Prius (2004-09) :: Hybrid System Warning And Triangle Of Death Light On
Mar 9, 2015
A few days ago I was driving my 2005 Prius aggressively up a mountain road and all at once the hybrid system warning light, the triangle with the exclamation point, and the regenerative brake system warning lights came on.
After about 2 minutes parked, I restarted the car and the regenerative brake system warning light went off, but the other two were still on. I still drove it twenty miles home, over another substantial mountain gap (about 1000 ft up and another 1500 down), without any problems.
I checked the voltage of the 12v battery, which seemed to be on the low end, but OK. (I think the lowest reading was 11.9). There seemed also to be some turbulence in the inverter coolant reservoir.
I brought it into the electronic vehicle specialist in town here today, who pulled my codes and said that the hybrid battery was dead.
View 5 Replies
Advertisement
I have been using it since last 10 months and was totally in love with this car.. But recently, an error showed up on MFD as well as the engine checklight came on. all this happened after a while, when i started the car one fine the morning..
car stats:
model: 2008
mileage: 123300Km
bought at 92000Km and was trouble free till now..
View 5 Replies
During a highway trip three months ago, my 2004 Prius suddenly lost engine power, the red triangle Master Warning light came on accompanied by a warning sound, and then the Hybrid System Warning sign appeared on the Multifunction Display. I pulled off to the side of the road and stopped. I turned the car off and then tried turning it on again. Engine power was restored although the warning lights remained. We took a chance and carried on with our trip. The same sequence of events reoccurred about 10 times on our 1,300 km journey. I took the car to a Toyota dealer where they found a C2318 DTC. They checked the battery and the HEV fuse but could not locate the problem.
We returned home and on the way the same thing happened a few more times. My service manual noted that the description for C2318 is Low Voltage Error (Power Supply Malfunction) and the trouble areas are HEV fuse, IGCT relay, Wire harness or connector, or Auxiliary battery. Since the car was nearly 7 years old I thought I had nothing to lose by replacing the battery, which I did. However, on a short 150 km trip last week the problem appeared again, once while approaching our destination and once when we were almost home. There seems to be a pattern in that the problem appears every 150 km or so of highway driving. It has never done it while driving in the city.
View 19 Replies
I have an 07 Prius which I bought used in 2011 and which has been fine (except for some A/C work last year) but got the 'triangle of death' this morning and having towed it to my regular shop, they tell me the code (they couldn't give me the number) simply said 'replace hybrid battery'... the car has 102,605 on the clock.
View 9 Replies
I have a 2007 toyota prius. The car drives, but pulsates. The Check engine light and triangle of death are on. Diagnostic test says "replace hybrid battery pack", but wouldn't the car not even start if the bat pack were dead? What it could be? perhaps a bad cell or two? a bad ecu?
View 19 Replies
I own a 2005 Prius with 233K miles. I got the terrible red triangle of death and several other warning lights. Had the codes checked out at Toyota and confirmed a bad HV battery. I am kinda handy and I replaced it myself. No big job, it took about two hours, most of which was spent removing the interior panels, etc. Test drove the car and all looked well. Thirty or so miles later, BAMMM, lots of warning lights. At this point I took it to my mechanic to have it checked out. They found nothing you wouldn't expect when you've disconnected the two batteries.
They cleared the codes and off I went. Again about thirty miles out the lights went on again. Back to the garage once again. What they found was a corroded connector running to the fan, located under the rain gutter of the hatch, passenger side. Hmmm, how'd that get corroded?? Two years ago I remember drain the sump where the spare's located of 6 inches of water, how'd that get in there??? My mechanic confirmed he has seen that before in the Prius. So now I am wondering, did the initial battery fail because the fan may have failed??? Perhaps we need a warning light.....
View 9 Replies
Possible hybrid battery failure in my 2004 Prius (96K miles).
Sunday before last, the check engine light, warning triangle, and hybrid warning light came on when I started my car at the grocery store.
Because I was close to home, I drove home and the car functioned completely normally. The next morning, when I started the car, the same warning lights appeared. However, when I tried starting my car with the headlights off (I always leave them on), no warning lights appeared.
I took my car to an independent mechanic. This is their written report:
"Found multiple check engine codes, P3000, sub code 123, V0100 sub code 211/330. These codes are set when high voltage control detects a malfunction in battery pack/ECU assembly. To check battery pack we took vehicle out on a test drive while monitoring the cells in the battery pack. Found that they are all weak and drop fast when battery is put under a load. Code C2318 is a low voltage error/power supply malfunction code with the auxiliary battery. The voltage spec for setting the code is 9.3 volts, this battery is less than 9.2 volts."
In conversation, the mechanic also told me there was significant voltage variation across the cells in the hybrid battery.
I then took my car to the dealer to try to confirm this analysis. They were unable to read any codes because the independent shop apparently cleared them. The dealer was unable/unwilling to do more than read the codes to diagnose the problem. (Indeed, they seemed surprised that the independent mechanic could monitor the cells in the pack.) All they did was to drive the car around some more to see if the check engine light would come on. It did not.
The car has been driven 80 miles since the warning lights last appeared and appears to be behaving normally. From your perspective, does the report from the independent mechanic make sense and is it believable? And is their test under load definitive of a hybrid battery problem? Could the results be affected by the low auxiliary battery? Also, if I do have a hybrid battery problem, what are the chances of being suddenly thrown into limp mode while driving it?
View 5 Replies
First off I have a 2010 with about 11,000 miles and it has been running great since I got it. This morning I was greeted with the "Yellow triangle" and the "check hybrid system warning". The car started fine and I pulled out of the garage under battery as usual and then the engine kicked in also as usual, everything seemed normal except for the warning lights. Since I have a long commute I just took my wife's car and got to work and did a forum search on this issue. I called my wife and had her turn the car on and off three times and she said it cleared the yellow triangle and check hybrid system but it still had the check engine light on. She also said the car seemed to be running fine and shes driving around town in it. I couldn't find anything on the check engine light. Is it ok to drive it?
View 3 Replies
My wife has a '03 that has been great. No issues. I am a excellent mechanic, on conventional cars and motors. Here's my story:
Bought the car used and working last week. Put in a new 12v Group 26 battery w/conversion. I verified the 12v battery was at 12.8v and when engine was running, 13.6v to charge the battery. Car was starting and driving wonderful for about 600 miles. No shuttering, no shaky starts. Mileage was about 38.6. Anyway, yesterday was driving and all of a sudden the warning Triangle comes on, Hybrid system icon comes up and the engine goes off. I was able to drive the car about 1/2 mile on the traction battery back to my work.
It happened to have a code reader handy and it reads a P3125, Inverter. I realize there are sub codes that further diagnose the issue, but I don't have that type of OBDII reader although mine is a very expensive model. Anyway, I reset the code and got the car to start. Motor begins to go up in RPM and throws the code again. I shut it off, reset the code, try to start the car and I feel it slightly jump forward, engine does not start, then throws the warning code again. I did notice the traction battery is at 25%. I do this two more times trying to get the engine to start before I call the tow company. BTW, the car rolled easy, so I don't think its the MG2 is bad, although correct me if i'm wrong but doesn't Mg1 start the engine?
Oh, incidentally, also the ignition key does not release either. The key release solenoid is energized unless I unplug the 12v battery, then I can get my key out.
View 19 Replies
My wife just called and said this light came on. She said when it came on the car turned off its cruise control but kept running. Now she says it seems to be running fine but the light is coming on.
The car has around 110k miles and I just replaced the spark plugs, air filter and engine oil about 1k miles ago. What it could be? I'm going to have her pull codes at the auto parts store but she needs to do about 20-30 miles of driving today for work. Is it safe for her to do so?
View 17 Replies
My hybrid system warning light came on last night in my 2005 Prius with about 89,000 miles. The car may have run out of gas (I wasn't driving). This car will only take about 8.5 gallons when the fuel light starts flashing. I started it this morning, light was still on, only 2 bars on battery, my car usually runs near the green, and the gas engine stalled after about 30 seconds. The gas indicator was flashing, so I added a 1/2 gallon I had at the house, and unplugged the 12v for about 10 minutes to clear the system. Upon restarting, fuel light was still flashing, but no hybrid warning light. Drove a few miles, filled up with gas, and drove another mile.
So my question, could running out of gas and driving a very short distance (light came on as my wife turned into our driveway), cause this warning light to come on? If so, will there be any lasting effects? Did unplugging the 12v battery clear the computer codes, or can I still get these read to learn more about what happened?
View 2 Replies
I have a 2005 Prius with 135k miles. Yesterday the red exclamation light came on and also the hybrid system warning light. I shut the car off and it came on again. The third time the car started normally and it is driving normally today with no warnings. Does this sound like the 12 volt battery? It is original.
View 6 Replies
This morning i picked up my friend from her house and got into my Prius to start driving away, immediately after entering ready mode it beeped, the red triangle came one, the MFD said something like 'problem' or 'error', I don't remember the exact word and then two symbols came up. I turned the car on and off again and it was all still there. I drove anyway for about a mile to my other friends house where i turned the car on and off again and everything went away. The whole time the car felt fine, there was nothing wrong with it yet it had the triangle/symbols on the MFD.
View 7 Replies
The last few weeks I've been noticing that, upon start, the hybrid battery is showing at 1 line. It's been really hot in SO cal and the air con has been blasting, so I've been letting it charge up a bit before driving. Once I'm on the road, the battery charges fine and seems to hold a charge.
View 10 Replies
I have had no issues with this car of 120K miles until today, although my MPG has decreased to 35 MPG. The following lights came on with a loud beeping sound : Brake warning lights, malfunction indicator light, master warning light and the hybrid system warning light. These stayed on for 25 minutes and then went off. I drove 12 miles without any issues with all the lights and sounds beeping.
View 4 Replies
I have been having some hybrid battery issues. My prius is a 2006 with 198,000 miles. The original battery was replaced at around 120,000 with a junkyard battery. About a year later that battery gave up the ghost and I decided to rebuild that battery. So far that has worked quite well until recently.
My troubles started a couple weeks ago when I got the Red triangle and all the dash lights and the hybrid system icon on the MFD. Naturally I thought it was the battery again. Took it out and checked the voltages of the modules. All the modules where within tolerances. I grabbed a OBDII scanner and checked the code. It was telling me that the Hybrid current sensor was bad. I changed that out with the wiring harness from the old battery.
That lasted for a few days before the red triangle came back. I checked the code and it was indicating one of the blocks was bad. I think P3019. So I took the battery back out and replaced that block with other modules. Almost instantaneously the red triangle came back with two more bad blocks. I think it was P3012 and P3022. So I took the battery out once more and tested all the voltages of all the modules. Everything was 7.86-7.9v. So I decided to start the rebalance of the existing modules in hopes to find some bad modules.
I also bought a new 12v battery and installed that. I got everything back together and took it for a road test. It took about 30 mins before the triangle came back. I grabbed the codes and it was still indicating bad blocks. P3011 and P3018. I am a little at a loss.
View 3 Replies
I've got some issues with my 2005 Toyata Prius (~150,000 miles). My wife was driving recently and the "Master Warning Light", the "Hybrid System Warning Light" and the yellow "Brake System Warning Light" all came on.
Some quick reading of the owners manual said we should take it to a dealer right away, but because it was a yellow, and not red, brake system warning light it seems ok to drive at least to a dealer. in regard to the yellow brake system light the manual said it could be that: "the regenerative brake system failed or that the hydraulic brake system failed".
Now, I have a cheap bluetooth OBD reader hooked up to the "torque" app on my phone and I thought I would try to see what error codes there were to learn more. But strangely, it did not read any fault codes. I've used this reader successfully on my 2001 Mitsubishi galant, but I'm not reading anything for the prius in this case. I'm not sure if there is legitimately no error code associate with the warning lights or if my app is just failing to read them for some reason.
View 19 Replies
My wife was driving our 2009 prius this morning. she said the red triangle, this other yellow circled, light with an ! came on plus in the display window the car icon with the ! came on. Manual states that this is a hybrid system failure.
On very cold mornings the car smells very hot for a period of time. She said this happened again.
I tried to do a reset (turning it off and on atleast 4 times) did not work. So I had it towed to a dealer tonight and I started it again and this time very hot smelling and a whole lot more lights were on, ( brakes lights, almost all of the lights I would say.)
View 10 Replies
My 2007 proud of 180k miles which hasn't had any issues up until now just randomly gave me this error, where the red triangle of death, vsc, and tire pressure ((!)) Sign came on. It drives fine and there is no check engine light.
View 16 Replies
I am a new Prius owner. I just purchased a 2008 with 27k miles yesterday, and last night I got the "red triangle of death". My car is currently back at the dealership after a very expensive tow. I only got to drive it for about 4 hours.
Before the break down, I was extremely excited to finally have a Prius, and was really happy with my purchase. I'm still excited about having the car, but I'm also highly disappointed that it broke down the day I bought it! I sure hope this isn't a sign to come! I see that most people love their cars, and I've read that they consistently get high dependability ratings.
View 19 Replies
2005 with 123,000 miles. I have owned for a few thousand miles. Car was dealer maintained at every recommended interval. Car runs perfect.
After car sat for a week or so, I drove it and the red triangle popped up along with PROBLEM statement and take to immediately to dealer symbol. Red Triangle and other warnings repeats every once in awhile - will go a day without, and then will come on and off within a couple miles. Car continues to run fine. There are no other check engine lights. I have checked all the fluids and they are fine.
The battery charges fine, and holds the charge overnight. I have a generic code reader and there are no codes. I have read other posts, and there are always problems that seem to come with the Triangle. Gas mileage is fine as well.
View 19 Replies
