Prius (2010-12) :: Engine Rough And Loud At Startup
Feb 12, 2011
I have driven 25,xxx miles on my 2010 Prius. Three times during the last thousand miles I have experienced very loud and scary engine noises during start up. The car had sat for at least ten hours outside in 20-30 degree weather.
I took the car into the dealership for an oil change and my service advisor told me that Toyota was aware of the problem and the noise was not coming from the engine- but a device that mates the ICE with the electric engine. He told me that although it was a loud and dangerous sounding noise, it was not something that would harm my motor. I asked that the noise be logged into my service record.
View 19 Replies
Advertisement
Mileage 192k. Signs...stumbling/rough engine startup for first time of the day and anytime the engine sits for a few minutes before turning on again (battery charging/speed high enough for engine to start, etc).
2010 Prius engine start stumble - YouTube
Started out with no code, then check engine light started coming on. P0301, misfire cylinder #1. Sparkplugs were replaced, and coil pack for #1 switched with known good one. EGR tube also cleaned of carbon.
Stumbling/roughness has been getting worse, about an inch of coolant used per week of driving. No oil in the coolant, and no coolant in the oil (no milkshake or anything like that).
Dirty fuel injectors were suspected, but no improvement after using Techron. Finally, a boroscope was used to inspect the cylinders through the sparkplug holes, and a very slow leak was found in cylinder #1. Since liquid cannot be compressed, during the compression cycle significant misfiring occurs.
View 19 Replies
Twice during the 6 months that we have owned our 2010 Prius, a loud clattering noise from under the hood occurred upon startup. After shutting it down and restarting, all was normal. It sounded like an engine that was getting ready to throw a connecting rod. The dealer could find nothing wrong and when I contacted Toyota's hot line, they were clueless as well. One service writer suggested the ABS as the source, but I've owned 5 other cars with ABS and never heard anything like it.
View 2 Replies
I once experienced the noisy engine start up.. It sounded like the engine was trying to run backwards or severe pre-ignition.
View 2 Replies
Initially thought that this was related to some water in the tank, since it started when the gas dropped to 1 bar (already put some stuff HEET when put the whole tank, did 60miles so far). ODB throws out multiple cylinder misfire (codes 300, 301, 302, 303 etc). It lasts up to 3 seconds. Sometimes the check engine pops up sometimes it doesn't. there was absolutely no problem under load. does it seem like a fairly common problem ? Intake manifold clogged ?
View 14 Replies
My 2010 Prius V just past the 24000km mark. I have a buzzing noise coming from the engine bay during startup. It happens when the interior fan is on. You can hear it clearly after you start the car, during the silence of the "boot up", before the ICE kicks in. I can't be sure if it continues to buzz after that because the sound of the ICE drowns it out. However, If I shut off the fan during the boot up, the buzz disappears. Finally, if I leave the fan off and start the car, there is no buzz.
During a recent oil change, a hybrid technician claims that this is normal. It used to happen infrequently but now it is consistent, so if it was normal, I should have heard it when the car was new.
View 1 Replies
Both my lowbeam bulbs went out at the same time on my 2011 back around 48k miles. I believe I read there is a TSB on this issue along with a strange engine rattle at startup.
View 5 Replies
Yesterday afternoon after warming up (car still in park) the engine shut down was very rough. I heard a quick string of maybe 5 or 8 loud bangs under the hood. Sounds like something got loose and banging inside the engine compartment and ready to fall off at any moment. This morning it was just a bit rough but not nearly as scary. Other than that the car seems to work fine.
View 1 Replies
I just bought a 2012 Hyundai Elantra GLS (Canadian model) with 44k km. When I first test drove the car, the dealer (Honda) had the car warmed up and ready to go. As a result, I didn't notice the loud engine or anything. All I noticed is the engine was louder on acceleration versus my 2008 accord. I already bought the car but today I asked to test drive the car again (I'm excited) and noticed a loud ticking on startup? I asked the Honda dealer what was wrong and they simply said Hyundais are louder than Hondas. My 2008 accord has a ticking engine already but Honda is rebuilding the engine. This car is ticking louder than my 2008 accord. However, the car does quiet down when the engine is warm.
View 2 Replies
When I start my car I hear this very loud noise. I think it is coming from the exhaust but not sure. This only happens when the car is cold(not weather) and after a few minutes the noise is gone. I have aftermarket lowering springs on the car, do you think that caused the problem?(I'm thinking no)...
View 4 Replies
Twice in the last month, my 2010 Prius has made this incredibly loud noise when the engine first started up. The noise continues for a minute or two, and then stops. The car then runs as normal. I brought the car to my dealer, who after a brief looking-over could find no reason for it. I shot a video of the car making the sound the 2nd time it happened and brought it to the dealership with me to play for the mechanic. No one who heard it there ever heard anything like it before.
It has been really cold here this winter, so "cold oil" was once thought, but was dismissed as unlikely. The car gets 0-20 oil.
View 19 Replies
We're having problem with our Prius where car suddenly started to make weird clunking noise from the engine (28k miles, 2011 Prius). Car sounds unsafe to drive around, so I left it parked in the drive way. I did check engine oil level and it was at F level.
View 4 Replies
When the battery power is low, the engine will kick in and then there is a loud "exhaust" sound. Are those really sound from the exhaust or some other fan?
View 5 Replies
I have a 2002 Prius that is running fine except for a loud noise when I started it up---like the one the exha fan in my bathroom makes, but the car runs well and there are no lights or any other indicator that anything is wrong. I am taking it to a local mechanic today, since I don't trust my local dealer. My car has about 95, 000 miles on it.
View 7 Replies
So my 2012 plugin was parked for about 3 days, and when I turned it on, heard loud knocking and the check engine light came and stayed on.
When switching the car on or off, I'll hear two taps/ticks that were not there before. Loud knocking is not there now.
What can the issue be? It was very cold and snowing.
View 14 Replies
I got in the car today and started it... I was waiting a few seconds for someone to get in the car (it was in the garage) and as soon as the engine kicked on there was a very very large long rattle noise i immediately turned the car off. Waited again and turned it on same noise.. the only thing I found was a cover under the car towards the front was really loose. ( I haven't hit bottom or anything while driving) but I did have the lighted door sills just installed the other day. But it never made that noise..
btw i have 1100 miles on it..I looked under it and is the black dust protector thing supposed to be loose like if I push on it I can make it rattle..
View 3 Replies
At 13,000 miles I've experienced the "rough start". Pulled it out of the garage to wash and wax it. I tried to put it in EV Mode but it wouldn't because the traction battery was down to only 3 bars, I assume. The engine only ran for 4-5 seconds than I shut it off, washed it and waxed it. Left it outside, temperature was about 55 degrees. When I went to start it about 2 hours later to run an errand it felt like the engine was down a cylinder and I shut it off immediately. I waited a minute and it restarted just fine. After reading the threads about the "rough start" I believe it happened because I didn't let it run through all the necessary cycles during the prior start up.
View 7 Replies
The first part of diagnosis is to understand how frequently this happens and hopefully find any reproducible patterns. This is an open poll running to the end of October.
ZVW30 - 1.8L Prius...
View 12 Replies
I have noticed in certain circumstances that the engine seems to be in a resonance where it is shaking noticeably and getting worse not better. It happens in two situations.
One is after gliding and slowing to make a turn (with the engine off). As I am exiting the turn and hit the gas the car shakes a lot for about a second or two, then smooths out.
View 13 Replies
I've been recently having the engine rattle/knock noise occasionally when I start the car. After my first oil change, I mentioned this to the dealer and demonstrated this to them while they documented the issue. I left my car at the dealership for investigation.
The following day, my dealer said they called Toyota and created a case about this. Toyota responded saying they heard about this and the possible root cause is the Motor Mounts on the Prius. They will be sending parts (date is still unknown) to fix the issue. :rockon:
I specifically asked if there is any damage to the engine and they said absolutely not and there is nothing wrong internally with the car. This also makes kinda sense because if I press the accelerator to the ground when it starts up, the knock doesn't appear. It also works if I put the car into D and drive away.
View 6 Replies
I've been recently having the engine rattle/knock noise occasionally when I start the car. After my first oil change, I mentioned this to the dealer and demonstrated this to them while they documented the issue. I left my car at the dealership for investigation.
The following day, my dealer said they called Toyota and created a case about this. Toyota responded saying they heard about this and the possible root cause is the Motor Mounts on the Prius. They will be sending parts (date is still unknown) to fix the issue. :rockon:
I specifically asked if there is any damage to the engine and they said absolutely not and there is nothing wrong internally with the car. This also makes kinda sense because if I press the accelerator to the ground when it starts up, the knock doesn't appear. It also works if I put the car into D and drive away..
View 11 Replies
