Prius (2004-09) :: Red Triangle With Code P0aa6 And Sub Code 612 Came On
Dec 24, 2015
have a 07 prius with 113k miles. It recently displayed the red triangle with code p0aa6 sub code 612.
I took apart the battery and nothing looked corroded, then on the inside of the bus bar i found a small amount of corrosion. After testing the cells i found 2 modules that were leaking voltage.
Since I had everything open I figured I might as well test to see if any cells were on there way out. The static voltages were pretty close around 7.8v, there were a couple modules that were .3v apart that I'm doing more testing on. I load tested each module with 1a, is 1 amp enough for a load test? I have a 100a load tester but figured that was way too much. They were all ok under load test, dropping about .6v and returning to original voltage within a few minutes.
Then I decided to check capacity on the bad cells, they were about 500mah, got to 1000mah after 1 discharge/charge cycle. I tested the capacity on a cell I thought was good and so far it discharged about 1050mah until it reached 6v, this was from 7.77v. I'm giving it some time to rest to see if it goes back up a bit and then I'll discharge some more till it stays at 6v. Even if I get a little bit more in it will be way under the 6500mah it should have or even the 3500mah that I've read is acceptable.
Since all of the modules have parameters that are pretty close I'm thinking the capacity will be pretty close as well.
View 19 Replies
Advertisement
I've got a 2006 Prius that was a model car--no problems at all--until it turned 4 years and 1 week old in April 2010. Then my aux battery died on 22 April, with just 31,583 miles on the car, and was replaced at Downtown Toyota in Oakland, CA. My dashboard lighted up after hours, and since my regular mechanic (Art's Automotive) was already closed for the evening, I had it towed to downtown Toyota. No huge deal, except for the cost of the battery/labor. The codes were: C2318, b1421, b1200, b1207, and b1271.
4 weeks later, on 22 May, I pulled into my driveway, and 4 lights came on: the MIL, the VSC, the yellow ! inside the circle, and the Hybrid System Failure icon on the MFD.
View 19 Replies
I picked up a 2004 Prius with 150k. It has no check engine light and no codes with a scangauge. I hooked it up to a mini-vci with techstream and found the following: P3009-526, C1310 and B1421. The car will only start if you reset codes, then after a few minutes of running the red triangle comes back.
View 10 Replies
Was driving home from school yesterday and my 2005 Prius turned the check engine light on and the red triangle light. Plugged into the scan tool it read: P0a80. I have a hybrid battery ordered. It should be delivered on Tuesday. How long can I get out of this failing battery before the car is undriveable? The Prius is my only vehicle and I don't have a problem with installing the battery, I just I'm wondering if the car will just drop dead on me before the battery gets here? The car appears to be driving normally with no loss of performance or MPG.
View 4 Replies
Seems like issues with my 06 prius battery are back, however this time it is rather strange but very predictable. I cannot read any trouble code as the red triangle on the dash (and "problem" on the display) never stays on more than a few seconds (1-5 seconds at most).
At first it was doing this only after long downhill driving (like my 1.5 mile downhill street at 25 mph) - charging the battery and once getting to the last green bar I would get a Bip, red triangle and "problem" on the display. This has been going on for 4 weeks roughly.
But it's gradually getting worse, the same symptoms would appear after shorter downhill driving. And now it does almost every time I get the foot of the accelerator (assuming the car has decent momentum to regenerate).
I am guessing a module is starting to fail but last time I had a failed block, it didn't do that. One day I got the red triangle along with a bunch of other lights and that was it.
View 5 Replies
Had a company install fog lights on my replacement 2007 Prius I picked up after I totaled my 2008. When i went to pick the car up, the car wouldn't start. Showed the triangle of death and threw a code that the 12v was bad. Probably from having the car off and testing the fog lights continually - resulted in a drained battery. I picked up a brand new yellow top optima battery and thought this would resolve my issues. Nope, once the batter was replaced, the car wouldn't go into Drive or Reverse, only park or neutral. The current code is P0A0D. The shop is baffled. They removed all modified parts and still can't figure out the issue. They are currently replacing the interlock plug in hopes that this will resolve the issue.
View 19 Replies
2004 Prius, 149,000 miles. Driving on a highway when suddenly it felt like a headwind was bearing down on me, and a minute later, the red triangle of death and all the other lights came on. Did not totally lose power. Pulled to the shoulder and while waiting for the tow truck, started and turned the car off several times.
After the first few times, the red triangle did not light up, but the check engine icon remained on. The tow truck driver had a very difficult time getting the car into neutral to pull onto the flatbed, and then when he took the car off the truck to park it at the dealership, he said it shifted "hard" into drive.
I don't have a code since I don't own a reader. What this might be? I really, really hope it's not the traction battery needing replacement. I have no training to replace single cells.
View 12 Replies
About 1500 miles ago, I replaced a cell in the battery pack. Now the triangle of dead is back and the code is "replace battery pack" again.
I tested all the cells and here are the results.
(the previous one I replaced was 4.5 volts, very low and easy to find)
View 9 Replies
I currently have a 2008 Touring Package 6 with 180k and I am getting weird problems. I am getting the triangle of death, VSC, and yellow ! light. There is no check engine light. On the LCD I am getting the red battery + - icon as well as the car hybrid icon. I scanned it and I am getting a hybrid code P0A09 . All of the maintenance have been kept up and all fluids are perfect. No weird noises and the car is doing 53 mpg. It switches between gas and electric with no problems at all. Symptoms were yesterday with the lights. I cleared the codes and they would come back instantly. Today, I did the same thing and now everything is perfect. I am attaching the pictures of my dashboard lights that were on and the codes I was able to obtain in diagnostic mode.
View 11 Replies
2007 Prius with 112k. It's getting the red triangle and check engine with code P3012. My understanding is P3012 points to 'Battery Block 2 Becomes Weak'. Battery block 2 is the 3rd and 4th modules counting from the end where the ECU is. These two modules test out the same as the other 26 modules in this pack, ranging from 7.40 to 7.46.
I got them this low by running A/C on high with car in neutral, hoping the bad module would show up. (Neutral prevents engine from charging HV battery.)
View 3 Replies
My Prius has started throwing the code P0A80, it all happened after I went away for work and left the car in storage for 15 days, during that time I left the OBD scanner plugged in and it drained the 12v battery, a quick jump start and it was back up and running.
While I was backing it out of the driveway the warning triangle came on and the MFD said "problem" the scanner showed the P0A80 code. I thought that was odd, but maybe related to the flat 12v battery and self discharge of the traction battery so I reset the code, it drove normally to the shops. When I restarted it and started to drive it threw the same code again.
I then installed techstream on my laptop to try and get some more in depth answers but was having trouble getting that running on Windows 8. So overnight I disconnected the 12v battery and would try again in the morning.
I got techstream working and connected it up to the car, connected the 12v and started it. While I was configuring techstream to graph the pack voltages I noticed something odd, the engine was being loaded and unloaded in 2 second cycles, and at the same time the inverter was whining as it does this. I was thinking maybe it's doing some sort of charge and measure cycle since the ECU's have lost any pack data due to the power loss of the 12v battery?
It ran like this for 20 mins or so and the engine stopped, techstream showed pretty normal cell voltages, I couldn't see any wild differences between the cells.
View 10 Replies
I'm guessing that I need to repair or replace the HV battery. But I'm not sure.
Today I drove for about 20 minutes with no issue. 10 minutes later, I got back in the car to drive again. This time, after about 20 seconds into the drive, a string of dash lights came on; Red triangle, VSC, Check engine.
The VSC light went away. But the red triangle and check engine light are still on. So, I had the trouble codes pulled by a mechanic, and the code P0A80 was returned along with a statement reading 'replace hybrid battery'.
Should I take this at face value? Or look for something else first?
2007 Prius - 150,000 miles
View 5 Replies
So I replaced my battery about 20k miles ago, so I know that's fine. I always throw a P0420, but I'm told that's fine too. So I was driving, and I lose power suddenly. The red triangle comes on, and I plug my scangauge II in, which tells me it's P0121, or the throttle body sensor. I reset the codes to make it home - my battery DID charge just fine on the way home, making it up to a 63.5 state of charge. Now when I start it, and press the gas, it tends to rev up, rev down, and repeat. I haven't gotten the red triangle again yet but I also haven't driven it since then.
View 2 Replies
My check engine and red triangle light came on. I checked the code and it's a battery issue. The code is P0A7F. I called the dealer and they want me to bring the car in for a check. I have about 117,000 miles on the car. They have a service bulletin open. I would like to avoid paying large dollars for a new battery.
View 7 Replies
07 Prius. So I get the triangle of death, car shuts down, and throws the A093 code indicating pump failure.
View 10 Replies
Is it safe to drive my '02 with the triangle on the dash? I've tried to get rid of it, throttle body cleaned, MAF cleaned, battery seems good (13v, no load). What else can I do to try and get rid of it? BTW, '02 Prius, 183K mi. It runs good, cycles on and off normally (motor to battery, etc.). The code clears it self after sitting about a week w/ occasional starts, then I drive it for about 50-70 miles and the light comes back on...
View 7 Replies
Working on a 2010 with 156k miles that threw a P0A80 on two separate occasions. Once before the 12v battery was changed, then the day after the 12v change. Decided to change the HV traction battery today with one from a wrecked 2014 with 56k miles.
After changing the HV batt I started getting the yellow triangle with no code associated with in. I would clear the code and drive the car a few minutes and then the triangle "check hybrid system" would appear.
View 14 Replies
I have a Toyota prius 2008 with 130,000 miles. I kept getting red triangle sign, the car will slow down and will need to pull over, shut it down and restart. I went to the dealer. First they diagnosed 12V battery issue, so we got that replaced. The red triangle sign kept coming, so we went to the dealer again, they replaced transmission fluid. They said it was low on transmission fluid. The red triangle sign kept coming. So we went to the dealer again. They said it is transaxle internal problem. The diagnostic code is P0A37. I have a couple questions. In California, what is the warranty for Transaxle problem. In some posts I saw 180,000 miles, 10 years. The dealer said they called Toyota and Toyota does not cover the repair. It is a costly repair. Second , is this code really requires Transaxle replacement.
View 16 Replies
I have around 68k miles on my 2009 Prius and just got a CEL, the Red Triangle with an exclamation point, an intermittently occurring VSC light, and an intermittently occurring yellow circle with an exclamation point on the upper dash display. I also have a car shaped icon with an exclamation point on my main display (ICE?). My scan tool shows P0093 as the only code.
View 19 Replies
I got red triangle and headlight icon on the screen. I hooked OBD and It gave me error code P1116, I checked all my front, back lights are working fine.
View 19 Replies
2002... 184,000+ miles
I was driving the car and triangle popped up and engine would not shut off while parked (key on) I hooked up the non prius aware scanner (carry one with me at all times) and don't remember the code, but it was a "HV malfunction".
I didn't shut the car off to clear the code as I was not home and attempted to drive it home, meanwhile engine never shut off. I had to come to a complete stop at a red light and the car died. tried restarting it but nothing. so I pushed it off to the side of the road and cleared the code. Tried again and nothing. didn't start, nothing. it beeped and error code popped up. Checked the code and it was p3125.
I know there are subcodes but online it was leading to inverter. but I replaced the inverter last year with a re involt. I had the car towed to my job for $50, to have it towed home, would cost roughly $168. When I got it to work, I did the screen thing and checked the 12v battery and it was reading 10.9 I have been meaning to get a new one for about a year now so I did.
I purchased a new optima battery and installed it yesterday, cleared the codes, tried to start it and nothing. error code p3125. What leads me to believe that it may be a transaxle, well actually a Mg2 is when my inverter went bad, it would start then shudder and die then the triangle would pop up. this time around, it doesn't even start. I have an appointment with the dealership to get the code with subcode read on Tuesday 10/15 for $98.7.
View 7 Replies
