used my Actron scanner to pull the P0A94 code. I didn't see that it's able to read the sub codes, or maybe that's a capability that only the expensive dealer scanners have. Anyway, I can't conclude what it is other than the generic "DC-DC Converter Performance". I know that here and elsewhere there's a list of all DTC codes, and I saw that this code has 17 sub-codes, many of which are related somehow to the inverter, which seems to have been the subject of a recall in Gen II models (acutally the inverter cooling pump IIRC) but not on Gen III.
View 16 Replies
Went to start the car up this morning - foot on brake and pressed the Power button. The car went through its checks but when it finished the 'Welcome to Prius' graphic it did a continuous beeep and displayed 'Check Hybrid System' and didn't start.
I turned it off and tried again and on the third or fourth attempt the car eventually fired up, the error message was gone and there were no warning lights on the dash. The car did smell like it was running rich though.
I turned it off and called the dealers. They said if no warning lights are now on it should be ok to drive the 6 miles to see them and they'll check it on their computer. As I drove to see them the car was running OK but the fuel economy was shocking. I was getting about 40 mpg UK (30 US mpg) as a trip average.
View 19 Replies
My Prius yesterday while driving slowly (under 10 mph) all the dash warning lights came on(triangle, cel, trac control, brake). the gas engine started and the message came on that says: "check hybrid system". Today when I went out to check there only two warning lights on (triangle and cel) with the same message displayed. My question is can the vehicle operate without damaging anything if I drive it as is? I have read on several threads that the engine will not start if the hybrid motor(s) are not working. Since my engine starts and runs I have to believe the motor(s) are working.
View 19 Replies
1,500 miles ago my car had it's 30k service. Today, i got "CHECK...". At home this evening i checked the inverter coolant reservoir, it was empty. I've added 1L of de-ionised water (which got it to full, and i see turbulence in the fluid) until i can get the correct fluid.
View 13 Replies
Jumped into the Prius this morning to discover dash lights working, no radio etc so vehicle would not turn on. Replaced the auxiliary battery (about 5 years old.) Now all dash light, radio etc are looking great BUT:
- Enngine will not engage
- Message stating Check Hybrid System
- Various waning lights on dash (yellow waning triangle, swerve icon on left)(battery, brake, chech engine, steering wheel?) and abs!!!on the right)
View 6 Replies
I was driving my plug-in yesterday on the freeway and suddenly it alerted me the following:
Check Hybrid System
Stop the vehicle in a safe place
I pulled over to the side and tried to reset the message (push power button 3x), but message still was coming up. With my Toyota dealership not too far away, decided to bring in my car to have it checked out.
After 2 hours with their hybrid tech, they were not able to replicate the message (of course, always the case), but the tech was able to catch a P0C3E error from their diag tool. Being that they could not replicate the issue, they released my car and started to bring it back it the issue persist.
View 19 Replies
Yesterday while driving on the freeway in EV mode, my PIP (one of the first delivered to the states) flashed the "Check Hybrid System - Stop the vehicle in a safe place" message. I was near my house so I just went home. My SG2 showed code P0C3E, which is apparently an inverter over temperature code.
Took it to the dealer this morning and they just informed me that the car needs a new inverter, but no other details… "internal fault" is what he said.
While googling, i found this recall notice:
Green Car Congress: Toyota recalling about 701,000 Gen 3 Prius vehicles in US over software issue in inverter assembly
that doesn't talk specifically about the PIP and implies that it is a software problem, but goes on to say if the car is in a fault condition the inverter will be replaced. of course, it's possible that a software problem leads to hardware damage.
View 16 Replies
I just bought a used 2012 Toyota Prius iTech from a country town 3 hours away. About an hour into the drive home, the display informed me to "Check Hybrid System" and then "Check PCS System". The car continued to function for a little while, then eventually lost acceleration, so I pulled over. I turned it off and on again; the warning light remained but the car started and continued to work, but soon after I lost acceleration again. This happened one more time.
Then I Googled the problem and discovered that you could "turn it off and on again three times to reset the computer". I did this and the problem disappeared and did not resurface for the remainder of the trip, and has not happened again since.
View 1 Replies
Car was deemed a total loss. I didn't think the damage was too bad and one of my friends at a bodyshop told me to go ahead and do a car buy back that I can't go wrong with a prius. My mother said $20 gas a week. So I did and gave my mom the difference. The Car drives going forward and in reverse just find. Besides the body damage I got underneath the car and I see a bent tie rod end and maybe a lower control arm. The thing is when I hop inside to move the car I notice the car reads transaxle disengaged and battery system won't charge in neutral.
View 19 Replies
I have a 2005, I purchased new in 2005. I now have around 120,000 miles and have had no problems - just oil changes and new tires.
I was driving on the interstate in MS and all of a sudden all these lights come on on my dash including the triangle that means take it to your dealer immediately. The car sounded funny acted funny and accelerated funny. I was closer to home so I came home and called the dealer. They said to drive it in but if it started acting up to pull over and they would come get me.
When I cranked it, it sounded like I was pushing the accelerator but I wasn't so I cut it off then cranked it again. I drove it very slowly cause it was acting weird.
I drove it home to discuss it with my husband and to do some on-line research here. So 2 - 3 weeks later my husband decides to look at it and by now the little battery is dead - it is the original battery too -btw. So I bought a new toyota battery (the little one). My husband hooked it up to see if the car would crank. It did but all the lights on the dash lite up again including a couple new ones!
View 19 Replies
i un plug the battery and change the speedometer from US to CANADIAN. on a 2010 prius. Now the car dont start .The hybrid orange symble lights up and Check hybrid system shows on my desh.
View 8 Replies
Just started up my car and the "Check Hybrid warning system" came on, along with a check engine light. The car starts and moves, but I'm unsure if I should drive it to the dealer two miles away without doing any further damage to the vehicle or have it towed. The car has 130000 miles and is serviced every 5000 at the dealer with all recommended maintenance performed.
View 11 Replies
I have a 2013 Prius Persona with about 5,300 miles on the vehicle. Just recently had the 5,000 mile service taken care of at a local toyota dealership. The very next day I tried to start my vehicle with no prevail. My instrument panel indicates "check hybrid system" (!) the car will not start, nor will it shift into drive or reverse, only into the neutral position. Made several attempts to turn vehicle on and off and tried to jump start. Still no luck. Had the car towed back to the dealership. Mechanics are still trying to identify the problem. What may be the cause?
View 5 Replies
